2026 Hyundai Ioniq 9 electrical system problems

Related recalls

• Recall 26V068000Feb 5, 202627 vehicles
  ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY

  Hyundai Motor America (Hyundai) is recalling certain 2025-2026 IONIQ 5 and 2026 IONIQ 9 vehicles. The high voltage battery system may contain an improperly tightened bus bar, which can cause a short-circuit.

  Risk: An electrical short in the high voltage battery system increases the risk of a fire.

  Remedy: Dealers will inspect and tighten the bus bar retention bolts and replace the battery system assembly, as necessary, free of charge. Owner notification letters were mailed April 3, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 294. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 7, 2026.

What owners say

1. Filed Aug 11, 2026CAElectrical SystemEngineTransmission & Drivetrain

   Driving on a public road with a 50 phone speed limit, I received an error message on my dash stating electrical failure, and then the car shut down and began to coast, I had use all my strength to turn the car towards the curb and coasted to a stop. I received an error message from multiple components and then the dash went blank.

   NHTSA complaint #11756108 · source
2. Filed Aug 6, 2026VAElectrical SystemFuel, Hybrid & EV Propulsion

   On 8/3/26 my Ioniq 9 had a warning message to Check the Electrical System, but provided no additional information. I was able to drive the car home, anticipating that I be able to take it in to the Hyundai dealer where i purchased the vehicle. It should be noted that the car went into limp mode (max 25 mph) for the final six miles to my home. I researched the issue on line and determined that it was possible to get the car to the dealer based upon the experience of other…

   NHTSA complaint #11755299 · source
3. Filed Jul 22, 2026CAElectrical System

   An Integrated Charging Control Unit (ICCU) failure halts the vehicle’s ability to charge and power the 12-volt battery. When it fails, the car can no longer keep the 12V battery charged. This drains the 12V system, potentially causing a sudden loss of motive power while driving or a "bricked" car that won't start. The presents a safety problem because it happened while I was driving and the car slowed down to a halt in a high speed traffic area. This is a well known issue…

   NHTSA complaint #11751977 · source
4. Filed Jul 14, 2026WVElectrical System

   ICCU failure. Warning lights came on in the dash and diagnostic codes were available in my Hyundai app. My family and I had just gotten back from a road trip and if the ICCU would have failed while we were on the trip we would have been stranded and it would have been during the heat wave. The vehicle is currently in the service department waiting for the part to come in.

   NHTSA complaint #11750459 · source
5. Filed Jun 26, 2026ORElectrical SystemTransmission & Drivetrain

   My 2026 Hyundai Ioniq 9 (Performance Calligraphy AWD), leased new in late April 2026 from Team Hyundai of Bend, OR, suffered an Integrated Charging Control Unit (ICCU) failure at approximately 1500 miles in late June 2026, roughly two months into ownership. The failure progressed over several days. First, at a ChargePoint Level 2 (AC) station, the vehicle repeatedly displayed "charging started" every few minutes in a continuous start/stop/retry loop. Within days, AC charging…

   NHTSA complaint #11746752 · source
6. Filed Jun 21, 2026CA1 injuredBody & StructureElectrical System

   The motorized flush door handles lack an automatic anti-pinch resistance sensor when retracting. If an object, hand, or child’s finger is caught inside the door handle while the vehicle locks, the motor continues to force the handle shut. This creates a severe crushing and entrapment hazard. This is available for inspection upon request. My child’s finger got caught in the door handle while the vehicle was locking. There have also been several near miss incidents. The…

   NHTSA complaint #11745506 · source
7. Filed Jun 13, 2026MAElectrical SystemFuel, Hybrid & EV PropulsionOther / Unknown

   On XXX, at approximately 2:20 PM, while driving about 30 mph on a suburban road in [XXX], a red battery warning light appeared on the main instrument cluster. I pulled over and contacted Hyundai support. When I attempted to resume driving, the vehicle accelerated sluggishly with noticeably reduced power. I pulled over a second time and parked with the vehicle still powered on. While I was on the phone with Hyundai roadside assistance, a red ‘Stop vehicle and check power…

   NHTSA complaint #11743940 · source
8. Filed Jun 4, 2026CTElectrical System

   On XXX, my 2025 Hyundai Ioniq 9 displayed a battery fault warning (DTC P1AAF00). I was instructed by Hyundai to bring the vehicle to a dealership immediately as other Ioniq 9 owners had experienced sudden and complete loss of motive power during highway operation. The vehicle has been at Pacifico Hyundai in [XXX] since that date. I was initially told the battery control module required replacement with only 7 units available nationwide. On May 5 I was informed via text that…

   NHTSA complaint #11741955 · source
9. Filed Jun 2, 2026NYElectrical SystemFuel, Hybrid & EV Propulsion

   The Integrated Charging Control Unit (ICCU) on this vehicle produces loud whirring noises when charging at 80% or above. This has been documented in writing to the service department. The ICCU defect is a known systemic issue across the Hyundai and Kia EV platform. The vehicle is currently scheduled to return to the dealer for this and other defects. This is the second major service visit on a vehicle leased in March 2026 that was already out of service 28 consecutive days…

   NHTSA complaint #11741651 · source
10. Filed May 21, 2026COElectrical SystemOther / UnknownAcceleration & Cruise Control

    I was driving on the highway at 70 mph approximately with my young daughter in the backseat. All of a sudden, the front display on my Hyundai Ioniq 9 went completely black and said "no signal." I lost all dashboard information about my speed, gas gauge, horsepower etc. The only thing I could do was see how fast I was going because I was on google maps and my audiovisual screen in the center was still working. I drove 15 min with this to the dealership. The signal never came…

    NHTSA complaint #11739235 · source
11. Filed May 10, 2026MNElectrical SystemEngineAcceleration & Cruise Control

    Was driving down the highway when Check: electric vehicle system warning came on and car slowed suddenly and wouldnt go past 41MPH. Within a min, the car slowed down further and just as I was pulling on the shoulder. Car didnt have power to move after.

    NHTSA complaint #11736905 · source
12. Filed Apr 14, 2026CTElectrical SystemTransmission & Drivetrain

    Vehicle was operating perfect then got alert indicating electrical system fault but vehicle still drove (was just 2 miles from home ) but then alarms sounded and just able to pull off road before vehicle died. Checked and see code DTC PIA9096 and car was inoperable after. Towed to dealer for replacement of ICCU module. They acknowledged they have seen this before. I was on a local road, but if this happened on a highway, would have been more hazardous!

    NHTSA complaint #11731046 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology