2022 Kia Niro problems, complaints & recalls

2022 Kia Niro recalls (1)

• Recall 23V534000Jul 31, 2023121,411 vehicles
  POWER TRAIN:AUTOMATIC TRANSMISSION:INTERNAL:CLUTCHES/BANDS:ACTUATORS/SOLENOIDS

  Kia America, Inc. (Kia) is recalling certain 2017-2022 Niro and 2018-2022 Niro Plug-in Hybrid vehicles. Fluid may leak into the printed circuit board inside the hydraulic clutch actuator, which can result in an engine compartment fire.

  Risk: A fire increases the risk of injury.

  Remedy: Dealers will inspect and replace the hydraulic clutch actuator as necessary and install a new fuse, free of charge. Owner notification letters were mailed December 29, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC276.

NHTSA defect investigations

• DP22005Opened Jan 27, 2023Closed Aug 7, 2023led to recall 22V063000

  Pedestrian alert sounds

  NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after Marc…

Recent 2022 Kia Niro complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Sep 7, 2026FLElectrical System

   I park the car, lock it and then later on can’t open it. I use the emergency key to enter it but then can’t start it even with a new battery in the key fob. It happened twice. It is an issue that needs to be fixed as soon as possible because in case of emergency you’re stuck outside your car and can’t use it to escape a danger or respond to an emergency. You’re a sitting duck in the open, going nowhere.

   NHTSA complaint #11762514 · source
2. Filed Aug 25, 2026GAElectrical SystemEngineFuel, Hybrid & EV Propulsion

   2022 Kia Niro EX Premium Hybrid was sold as Kia Certified Pre-Owned on August 12 2026 with an active check engine light present at time of purchase. Dealer Calavan Kia West in Lithia Springs GA represented the vehicle as passing a 165-point CPO inspection. Dealer attributed the light to a gas cap issue and cleared the code to complete the sale. Six days later approximately August 18 2026 the check engine light returned. Dealer attempted one repair which failed. As of August…

   NHTSA complaint #11759306 · source
3. Filed Jul 29, 202690,000 miIDBrakes

   The contact owns a 2022 Kia Niro. The contact stated that while his wife was driving at various speeds, the vehicle made an abnormally loud grinding sound. The vehicle was taken to an independent mechanic, and the brake pads and rotors were replaced. While replacing the brake pads and rotors, the mechanic became aware that the parking brake cable housing was at an improper angle on the rear wheels, causing friction to damage the parking brake housing and exterior rubber. The…

   NHTSA complaint #11753454 · source
4. Filed Jul 20, 202692,000 miCABody & Structure

   The contact owns a 2022 Kia Niro. The contact stated that a hardwired kill switch was installed in the vehicle, and the switch overheated to the point that the vehicle was unable to operate. An investigation was conducted by the contact, who touched a big box underneath the dashboard. The contact's hand was burned on the fingertips because the box was extremely hot. Water was run over the hand by the contact to heal the injuries, but outside medical attention was not sought.…

   NHTSA complaint #11751662 · source
5. Filed Jun 10, 2026PACrash1 injuredTowedAirbags

   The contact owns a 2022 Kia Niro. The contact stated that while driving from a complete stop at 5 MPH, the vehicle was T-boned on the passenger's side by a Jeep Grand Cherokee driving at high speed. Due to the impact, the contact's head struck the dashboard. The other vehicle fled the scene of the crash. The airbag deployed on the passenger side but did not deploy on the driver's side. No warning light illuminated. There was no reported fire. A police report was filed. The…

   NHTSA complaint #11743136 · source
6. Filed May 27, 2026CADriver Assistance & Safety TechElectrical SystemEngine

   Problem 1, Check Engine Light: I purchased the used car on Jan 9 2025, around 23,400 miles from Kia Dealership, capitol Expy in San Jose. Today 05/27/2026, the odometer reads 26, 407 miles. My car is used only twice a week - 20 miles on Fridays, 12 miles on Wednesdays. My car has less than minimum wear and tear and is barely used. I completed my 25K service after Thanksgiving in Nov 2025. I have not even driven 1500 miles and the car is back in for service. Prior to this,…

   NHTSA complaint #11740374 · source
7. Filed May 6, 2026MDOther / Unknown

   am writing to formally request assistance regarding my Kia vehicle which I purchased used at approximately 38,000 miles. Shortly after purchase, the vehicle became undrivable and has since required repeated repairs without resolution. To date, the vehicle has been presented for repair on six separate occasions for the same issue and has remained out of service for a significant period of time. Based on these repeated failures and lack of resolution, the vehicle may…

   NHTSA complaint #11736000 · source
8. Filed Apr 24, 2026GAFuel, Hybrid & EV Propulsion

   Intermittent warning to "Refill Inverter Coolant" displays on the dash screen. This is a known issue pursuant to SA512 (ELE 270 Rev 3) due to faulty coolant that crystallizes and interferes with the sensor. However, per Kia, it is only covered under standard warranty (5 years/60k miles) and while my vehicle is within the year warranty, it is over the mileage. Quote was to replace "Chiller, water pump and flush coolant system" at a cost of $2369.02 including parts and labor.…

   NHTSA complaint #11733667 · source

Compare the 2022 Kia Niro with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 10, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology