2010 Hyundai Veracruz engine problems

Related recalls

• Recall 20V705000Nov 13, 202060,097 vehicles
  ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:SEALS/GASKETS

  Hyundai Motor America (Hyundai) is recalling certain 2007-2012 Veracruz vehicles that were previously recalled under recall number 14V-415. Oil may leak from the front cylinder bank cover gasket, potentially dripping onto the alternator and causing the charging system to become inoperative.

  Risk: An inoperative charging system can result in an engine stall, increasing the risk of a crash.

  Remedy: Hyundai will notify owners, and dealers will inspect the valve cover gasket and repair it as necessary, free of charge. Owner letters were mailed September 7, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 197.

• Recall 14V415000Jul 8, 201461,122 vehicles
  ENGINE AND ENGINE COOLING:ENGINE

  Hyundai Motor Company (Hyundai) is recalling certain model year 2007-2012 Veracruz vehicles manufactured from December 26, 2006, through July 24, 2012. The affected vehicles may experience an oil leak from the front cylinder bank valve cover gasket. If there is a sufficient amount of oil dropped onto the alternator, the alternator will be damaged causing the charging system to become inoperative.

  Risk: If the alternator is damaged, the charging system warning lamp in the instrument cluster will illuminate, and the engine will lose power and the vehicle will eventually stop operating while being driven. An unexpected failure of motive power while driving increases the risk of a crash.

  Remedy: Hyundai will notify owners, and dealers will inspect/repair or replace the alternator and the front valve cover gasket, free of charge. Hyundai sent out an interim letter to owners on September 3, 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 121.

What owners say

1. Filed Sep 19, 2026ILElectrical SystemEngine

   Valve covers leaking oil onto to the alternator. Engine may shut off while driving and cause serious accident. The problem has been confirmed, inspected, and diagnosed by Hyundai Dealership. The instrument panel , radio, and climate control lights flashing and flickering when lights are turned on. September 07, 2026 is when it first appeared. Recall was done by dealership but did not remedy permanent repair. Called Hyundai customer care and both dealership and customer care…

   NHTSA complaint #11765490 · source
2. Filed Sep 3, 2026205,670 miPAEngine

   The contact owns a 2010 Hyundai Veracruz. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 20V705000 (Engine and Engine Cooling); however, the repair failed to prevent a failure. The contact stated that upon further inspection, there was an engine oil leak that was leaking onto the alternator. The local dealer was contacted. The failure mileage was approximately 205,670.

   NHTSA complaint #11761849 · source
3. Filed Jun 11, 2026114,000 miFLElectrical SystemEngine

   The contact owns a 2010 Hyundai Veracruz. The contact stated that after starting the engine and shifting into drive(D), the engine immediately shut off. The vehicle could not be restarted, and the battery failed. The manufacturer and local dealer were notified of the failure. The cause of the failure was not determined. The contact stated that the vehicle had previously experienced the same failure and was serviced under the NHTSA Campaign Number: 14V415000(ENGINE AND ENGINE…

   NHTSA complaint #11743441 · source
4. Filed Oct 27, 2025CAEngine

   They should not have closed/completed the prior recall that was open regarding the valve cover gasket leak - oil leaks onto the alternator when can cause the alternator to fail. I went to the dealership last year to get it fixed and even per the dealership, they told me this valve cover leak is going to still be a problem even if fixed. It will leak again - and they are right. It is currently leaking again and possibly causing the alternator to fail.....again. Just this…

   NHTSA complaint #11695796 · source
5. Filed May 27, 2025117,674 miFLEngine

   The contact owns a 2010 Hyundai Veracruz. The contact stated that there was a hard knocking sound coming from the engine. While driving 45 MPH, the vehicle lost motive power. The battery power was low. The vehicle was previously taken to the local dealer for TSB Number: 21-01-047H-2. The contact stated that the failure was related to NHTSA Campaign Number: 20V705000 (Engine and Engine Cooling) and 14V415000 (Engine and Engine Cooling). The alternator was replaced; however,…

   NHTSA complaint #11663033 · source
6. Filed Oct 9, 2024MSEngine

   The contact owns a 2010 Hyundai Veracruz. The contact stated while driving at approximately 35 MPH, there was an abnormal odor inside the vehicle. The contact stated that the odor was burning oil. The contact stated that the check engine warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that there was an oil leak from the T-Joint and that the repair was covered under Manufacturer Recall Number: 197 - Oil…

   NHTSA complaint #11618958 · source
7. Filed May 7, 2024PAEngine

   Driving at approximately 35 mph Check Engine Light came on P0331 Knock Sensor - light was cleared drove 14 miles CEL was back on. Called Hyundai about the code & knock sensor in reference to all the Hyundai models being recalled for the same problem and a warranty extension being granted. Hyundai advised me to take it to a local dealer for diagnosis and pay the fee of course. I did just that. The dealer clear the codes and sent me home. CEL was on again. Car was back at…

   NHTSA complaint #11587348 · source
8. Filed Apr 19, 2024106,000 miPAEngine

   The contact owns a 2010 Hyundai Veracruz. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with knock sensor failure. The vehicle was repaired; however, the failure recurred shortly afterwards. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was…

   NHTSA complaint #11584068 · source
9. Filed Aug 18, 202370,000 miGATowedElectrical SystemEngine

   The contact owns a 2010 Hyundai Veracruz. The contact stated that his wife was unable to start the vehicle. The vehicle was not drivable. The contact towed the vehicle to the local dealer, where it was diagnosed with needing the alternator to be replaced. The vehicle was repaired but experienced the same failure three years later. The contact took the vehicle back to the local dealer, where it was diagnosed and determined that the alternator needed to be replaced a second…

   NHTSA complaint #11539407 · source
10. Filed Mar 30, 2023140,000 miALEngine

    The contact owns a 2010 Hyundai Veracruz. The contact stated that the vehicle had experienced an engine oil leak. The contact stated that the engine oil leaked onto the alternator and caused the alternator to fail. The vehicle was taken to the dealer and repaired under NHTSA Campaign Number: 14V415000 (Engine and Engine Cooling); however, the failure reoccurred. The vehicle was taken back to the dealer, who informed the contact that recall repairs were completed one-time…

    NHTSA complaint #11514606 · source
11. Filed Sep 18, 2022TXElectrical SystemEngineFuel, Hybrid & EV Propulsion

    Our ESC light comes on occasionally, many times when making a left turn. Then the throttle quits and the car slows down. We had it in the shop 6 times with no repair.

    NHTSA complaint #11485097 · source
12. Filed Aug 5, 2022PATowedEngine

    The contact owns a 2010 Hyundai Veracruz. The contact received notification of NHTSA Campaign Number: 20V705000 (Engine and Engine Cooling) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had experienced a failure and the vehicle was no longer drivable. Parts distribution disconnect.

    NHTSA complaint #11477814 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology