2016 Hyundai Santa FE engine problems

Related recalls

No recalls on file.

What owners say

1. Filed Sep 4, 2026TXEngineTransmission & Drivetrain

   1. Component/System Failure & Availability: The failed component is the engine's internal Camshaft Variable Valve Timing (CVVT) phaser backing bolt within the 3.3L V6 engine assembly. An internal factory bolt unthreaded, backed out, and physically pierced directly through the upper valve cover. The vehicle and intact failed engine are currently located at an authorized Hyundai dealership service center in [XXX], and remain fully available for immediate physical inspection by…

   NHTSA complaint #11762257 · source
2. Filed Jun 11, 2026NYCrashTowedEngine

   WHAT FAILED: The engine — the 3.3L Lambda II GDI V6 (engine family GHYXV03.31XE per the federal emissions label) — failed catastrophically: a connecting rod penetrated the engine block. The failed engine IS available for inspection on request. It has been preserved unrepaired since the failure, the rod penetration of the block is externally visible, and the vehicle is currently at Niagara Hyundai in New York. WHAT HAPPENED / SAFETY RISK: On [XXX], I was driving at…

   NHTSA complaint #11743619 · source
3. Filed Jun 6, 2026GAEngine

   I filed a complaint when the first engine seized. It's a miracle we got off the road safely that day. While it was at the dealership, the engine was replaced with a used engine and covered by my extended warranty from Vroom. I believe the cost was approximately $14,000. I was told the engine had around 30,000 miles on it. I've put around 20,000 miles on this engine and the same thing happened again. This time, the engine had been knocking for a few months. When it started…

   NHTSA complaint #11742460 · source
4. Filed May 25, 2026NCEngine

   Purchased a used Santa Fe in January 2026 with 129k mile and at 131k my vehicle's CEL came on and did not function properly while operating. While driving the vehicle failed to accelerate above 25 mph when I pushed the gas. I pulled over to get out of the way of traffic and avoid any accidents. I shut the car off and sat for several minutes before restarting my vehicle. It successfully restarted and I drove home and parked it. I ran CEL diagnostic and received the code…

   NHTSA complaint #11739964 · source
5. Filed Apr 21, 2026PAEngine

   Rod bearing failure while driving, engine made a clanking noise. Engine made a loud bang and shut off. It was difficult for the driver to get control of the vehicle and get it to the side of the road. Engine threw the rod and piston through the oil pan causing catastrophic internal damage. The oil had been changed the day prior. The company that changed the oil sent an inspector to evaluate car at the scene. He stated this is a known problem with this engine. He pulled up…

   NHTSA complaint #11732856 · source
6. Filed Mar 19, 2026OHEngine

   Beginning about a month ago, I noticed a rattle upon the engine start up that lasted for a 1-2 seconds then stopped and everything sounded normal. I thought it could be b/c of the cold weather. I went in to get a routine oil change on 03/11/2026 and they said the oil looked fine, but it was about a quart low, indicating it was burning some oil somehere. They said to check in in a few months and they would top it up if needed. I asked them about the rattle and they thought is…

   NHTSA complaint #11725475 · source
7. Filed Sep 19, 2025150,000 miVATowedEngine

   The contact owns a 2016 Hyundai Santa Fe. The contact stated that while driving 60 MPH and attempting to depress the accelerator pedal, the vehicle decelerated and failed to respond as intended. The contact coasted to the right side of the road, turned off the vehicle, and the vehicle failed to start. Neither an independent mechanic nor a dealer was contacted. The vehicle was towed to an independent mechanic; however, the vehicle was not diagnosed. The contact was informed…

   NHTSA complaint #11688502 · source
8. Filed Sep 7, 2025ILEngine

   My engine failed at 113,000 miles. It just sounded like a diesel truck when I started it one day. There were no warning messages at all. It did not have any power above 45 mph. I took it to a Hyundai dealer and showed him the extended warranty letter I received from Hyundai. The letter said my specific engine should qualify for an extended warranty. However, the dealer (Castle Hyundai of Downers Grove, IL) said because my engine failed due to timing chain failure and not…

   NHTSA complaint #11685544 · source
9. Filed Aug 4, 2025OREngine

   My 2016 Hyundai Santa Fe lost all power, shutting off and stopping abruptly in the middle of the road with no warning lights or “limp mode” being set off requiring my partner and I to push it into someone’s driveway with our two children in the car to get them to safety. We took the vehicle to a mechanic shop where we were told that to engine was seized and needed to be fully replaced with an initial quote starting at 8 thousand dollars for a replacement engine. I contacted…

   NHTSA complaint #11678240 · source
10. Filed Feb 27, 2025145,322 miTXTowedEngine

    The contact owns a 2016 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power with the check engine warning light illuminated. The vehicle was towed to an independent mechanic, where it was diagnosed that the engine had failed and needed to be replaced. The vehicle was not repaired. The vehicle was towed to the dealer, where the same diagnostic information was provided. The contact was informed that the engine needed…

    NHTSA complaint #11645352 · source
11. Filed Feb 7, 2025NYEngine

    This is my 2nd engine on my 2016 Santa Fe Sport. My car has 190,000 miles and had a catastrophic engine failure, it’s been at the dealership for 2 months. Hyundai said my lifetime warranty on my engine is not covered cause I had a misfire in the #4 cylinder with less than 2,000 miles on the spark plugs. Hyundai warranty department only spoke to the dealership directly and had me speak to a case manager (which did nothing, they never even talked to the warranty department…

    NHTSA complaint #11641440 · source
12. Filed Jan 13, 2025NYEngine

    While driving down the highway at 65mph my 2016 Santafe Sport experienced engine failure. We sat on the side of the highway, next to an on ramp with high traffic beside a cement wall. When the tow truck arrived the driver was nearly ran over! There was no way to get the car to a safer location. After being towed to the dealership they said the engine failure would be submitted under warranty due to an issue with the connection rod bearing damage causing the engine to fail.…

    NHTSA complaint #11635757 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology