2011 Chevrolet Corvette problems, complaints & recalls

2011 Chevrolet Corvette recalls (1)

• Recall 11V491000Oct 3, 20115,755 vehicles
  STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS

  General motors (gm) is recalling certain model year 2011-2012 chevrolet corvette coupe vehicles, manufactured from january 24, 2011, through september 1, 2011, for failing to comply with the requirements of federal motor vehicle safety standard number 206, "door locks and door retention components". The rear hatch hinges may not meet the load requirements specified in the safety standard.

  Risk: The rear hatch could separate in the event of a crash, increasing the risk of injury.

  Remedy: Gm will notify owners and dealers will replace both rear hatch hinges free of charge. The safety recall began on october 14, 2011. Owners may contact chevrolet at 1-800-630-2438.

Recent 2011 Chevrolet Corvette complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Jul 19, 2026TXFuel, Hybrid & EV Propulsion

   I bought this vehicle in XXX with about 39k miles. About a year after purchase, I began smelling gasoline in my garage after I filled the tank. I have consulted Corvette forum ([XXX]) and find this is a common problem. If I fill the tank more than halfway, it seems to occur consistently. I recognize this car has no warranty, but this seems to be both common and a serious safety concern. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint #11751403 · source
2. Filed Feb 15, 2026FLFuel, Hybrid & EV Propulsion

   My 2011 Grand Sport Corvette fuel system was repaired on 2/14/22 at no cost to me by special policy 15682-03. Now, 4 years later, the same problem has occurred again. I notice fuel smell in my garage with the tank nearly full after fill-up, and upon inspection, I notice evidence of fuel leaking along the side of the primary tank behind the driver's seat which is the same problem encountered before. GM tells me no additional help for repair is not forthcoming due to the age…

   NHTSA complaint #11718067 · source
3. Filed Oct 9, 2025CAFuel, Hybrid & EV Propulsion

   Fuel pump feeder is known to be a major issues on these cars. These should be a safety recall with no explanation. Feeder fitting tends to crack overtime. Recently purchased and wasn’t aware of that previous recall which the previous owner didn’t handle.

   NHTSA complaint #11692236 · source
4. Filed Jul 19, 2025TXFuel, Hybrid & EV Propulsion

   Fuel is leaking from the top of the driver side fuel sending unit. This is a know issue on these cars and should be fixed under a recall. This is a very dangerous issue.

   NHTSA complaint #11674701 · source
5. Filed Jun 27, 2025CAFuel, Hybrid & EV Propulsion

   I bought a 2011 Grand Sport Corvette and if I fill the tank over half full the gas smell is unbearable. Some one needs to recall these cars. This issue is very serious. Fuel leaks out the top of the tanks, and will then drip down the back side onto the hot exhaust. If ignored this could result in a fire and possible death. If parked overnight in a garage, the vapor will fill the garage and could easily be triggered into an explosion and fire from a gas water heater or other…

   NHTSA complaint #11669852 · source
6. Filed Sep 30, 2024TXFuel, Hybrid & EV Propulsion

   Fuel pump elbow at top of driver side tank cracks and allows fuel to leak out of plastic piece. Many have the same issue and all we got was a very temporary fuel pump recall. Engine light is on

   NHTSA complaint #11617223 · source
7. Filed May 12, 2024TXEngineFuel, Hybrid & EV PropulsionOther / Unknown

   My entire garage is filled with gas fumes after I filled my car up to full yesterday. I drive my car once every 2 weeks and this is filling my garage with fumes. There are no visible leaks, there is a technical service bulletin regarding a gas tank issue that expired. What component or system failed or malfunctioned, and is it available for inspection upon request? UNKNOWN, the vehicle is available for inspection. How was your safety or the safety of others put at risk? I…

   NHTSA complaint #11588339 · source
8. Filed Feb 15, 2024FLFuel, Hybrid & EV Propulsion

   Same fuel smell issue as what GM kinda covered with Bulletin #[XXX] However that is a 10 year / 120,000 miles limit. I'm under the miles but over on time. Just purchased the vehicle (was told "there are no recalls" because they were allow to all it a "Special Warranty Adjustment". Of course the previous owner didn't get this addressed ... nor WOULD they if the smell started later. So ... still a fire hazard ... even the fix offered is replacing plastic parts with same…

   NHTSA complaint #11572203 · source

Compare the 2011 Chevrolet Corvette with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 11, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology