2023 Ford Bronco engine problems

Related recalls

• Recall 26V468000Jul 20, 2026565,691 vehicles
  ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD · ENGINE

  Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco and Bronco Raptor vehicles. The engine compartment wiring harness may become damaged and short circuit.

  Risk: A short circuit in the engine compartment can create heat or spark, increasing the risk of a fire.

  Remedy: Dealers will install sheathing over the wiring, free of charge. This is a Phased campaign. Phase 1 will include 2026 Bronco Raptor notified owners on 7/31/2026. Phase 2 will include 2021-2025 Bronco Raptor vehicle will notify owners on or about 8/14/2026. Phase 3 will include 2021-2026 Bronco will notify owners on or about 9/1/2026. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S55. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 23, 2026.

What owners say

1. Filed Sep 24, 202632,752 miAZDriver Assistance & Safety TechEngine

   The contact owns a 2023 Ford Bronco. The contact stated that the vehicle experienced an issue with the rearview camera while in use. The contact received a notice for NHTSA Campaign Number: 26V124000 (Back Over Prevention), and the recall repair was subsequently performed. However, after the recall repair was completed, a new 'overheating' warning appeared on the infotainment system. The vehicle was returned to the dealer, where technicians tested the system and confirmed…

   NHTSA complaint #11766792 · source
2. Filed May 4, 2026VAFireEngineFuel, Hybrid & EV Propulsion

   My husband was sitting at a stop light when he noticed what appeared to be steam/smoke coming out from under the hood of the Bronco. Then smoke came into the vehicle through the air vents. When he looked up, flames were coming out from under the hood. He got out and the whole front of the car burst into flames and torched the car.

   NHTSA complaint #11735666 · source
3. Filed Apr 25, 2026NVEngine

   Going 80 on the fwy. It stared shaking, engine light came on. Immediately go off the fwy as soon as I stopped it died and wouldn’t start.

   NHTSA complaint #11733715 · source
4. Filed Mar 5, 2026NYElectrical SystemEngineFuel, Hybrid & EV Propulsion

   The vehicle experienced recurring electrical system failures beginning in December 2023. The vehicle intermittently would not start and on several occasions lost power unexpectedly. The vehicle was taken multiple times to an authorized Ford dealership for diagnosis while still under the manufacturer warranty. The dealership repeatedly reported that no issue could be identified despite the recurring electrical malfunction. The vehicle battery was replaced more than once…

   NHTSA complaint #11722270 · source
5. Filed Dec 17, 2025OKEngine

   Check engine light stayed on, constant. Code run showed cylinder 4 misfire. Bronco still under warranty so took to dealership. Mechanic said coolant was inside cylinder so he requested recommended remedy from Ford and would probably be engine replacement.

   NHTSA complaint #11705547 · source
6. Filed Jul 28, 202550,200 miCAEngineTransmission & Drivetrain

   The contact owns a 2023 Ford Bronco. The contact stated that while driving at an undisclosed speed and flat towing an RV, the Flat-Tow mode inadvertently disengaged and the contact smelled a burning odor permeating the interior of the vehicle with the message "Stop vehicle immediately, excessive temperature detected" displayed. The transmission temperature warning light was illuminated. The vehicle was taken to the dealer, who determined that there was damage to the…

   NHTSA complaint #11676815 · source
7. Filed Jun 2, 2025NMEngine

   Engine began to leak air in intake where this is a faulty problem in the previous two models years and is an active recall on them also, 23 Ford Bronco, began to misfire causing to have to get engine replaced

   NHTSA complaint #11664312 · source
8. Filed Nov 18, 2024CAEngine

   My engine has had a knocking problem since 3000 miles. Everytime I take it to Ford they agreed it has a knock but won't fix the problem stating it's normal and some engine knock more than others. The engine knocks at low rpm when stepping on the accelerator then smooths out about 1500 to 2000 rpm. One mechanic said it's an issue but they won't fix it unless it has a catastrophic failure this is unacceptable to me as they just want the vehicle to fall out of warranty when the…

   NHTSA complaint #11626073 · source
9. Filed Nov 18, 2024COEngine

   My vehicle has the 2.7L V6 Ecoboost engine. This engine apparently has a design defect that results in repeated cam phaser failure. My engine recently had cam phaser failure and I had them replaced. A week later I was driving at speed on a highway when my engine completely died. I had to pull to the side of the road and could not restart my engine. I ended up being towed to a dealership and am awaiting diagnosis.

   NHTSA complaint #11625971 · source
10. Filed Oct 9, 2024TXEngineWheels & Tires

    We installed new tires and wheels on our vehicle and it immediately started having engine problems and the check engine light comes on. We took it to the dealer and after several days back and forth Ford told the deal that it's a known problem with the 2.3L version of the Ford Bronco however they had no fix and no timeline to fix the problem. This creates a safety hazard as the engine program can't be updated and could cause damage to the engine and cause it to fail. The…

    NHTSA complaint #11618945 · source
11. Filed Jun 2, 2024FLBrakesEngineAcceleration & Cruise Control

    When driving or breaking at slower speeds, the car feels as if the transmission is “slipping” and the car jerks forward. The same thing happens when braking the car.

    NHTSA complaint #11591983 · source
12. Filed Mar 24, 2024ALEngine

    My 2023 Bronco with 6k miles died without any warning back in late January 2024. Ford service dept said it was a failed catalytic converter. After it was in the shop for a 1.5 months, waiting on the back ordered part, we picked up our truck around March 10. Fast forward to today, truck has 7k miles. We were southbound on the interstate in bumper to bumper traffic heading to Disney World when the truck’s engine died, yet again. Luckily we were not traveling typical interstate…

    NHTSA complaint #11579199 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology