2023 Ford Maverick Hybrid engine problems

Related recalls

No recalls on file.

What owners say

1. Filed Jun 1, 2026TXEngineTransmission & Drivetrain

   Eninge started knocking, flashed warnings to pull over immediately. I did and had the vehicle towed to Westway Ford in Irving. Their investigation showed the engine needs a full rebuild and they are claiming it is not covered under warranty. They shared pictures & a written repair estimate. Doing an analysis of the pictures they took and their description of what happened, combined with what I experienced and observed, this appears to be a textbook case of the behavior and…

   NHTSA complaint #11741298 · source
2. Filed Mar 18, 202645,300 miPAEngine

   The contact owns a 2023 Ford Maverick. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. There was a fuel odor on the exterior and interior of the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with a fractured fuel seal. The vehicle was not repaired. The contact was advised to take the vehicle to the…

   NHTSA complaint #11725203 · source
3. Filed Mar 17, 2026TXEngine

   Per the dealership my vehicle is throwing the same codes P1061 and P032F as the recall that is less than a month from when my vehicle was built. My vehicle knocks and then the speed drops to less than 35 miles and it happened to me in traffic. It is very dangerous and again this is the same issue as the recall for my 2023 that is for other 2023 vehicles. I have called Ford to get help and file a complaint but am getting zero help. Again this is a very dangerous event that is…

   NHTSA complaint #11724855 · source
4. Filed Dec 2, 2025MIEngineAcceleration & Cruise ControlTransmission & Drivetrain

   AUTOMATIC REVVING INCIDENT 1 DATE: November 25, 2025 TIME: about 4:05pm LOCATION: [XXX] WEATHER: Slight rain, around 37º F VEHICLE STATUS: In Park, heat dial turned on. DESCRIPTION OF ISSUE: Turned key to on position while in park. ICE engine immediately turned on and revved all the way, as if the accelerator pedal was pressed down all the way. Pedal was NOT under floor mats. Immediately turned key to off position, let sit for a moment. Turned key to on position again and…

   NHTSA complaint #11702611 · source
5. Filed Nov 5, 2025GAElectrical SystemEngineTransmission & Drivetrain

   This exact situation has occurred twice in the past 6000 miles driven. Both occurred while driving at highway speeds, once on I85N and once on I75N in GA. Our 2023 Ford Maverick XLT Hybrid suddenly and unexpectedly loss power and shutdown. This forced us to make an emergency stop and attempt to pull over in high speed, heavy traffic in both instances. The vehicle eventually restarted and was drivable with a check engine light illuminated. The DTCs were read with an OBDII…

   NHTSA complaint #11697663 · source
6. Filed Aug 20, 202580,000 miWATowedEngine

   The contact owns a 2023 Ford Maverick. The contact stated that while driving approximately 65 MPH, the check engine warning light illuminated, and the "Service Engine Immediately" message was displayed. The contact stated that the vehicle started losing motive power. The accelerator pedal was depressed, but the vehicle decelerated to 5 MPH. The contact stopped and had the vehicle towed to a dealer, who was unable to determine the cause of the failure. The vehicle was not…

   NHTSA complaint #11681949 · source
7. Filed May 4, 2025TNDriver Assistance & Safety TechEngineTransmission & Drivetrain

   While traveling 80 MPH using cruise control, the vehicle speed suddenly reduced and several warning lights illuminated. The three warnings were Pre-Collision Assist Not Available, Service Engine Soon Warning, and Powertrain Malfunction / Reduced Power. The accelerator pedal did not work but I was able to coast to the nearest exit. I stopped, turned the vehicle off and back on a few times but the warning lights would come back on. When I shifted the transmission into Drive…

   NHTSA complaint #11658823 · source
8. Filed May 3, 2025GAElectrical SystemEngineTransmission & Drivetrain

   2023 Ford Maverick Hybrid XLT lost all engine power at highway speed in the left lane of [XXX] . Red Warning Triangle with notice to pull over and Check Engine light with codes P0811, P0E71 and P1920. Truck then went completely dead, no electrical indication on the instrument panel and would not start. I towed it to the dealer and they said they reset and reloaded software on the PCM and BCM, but no explanation of what caused the issue to occur. Very unsafe for everyone if…

   NHTSA complaint #11658623 · source
9. Filed Jan 17, 202544,000 miSCEngine

   The contact owns a 2023 Ford Maverick. The contact stated the check warning engine light was illuminated. The vehicle was taken to the dealer who diagnosed the vehicle and determined that the exhaust gas recirculation (EGR) valve sensor had failed. The sensor inside the valve failed due to condensation getting into the valve and short-circuiting the sensor. The EGR valve sensor had been replaced. The manufacturer was made aware of the failure and opened a case. The…

   NHTSA complaint #11636494 · source
10. Filed Dec 24, 2024OKEngineOther / UnknownTransmission & Drivetrain

    While driving down US-69, while attempting to pass a vehicle at about 80 mph, the vehicle shut off and proceeded to stop accelerating, as well as started to slow itself down. The instrument cluster flashed quickly before shutting off, and the radio also shut off. The cabin lights came on, and I had to switch to the right lane to quickly get onto the side of the road where it gradually slowed itself down and threw itself into park. I had taken the key out, and simply turned…

    NHTSA complaint #11632260 · source
11. Filed Dec 19, 2024CAElectrical SystemEngineVisibility & Wipers

    Rear window driver side passenger failed and won’t go up or down bad regulator Transmission failure needs replaced at 1 year old Rear camera frozen no remedy on recall Engine failure during acceleration shifts to neutral then shifts to acceleration Engine acceleration at slow stops jerks forward during breaking Tires 1 year old under 25k miles no tread and needs replaced already Display shuts off randomly and stays frozen

    NHTSA complaint #11631549 · source
12. Filed Nov 18, 2024CAEngineTransmission & Drivetrain

    Loss of motive control ongoing issue. This is documented problem being investigated by NTHSA, R2Q4014. Functional issue: • Engine flips into Neutral unexpectedly. Vehicle coasts to a stop, where it flips into Park on its own. • Vehicle requires a restart to move gear out of Neutral. After restarting vehicle, vehicle can operate on limited power that maxes out at about 35 mph. Acceleration is dramatically reduced, gradually ramping up as the vehicle continues to drive — the…

    NHTSA complaint #11625995 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology