2008 BMW X3 engine problems

Related recalls

• Recall 17V683000Oct 30, 2017740,561 vehicles
  ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)

  BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.

  Risk: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.

  Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.

What owners say

1. Filed Mar 18, 2026AKFireElectrical SystemEngineOther / Unknown

   I am reporting a vehicle fire involving my 2008 BMW X3, which had an active safety recall for the Positive Crankcase Ventilation (PCV) valve heater (Recall Campaign No. 22V-119). This recall identifies a risk of short circuiting, overheating, and potential fire. On February 27, 2026, I contacted BMW after discovering multiple active recalls on my vehicle. I specifically asked whether the vehicle was safe to drive. After consulting internally, I was advised that I did not…

   NHTSA complaint #11725396 · source
2. Filed Mar 12, 2024MAEngine

   The car no longer starts. When towing it to a BMW dealership, they informed me that there is a problem with the VANOS bolts and that "they snap easily"; however after some research into it I realized that these engines have a recall for this specific issue only that my vehicle isn't listed under the recall. I believe this is a mistake and that it should be.

   NHTSA complaint #11576993 · source
3. Filed Feb 29, 2024200,000 miRIEngine

   The contact owns a 2008 BMW X3. The contact stated that while driving at 20 MPH in cold weather, there was smoke coming from the engine compartment. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted; however, the contact received no response. The contact stated that the failure was related to NHTSA Campaign Number: 22V119000 (Engine and Engine); the VIN was included. The…

   NHTSA complaint #11574752 · source
4. Filed May 12, 2023180,000 miPATowedEngine

   The contact owned a 2008 BMW X3. The contact stated while driving at an undisclosed speed, he turned on the heater and became aware of smoke coming from under the hood of the vehicle. The vehicle then started to overheat, and the coolant temperature warning light and the check engine warning illuminated. The contact stated that he veered off the road and turned the vehicle off. The contact then stated that he waited a few minutes and allowed the engine to cool down.…

   NHTSA complaint #11521716 · source
5. Filed Feb 28, 2023MAEngine

   The contact owns a 2008 BMX X3. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The local dealer was notified of the issue and confirmed that parts were not yet available for the recall repair. The manufacturer was not notified of the issue. The contact had…

   NHTSA complaint #11509460 · source
6. Filed Nov 18, 2022NVEngine

   The contact owns a 2008 BMW X3. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was unavailable. The contact stated that the dealer was contacted and stated that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that the parts were not yet…

   NHTSA complaint #11494175 · source
7. Filed Nov 10, 2022115,000 miCAEngine

   The contact owns a 2008 BMW X3. The contact received notification of the NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling). The contact stated that after attempting to turn on the heat, the heat failed to properly operate. The contact stated that the heat was either too low or too hot. The contact was concerned that the system would overheat. No warning lights were illuminated. The dealer was notified of the failure and the contact was informed that parts were not…

   NHTSA complaint #11493060 · source
8. Filed Nov 3, 202278,000 miGAEngine

   The contact owns a 2008 BMW X3. The contact stated while driving 30 MPH, the engine was shutting off inadvertently. Several unknown warning lights were illuminated. Additionally, the contact stated while driving at an undisclosed speed, the vehicle stalled in the middle of the road. The contact was unable to veer to the side of the road. The contact was able to restart the vehicle after several attempts. The contact drove back to her residence. The contact stated that the…

   NHTSA complaint #11492106 · source
9. Filed Oct 26, 2022169,935 miTXEngine

   The contact owns a 2008 BMW X3. The contact stated while driving 25-30 MPH, he smelled a burning odor and saw smoke coming out from underneath the hood. The contact veered to the side of the road and allowed the vehicle to cool down. The contact was able to continue driving. The contact stated that the failure had been reoccurring. The vehicle was taken to several independent mechanics who informed the contact that they could not duplicate the failure. The contact later…

   NHTSA complaint #11491015 · source
10. Filed Aug 10, 2022170,000 miCAEngine

    The contact owns a 2008 BMW X3. The contact stated when she picked up her vehicle from the dealer after having NHTSA Campaign Number:17V683000 (Engine And Engine Cooling) completed while driving at 40 MPH, the vehicle started overheating. The contact was able to pull over and when shutting off and attempting to restart the vehicle, the vehicle would not start. The dealer was contacted, and they stated the vehicle needed to be diagnosed. The manufacturer was contacted, and…

    NHTSA complaint #11478694 · source
11. Filed Jul 13, 2022200,000 miGAEngine

    The contact owns a 2008 BMW X3. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, there was smoke coming from underneath the hood and the exhaust pipe. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure…

    NHTSA complaint #11473749 · source
12. Filed Jun 29, 2022CAEngine

    The contact owns a 2008 BMW X3. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was unavailable. The local dealer was contacted and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN…

    NHTSA complaint #11471567 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology