2020 Kia Telluride lighting problems

Related recalls

• Recall 24V148000Feb 26, 202435,031 vehicles
  EXTERIOR LIGHTING:HEADLIGHTS

  Kia America, Inc. (Kia) is recalling certain 2020 Telluride vehicles. The high beam headlights may fail.

  Risk: Inoperable high beam headlights may reduce visibility, increasing the risk of a crash.

  Remedy: Dealers will inspect and repair or replace the high beam headlights, as necessary free of charge. Owner notification letters were mailed August 9, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC299.

• Recall 20V436000Jul 28, 202086,921 vehicles
  ELECTRICAL SYSTEM:WIRING · EXTERIOR LIGHTING:BRAKE LIGHTS · FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

  Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles equipped with Smart Cruise Control (SCC). When a trailer is connected to the vehicle, the trailer brake lights will not illuminate when the SCC applies the brakes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

  Risk: Inoperative trailer brake lights can fail to warn other drivers that the vehicle is slowing, increasing the risk of a crash.

  Remedy: Kia will notify owners, and dealers will install an additional wire harness to the main fuse box to signal the trailer brake lights, free of charge. The recall began September 10, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC194.

What owners say

1. Filed Oct 2, 2026GALighting

   LED running light of driver's side headlamp assembly inoperable On 10/14/24 BOTH headlamp assemblies were under recall warranty and replaced at Sons Kia in McDonough GA. On 10/8/25 I returned to Sons Kia for service and to have the LED checked on the driver's side as it was no longer operable, less than a year after replacement. I was advised there was no warranty on the LED running light but only the halogen bulb. They priced this headlamp assembly replacement cost at…

   NHTSA complaint #11768480 · source
2. Filed Sep 29, 2026MITowedElectrical SystemEngineLighting

   Everything with paint that everyone else with the pearl color is dealing with flaked all off .. electrical my seat caught on fire ... lighting headlights constantlyfail have changed multiple.. I can keep going on but there isnt enough time or room

   NHTSA complaint #11767667 · source
3. Filed Aug 22, 2026TXLighting

   The factory-installed driver/passenger side LED headlight assembly suffered a sudden, total internal electrical failure while driving at night, causing an immediate loss of forward visibility and creating a severe crash hazard. This is a known, systemic manufacturing defect affecting premium trims (SX/SX-Prestige) of the 2020 Kia Telluride. The housing seals degrade prematurely, allowing condensation to become trapped inside the unit. This moisture corrodes the internal…

   NHTSA complaint #11758772 · source
4. Filed Jun 18, 2026PALighting

   SC299 (high‑beam headlight failure) is actually a safety defect tied to visibility and part of a recall which my telluride falls just outside of

   NHTSA complaint #11744971 · source
5. Filed Apr 1, 2026PALighting

   The contact owns a 2020 Kia Telluride. The contact stated that while driving at various speeds, the high beam headlights failed to illuminate as intended, and the vehicle shuddered before losing automotive power. No warning light was illuminated. In addition, the contact stated that the warning lights failed to illuminate as designed when the engine oil level was low. The vehicle was taken to a local Auto Zone, where the relay and high beam headlights were replaced; however,…

   NHTSA complaint #11728510 · source
6. Filed Jan 6, 2026OHLighting

   The headlights on this car are pointed too high. When driving on the road at night vehicles coming the other way often assume you have your bright lights on and flash you with their bright lights which can temporarily blind you - obviously a big safety problem! If this only happened once in a while I'd say no big deal but it happens EVERY SINGLE TIME YOU DRIVE THE CAR! I've spoken with other 2020 Kia Telluride owners and they report the exact same problem. I've spoken to the…

   NHTSA complaint #11709139 · source
7. Filed Jul 14, 2025CALighting

   The contact owns a 2020 Kia Telluride. The contact stated while attempting to have a vehicle inspected, it was discovered that there was an open recall on the VIN. The VIN was included in NHTSA Campaign Number: 24V148000 (EXTERIOR LIGHTING); however, the part to do the recall repair was not available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the…

   NHTSA complaint #11673399 · source
8. Filed Jun 3, 2025VALightingVisibility & Wipers

   It took 8 months to repair the Recall #SC299B HALOGEN HEADLAMP-BOTH. Repair was done 04/03/2025, which appears to have not last long as high beam is low again and I am afraid to drive in early morning, dusk, or evening due to the timid, low bearing high beams. This is very unsettling as we have made three complaints due to negligence and lack of efficiency for recall repair, being in an accident due to not seeing a deer run across and we hit it, as well as, failed state…

   NHTSA complaint #11664738 · source
9. Filed Mar 21, 2025VALighting

   I have had mi car in multiple shops and been told they can’t repair my headlights. The bulb keeps blowing and now the headlight highbeam doesn’t work and my state inspection is coming up next month and the corporate office says there nothing they can do till the part is available. I need my car fixed for my safety and my family’s safety. I don’t know what else to do

   NHTSA complaint #11649698 · source
10. Filed Mar 20, 202560,000 miTXLighting

    The contact owns a 2020 Kia Telluride. The contact received Kia Campaign Number: 296 for the "Halogen Headlamp High Beam". The vehicle was repaired. The contact stated that on one occasion while driving at an undisclosed speed, the high-beam lights failed to illuminate as intended. The vehicle was taken to the dealer; however, no cause for the failure was found. The contact stated that the failure persisted. The vehicle was taken back to the dealer. The dealer was unable to…

    NHTSA complaint #11649546 · source
11. Filed Mar 17, 2025KYLightingOther / UnknownTransmission & Drivetrain

    What component or system failed or malfunctioned, and is it available for inspection upon request? POWER TRAIN, OIL CONSUMPTION, CAMSHAFT POSITION , CIRCUIT SENSORS A X 4, HEADLAMPS HIGH BEAMS DO NOT FUNCTION.CHECK ENGINE LIGHT FAILS. How was your safety or the safety of others put at risk? I DONT FEEL SAFE DRIVING AFTER SUNSET IF I CANT SEE ROAD WHEN NEEDED MY HIGH BEAMS DID NOT FUNCTION I WAS TOLD IT WAS FIXED BUT THERE WERE NO PARTS. STILL AN ISSUE. Has the problem been…

    NHTSA complaint #11648764 · source
12. Filed Jan 21, 2025CALighting

    I brought veh to Covina Kia on 1-6-25 for recall (SC299B) of headlight high beams failure. George Arroyo refused to take my veh in telling me my warranty had expired. I told him the safety recall had to be addressed. I insisted mileage doesn’t not void a safety recall. He finally took veh in. My veh has been at dealership for 16 days and has not been touched. It is obvious dealership doesn’t want to perform recall because there is no money to be made for the technician and…

    NHTSA complaint #11637456 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology