2018 Kia Niro problems, complaints & recalls

2018 Kia Niro recalls (3)

• Recall 23V534000Jul 31, 2023121,411 vehicles
  POWER TRAIN:AUTOMATIC TRANSMISSION:INTERNAL:CLUTCHES/BANDS:ACTUATORS/SOLENOIDS

  Kia America, Inc. (Kia) is recalling certain 2017-2022 Niro and 2018-2022 Niro Plug-in Hybrid vehicles. Fluid may leak into the printed circuit board inside the hydraulic clutch actuator, which can result in an engine compartment fire.

  Risk: A fire increases the risk of injury.

  Remedy: Dealers will inspect and replace the hydraulic clutch actuator as necessary and install a new fuse, free of charge. Owner notification letters were mailed December 29, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC276.

• Recall 22V836000Nov 11, 202227,030 vehicles
  HYBRID PROPULSION SYSTEM

  Kia Motors America (Kia) is recalling certain 2017-2018 Kia Niro hybrid electric vehicles previously recalled under recall 18V-666. The Main Relay within the Power Relay Assembly (PRA) may have inadequate connections between its contacts, causing increased electrical resistance, which can overheat the rear seats.

  Risk: Overheated rear seats increase the risk of a fire.

  Remedy: Dealers will inspect the PRA and replace either the PRA or the Main Relay, as necessary, free of charge. Owner notification letters were mailed January 9, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC256. This recall supersedes NHTSA recall number 18V-666. Vehicles already repaired under the previous recall will need to have the new remedy completed.

• Recall 18V666000Sep 25, 201827,030 vehicles
  HYBRID PROPULSION SYSTEM

  Kia Motors America (Kia) is recalling certain 2017-2018 Kia Niro hybrid electric vehicles. The Main Relay within the Power Relay Assembly (PRA) may have inadequate connections between its contacts, causing increased electrical resistance.

  Risk: The increased electrical resistance can overheat the rear seat which is above the PRA, increasing the risk of a fire.

  Remedy: Kia will notify owners, and dealers will inspect the Power Relay Assembly (PRA) for damage. If no damage is found, the main relay will be replaced. If damage is found, the PRA will be replaced. These repairs will be performed free of charge. The recall began November 23, 2018. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC168.

NHTSA defect investigations

• DP22005Opened Jan 27, 2023Closed Aug 7, 2023led to recall 22V063000

  Pedestrian alert sounds

  NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after Marc…

Recent 2018 Kia Niro complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Sep 15, 2026TXOther / Unknown

   My 2018 Kia Niro had the Hydraulic Clutch Actuator (HCA) replacement in 2024 due to a recall. About two years later, it failed again causing the call to completely stop working creating safety issues for me. The car was towed to the dealership but Kia refused to pay for the fix. I eventually paid for the fix and requested a reimbursement since my vehicle is directly impacted by Safety Recall Campaign SC276 (NHTSA Campaign 23V534000) due to a critical design defect causing…

   NHTSA complaint #11764588 · source
2. Filed Sep 15, 2026FLEngineTransmission & Drivetrain

   The dealership is falsely reporting to Kia Corporate and the NHTSA that Recall SC276 is 'completed' by only replacing a fuse. They are refusing to replace the actively leaking, fire-hazardous Hydraulic Clutch Actuator unless I pay an out-of-pocket diagnostic fee. They are violating federal recall safety mandates by trying to release a vehicle with an active, un-repaired recall leak.

   NHTSA complaint #11764305 · source
3. Filed Sep 3, 2026CACrashElectrical System

   My kia niro 2018 backup camera takes a few seconds to start up when the vehicle is put in reverse. the time it takes differs from a second to sometimes 5 seconds. I know of accident caused in a McDonalds drive through where someone was backing up but the cam didn't turn on right away and they got in a small accident.

   NHTSA complaint #11761999 · source
4. Filed Aug 18, 2026158,000 miALTowedTransmission & Drivetrain

   The contact owns a 2018 Kia Niro. The contact stated that while driving at an undisclosed speed, the temperature gauge became elevated, and the vehicle stalled. The message "Check Hybrid System - Turn Engine Off" was displayed. The contact associated the failure with NHTSA Campaign Number: 23V534000 (Power Train). The dealer was contacted and stated that the vehicle was serviced under the recall; however, the vehicle was still inoperable, and additional diagnostic tests were…

   NHTSA complaint #11757679 · source
5. Filed Jul 7, 2026CATransmission & Drivetrain

   The vehicle experienced a sudden powertrain failure while driving. A certified Kia dealership diagnostic scan confirmed active Diagnostic Trouble Code (DTC) P17ED (Engine Clutch System) and a physical hydraulic clutch fluid leak around the transmission housing area. These symptoms match the exact criteria of NHTSA Safety Recall 23V534 (Kia Campaign SC276) for the Hydraulic Clutch Actuator (HCA). The manufacturer's defective component leaked fluid, causing direct…

   NHTSA complaint #11748846 · source
6. Filed May 26, 2026TXOther / Unknown

   I am writing to request assistance regarding a recurring issue with Recall SC276. Approximately two years ago, I had the hydraulic clutch actuator (HCA) replaced by a dealership as part of this recall. Since then, the vehicle has been driven only 10,000 miles, bringing the total mileage to about 45,000. The vehicle recently broke down, and the dealership confirmed that the replacement HCA has failed. Despite this being the same part addressed by the recall, the dealership…

   NHTSA complaint #11740074 · source
7. Filed May 21, 2026CAElectrical SystemOther / UnknownAcceleration & Cruise Control

   The vehicle just shut down as I exited. The power and gas pressure decreased. Pulled over to see if my hybrid battery was defective or drained. It wasn’t. A notification popped up and said “Hybrid Control System or Low Voltage DC/DC Converter, Contact dealer for service. Finally got it towed to Kia of Valencia the next day and they said it was “Hydraulic Clutch Actuator” and they want charge me $2200 to fix it. But looking up the part, it says there’s a recall for that exact…

   NHTSA complaint #11739377 · source
8. Filed May 4, 2026WAElectrical SystemEngine

   On April 21, 2026, Go Kia Renton performed an oil change on my 2018 Kia Niro Touring (VIN). The car was in perfect condition just two weeks earlier — North Seattle Transmission did a full service on April 6, 2026 at 283,649 miles with no issues noted. Later that night while driving, the red oil light flashed. I pulled over immediately and called AAA. AAA towed the vehicle from Belltown [XXX] ) at 12:11 AM on April 23 to my house then at 9:14 AM towed it straight to Go Kia…

   NHTSA complaint #11735577 · source

Compare the 2018 Kia Niro with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 10, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology