2013 Hyundai Veloster electrical system problems

Related recalls

• Recall 23V132000Feb 28, 202325,715 vehicles
  ELECTRICAL SYSTEM

  Hyundai Motor America (Hyundai) is recalling certain 2012-2014 Veloster vehicles. High conductive liquid may leak into the Reverse Park Aid Sensor (RPAS), which can result in an electrical short circuit.

  Risk: An electrical short circuit increases the risk of a fire.

  Remedy: Dealers will inspect and replace the RPAS fuse and sensor, as necessary, free of charge. Owner notification letters were mailed July 28, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 242.

• Recall 19V204000Mar 14, 201916,487 vehicles
  ELECTRICAL SYSTEM:SOFTWARE · ENGINE

  Hyundai Motor America (Hyundai) is recalling certain 2013 Veloster vehicles that are equipped with 1.6 liter turbo engines. The engine management software may cause premature ignition (pre-ignition) of the air/fuel mixture in the engine. The resulting excessive cylinder pressure may damage the engine.

  Risk: Engine damage can increase the risk of a fire or cause an engine stall, increasing the risk of a crash.

  Remedy: Hyundai will notify owners, and dealers will update the engine management software, free of charge. The recall began May 14, 2019. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 182.

What owners say

1. Filed Oct 5, 2026TXFire1 injuredBrakesElectrical SystemEngine

   My 2013 Hyundai Veloster caught fire spontaneously while it was turned off and parked in my garage. The fire originated in the engine compartment, specifically around the ABS module area. The vehicle has an open and incomplete safety recall for this exact issue (Recall 251 / NHTSA Campaign 23V-651000). The Mission Fire Department responded to the scene to extinguish the fire

   NHTSA complaint #11769195 · source
2. Filed Sep 20, 2026LABrakesElectrical System

   My 2013 Hyundai Veloster experienced a catastrophic failure of the ABS module covered under Recall 23V-651 (Campaign 251). The brakes went completely to the floor while operating, and the ABS module is shorting out every replacement fuse, creating an imminent engine fire hazard. Hyundai Corporate has explicitly refused to remedy the underlying defective component causing this fire hazard, only offering to replace the blown fuse. This is a direct failure by the manufacturer…

   NHTSA complaint #11765616 · source
3. Filed Feb 27, 2026OHElectrical System

   I am writing regarding a serious safety issue with my 2013 Hyundai Veloster, purchased new. Over the life of the vehicle, I have replaced the manual AC/heat control head three times due to repeated failure. During the most recent installation, I left the trim panel off to monitor the wiring harness and found it becomes extremely hot while operating. A local repair technician examined it and immediately advised me not to use the heating system due to potential fire risk.…

   NHTSA complaint #11720871 · source
4. Filed Feb 24, 2026CAElectrical SystemEngineFuel, Hybrid & EV Propulsion

   "CATASTROPHIC ENGINE FAILURE & INEFFECTIVE RECALL REMEDY (NHTSA 19V-204): ​While traveling at highway speeds, with my two children and boyfriend, the vehicle went completely black. Car loss complete power, going into a limp mode( 'Loss of Motive Power') The Check Engine Light began flashing before going solid. When I was able to pull to the shoulder, I tried to start the car and noticed the radio screen was black and stayed black(before this time, the screen would some times…

   NHTSA complaint #11720265 · source
5. Filed Jan 29, 2026OHElectrical System

   Electrical wiring harness and connector melting and blower transistor overheating with know Hyundai internal documentation, all causing a smoke smell and fire hazard. I'm on my 3rd manual Heater / HVAC Control Unit. Fire risk acknowledged by Hyundai dealership and customer affairs. Forced to pay diagnostics fees despite know safety issues, Cost for repairs out the door around 2,450 out the door. Car sitting at the Hyundai dealership waiting for me to repair or not. I cant be…

   NHTSA complaint #11714229 · source
6. Filed Sep 2, 2025NCFireElectrical SystemEngineOther / Unknown

   On or about May 1, 2025, I was operating my 2013 Hyundai Veloster when flames were observed emanating from under the hood. I immediately pulled into the median and, upon opening the hood, observed an active fire beneath the plastic engine cover. I contacted 911. Before the fire department arrived, a passerby extinguished the flames with a fire extinguisher. Firefighters from a nearby station arrived shortly thereafter and fully doused the engine compartment. The vehicle was…

   NHTSA complaint #11684545 · source
7. Filed Aug 16, 2025TXFireElectrical System

   Smoke, burning smell came from ac control unit. Ac wiring unit, knob completely burned/melted. Reported to Hyundai local and corporate office no resolution other then I just have to replace the unit. Please note this happened in 2022 (40,000 miles today vehicle had 58,000miles) and I paid in full for the replacement the 1st time.

   NHTSA complaint #11681071 · source
8. Filed Jun 4, 2025PAElectrical System

   The knob for the A/C can not handle the amperage when in the 4 position, it gets too hot, melts, and shuts off the system. It is available for inspection. Hyundai is acutely aware of this problem and recalled it in other years, the same as their junk engines, but once again the owners of the 2013 are left out in the dark. This is a fire hazard that the manufacturer is trying to sweep under the rug, there are service bulletins out on it for other years.

   NHTSA complaint #11664794 · source
9. Filed Apr 27, 2025PRFireElectrical System

   Car started smoking on cabin while driving. Risk of hazard dueto bad A/C control switch. Wiring harness and plug melted too. Several Hyundai Veloster are suffering same issue. Started to think blower wiring is to small for load too. Pleaae see attached pictures. Time and miles provided is an approximate. Do not remember when exactly happened but was reported previously. In the pictures you are going to be able to see the faulty part P/N for your review.

   NHTSA complaint #11657074 · source
10. Filed Mar 5, 2025AZElectrical System

    The air conditioner knob doesn't work when I put it at 4. Took it apart and the wires are burn including the pigtail that holds the wires into the knob.

    NHTSA complaint #11646616 · source
11. Filed Nov 12, 2024NMElectrical SystemEngineTransmission & Drivetrain

    On October 17, 2024, owner was leaving Denver, CO on the highway and had to stop for traffic and vehicle wouldn't move. Was in drive but vehicle would not drive and pulled to side of road. Had insurance tow to nearest Hyundai dealership. Check engine light was on and dealership checked vehicle and needed to have the crankshaft position sensor replaced. Fixed the problem thank God and I was on my road shortly there after. My Veloster is 2013 with 47,000 miles at time of…

    NHTSA complaint #11624857 · source
12. Filed Jun 8, 2024FLElectrical SystemEngine

    Vehicle is burning through oil without having oil light engaged. Vehicle is going through two quart + of oil every 3 weeks. Just added 2 quarts of oil 3 weeks ago when the car would not accelerate past 5mph and rough idled (this turned out to be caused by a different issue still being diagnosed), I added the oil as dip stick showed no oil on the stick. Light did not come on. Took to independent mechanic this week who stated I had no oil in the vehicle. Can not go 3…

    NHTSA complaint #11593239 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology