2021 Chrysler Pacifica fuel, hybrid & EV propulsion problems

Related recalls

• Recall 23V010000Jan 17, 202367,117 vehicles
  ELECTRICAL SYSTEM:WIRING:CONNECTORS/PLUGS/RECEPTACLES · HYBRID PROPULSION SYSTEM: INVERTER

  Chrysler (FCA US, LLC) is recalling certain 2017-2023 Pacifica Plug-In Hybrid Electric vehicles (PHEVs). An internal transmission wiring connector may short circuit, resulting in an unexpected engine shutdown.

  Risk: An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash.

  Remedy: Dealers will update the Power Inverter Module (PIM) software and, if necessary, update the instrument panel cluster (IPC) and the electronic control module (ECM) software, free of charge. FCA US will notify dealers and begin notifying owners on or about: 03/21/2023 for 2021 model year vehicles, 05/02/2023 for 2019-2020 model year vehicles, and 06/15/2023 for 2017-2018 model year vehicles. FCA began notifying owners on February 23, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 03A.

What owners say

1. Filed Oct 2, 2026IAFuel, Hybrid & EV Propulsion

   The contact’s daughter owns a 2021 Chrysler Pacifica. The contact stated that while operating the vehicle, there was a strong fuel odor inside the vehicle. The contact’s husband inspected under the hood and became aware that there was a pin-sized hole in the fuel line and that there was fuel leaking inside the engine compartment. The contact stated that the fuel supply line was touching the engine and the vibration from the engine had caused the pinhole in the fuel supply…

   NHTSA complaint #11768440 · source
2. Filed Sep 28, 2026MOElectrical SystemFuel, Hybrid & EV Propulsion

   Our van will not charge when plugged in and a message on the dashboard says "Service Charging System". Also, the car will not go into reverse when turned on and the gear is showing in "R", reverse. It will not let me back up out of our garage.

   NHTSA complaint #11767417 · source
3. Filed Sep 28, 2026FLElectrical SystemFuel, Hybrid & EV Propulsion

   Vehicle is a 2021 plug-in hybrid minivan within the population of an open safety recall for internal high-voltage battery failure that can result in fire, including while parked and not charging. The recall remedy, performed at a dealer, consisted of a battery control module software update intended to detect the defect, plus battery pack inspection and replacement if flagged. Approximately six weeks after the recall remedy was performed, the malfunction indicator lamp…

   NHTSA complaint #11767407 · source
4. Filed Sep 9, 2026ALElectrical SystemFuel, Hybrid & EV Propulsion

   I am reporting a critical manufacturer-imposed restriction that prevents the completion of a life-saving safety campaign, Recall 52D (NHTSA ID: 24V362), which carries a strict "Park Outside and Do Not Charge" advisory.My vehicle has an active fault code P0E15 (Electric Coolant Heater control performance), which is a well-known, widespread factory defect in Chrysler Pacifica Hybrids. When I took the vehicle to an authorized Stellantis/Chrysler dealership to perform the urgent…

   NHTSA complaint #11762950 · source
5. Filed Jul 30, 2026MDEngineFuel, Hybrid & EV Propulsion

   Driving on the interstate at high speed, when check engine light comes on, warning message - Stop Safely Vehicle Will Shut Off - and red turtle warning indicator (limp mode). After a short time, vehicle will no longer accelerate. I pulled over to the shoulder, stopped and shut off engine. Restarted after a few minutes and everything appeared to work fine, with check engine light on. About 15 minutes later, it happened again. The dealership serviced the vehicle. Found error…

   NHTSA complaint #11753704 · source
6. Filed Jul 28, 2026PAElectrical SystemFuel, Hybrid & EV PropulsionTransmission & Drivetrain

   This 2021 Chrysler Pacifica Hybrid has a severe and recurring history of catastrophic high-voltage hybrid powertrain and transmission failures that cause a sudden loss of motive power while driving, presenting an immediate safety hazard. The vehicle has already required two full automatic transmission (eFlite EVT) replacements under factory warranty due to internal failures. It has experienced multiple high-voltage component repairs, including software modules for the power…

   NHTSA complaint #11753330 · source
7. Filed Jun 19, 2026NVElectrical SystemEngineFuel, Hybrid & EV Propulsion

   My 2021 Chrysler Pacifica Hybrid has a recurring hybrid/electrical defect that causes the accelerator to lose all power while driving, leaving the vehicle unable to accelerate or respond to throttle input. The vehicle remains “on,” but it cannot move under its own power and must be coasted or pulled over immediately. This has happened in traffic, including with children in the vehicle. The dealer confirmed fault code P1A21‑00 and documented that the high‑voltage system can…

   NHTSA complaint #11745325 · source
8. Filed Jun 3, 2026CAFuel, Hybrid & EV Propulsion

   While driving the vehicle, the accelerator will become inactive and result in the vehicle slowing to a stop. I will shut off the ignition and let vehicle rest for 10-20 mins before restarting. This does not resolve the issue and I end up towing the vehicle into the manufacturer’s service department. This often results in 100s of dollars in “diagnostic” fees. The service dept claims it’s bad battery, changes and issue arises again. Next they say it needed a software update,…

   NHTSA complaint #11741712 · source
9. Filed Mar 30, 2026GAFuel, Hybrid & EV PropulsionTransmission & Drivetrain

   I encountered two incidents of the same type. One was on Friday, March 27, 2026, the same day I picked up the vehicle from a local Chrysler dealership, where software updates and issues related to recalls were supposedly completed. The vehicle was at 38% battery level at the time of pick up from the dealership parking lot. After driving it for about 14 miles, the battery level depleted to <1% and that's when the "Stop Safety. Vehicle will shut off soon" displayed on the…

   NHTSA complaint #11728146 · source
10. Filed Mar 19, 2026PAEngineFuel, Hybrid & EV PropulsionAcceleration & Cruise Control

    While driving at normal road speed, the vehicle suddenly lost propulsion and entered limp mode. A turtle warning icon appeared along with multiple system fault messages. The vehicle began slowing down on it's own and was unable to accelerate. I pulled to the side of the road. The vehicle displayed an error "Stop Safely Vehicle Will Shut Off Soon". After sitting for a period of time, the vehicle restarted and was able to be driven again, but the failure occurred without…

    NHTSA complaint #11725453 · source
11. Filed Dec 18, 2025OHElectrical SystemFuel, Hybrid & EV PropulsionTransmission & Drivetrain

    Reversing onto roadway and shifted from reverse to drive via rotary dial and vehicle went into park and would not move causing me to block the roadway. In addition and even more concerning was that the vehicle could not be turned off and any and all actions to do so just left the car "on" and the hybrid system running. Eventually we pulled the battery cable on the main 12v in the trunk and the reset allowed us to move the vehicle again. I sat across a busy section for twenty…

    NHTSA complaint #11705779 · source
12. Filed Oct 21, 2025WAFuel, Hybrid & EV Propulsion

    High pressure fuel leak with large fan spray pattern in fuel line part number 68492134AA where it sits and rubs against a sharp corner of another component, (appears to be ignition coil) above the rear passenger side of the engine. Searched online and found another owner had posted an image of the exact same leak! https://www.reddit.com/r/ChryslerPacifica/comments/1amcdp9/2021_pacifica_hybrid_fuel_leak/Their photo and mine are identical and in comments on their thread, Two…

    NHTSA complaint #11694762 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology