2022 Ram 2500 transmission & drivetrain problems

Related recalls

• Recall 22V835000Nov 10, 2022250,079 vehicles
  POWER TRAIN:AUTOMATIC TRANSMISSION

  FCA US, LLC (Chrysler) is recalling certain 2020-2023 Ram 2500 and 2020-2022 Ram 3500 vehicles. A build-up of pressure and heat inside the transmission may result in a transmission fluid leak from the dipstick tube.

  Risk: Leaking transmission fluid may contact an ignition source within the engine compartment, increasing the risk of a fire.

  Remedy: Dealers will replace the transmission dipstick and transmission vent assembly, free of charge. Owner notification letters were mailed December 29, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. Chrysler's number for this recall is ZA3.

What owners say

1. Filed Jul 14, 2026120,000 miTXElectrical SystemTransmission & Drivetrain

   The contact owns a 2022 Ram 2500. The contact stated that while driving at an undisclosed speed, the vehicle intermittently went into LIMP Mode and failed to accelerate as needed. The contact pulled over and turned off the vehicle. The failure failed to be self-corrected after the vehicle was restarted. The vehicle was taken to a transmission specialist, who was unable to duplicate the failure. The contact was informed that the failure was electrical, and an unknown sensor…

   NHTSA complaint #11750317 · source
2. Filed Apr 28, 2026CATransmission & Drivetrain

   Per mopar recall ZA3 transmission tube and dipstick recall. When completed at Orange Coast Ram [XXX] , dealership completed recall, removed original dipstick, and provided a 15" locking dipstick the does NOT provide needed transmission fluid level. Inquired in Orange Coast Ram service department, stated they will not provide needed 44"dipstick to monitor trans fluid. I cannot order, purchase the needed dipstick, creating a dangerous situation if fluid is low, and will result…

   NHTSA complaint #11734279 · source
3. Filed Mar 13, 202610,000 miNYTransmission & Drivetrain

   The contact owns a 2022 Ram 2500. The contact stated that while driving at an undisclosed speed, the RPM fluctuated. Additionally, the vehicle made an abnormal sound while slowing down to come to a stop. The vehicle was taken to the dealer, who discovered burnt transmission fluid and replaced the transmission, but the failure persisted. The vehicle was taken back to the dealer; however, the cause of the failure could not be determined. The vehicle was not repaired. The…

   NHTSA complaint #11724045 · source
4. Filed Dec 22, 2025OROther / UnknownTransmission & Drivetrain

   I have a clunk to when coming to a stop, the transmission is down shifting, and just before it comes to a complete stop, the truck has a clunk that is felt through the vehicle and heard. at times while stopped the vehicle will lurch forward as though you have been hit from behind. The truck has been back to the dealership several times for this problem, two different dealerships because the first one gave up and was suggested to take it to another dealership per Ram. The…

   NHTSA complaint #11706544 · source
5. Filed Dec 3, 2025CAEngineTransmission & Drivetrain

   I am reporting a recurring safety defect involving hydraulic lifter failure in Ram trucks equipped with the Cummins diesel engine (model years 2019–2024). This issue is widely acknowledged by Stellantis and multiple dealers. It typically begins with a knocking sound and has been documented in many cases to progress to complete engine failure. My vehicle has fewer than 20,000 miles. The lifters were already replaced once, which required the cab to be removed. Within less than…

   NHTSA complaint #11702823 · source
6. Filed Sep 2, 2025AZTransmission & Drivetrain

   Dodge Ram started making typewriter sound coming from the engine. Took the Ram to the dealership and they found 3 damaged push push rods and 3 damaged rocker arms. Dealer refused to address the metal shaving from the internal damage floating around the engine. Engine had 32k miles on it and oil was changed at 7 to 8k miles intervals.

   NHTSA complaint #11684623 · source
7. Filed Jun 4, 2025ALEngineFuel, Hybrid & EV PropulsionTransmission & Drivetrain

   The Mass Air Flow (MAF) sensor on my 2022 Ram 2500 failed, causing multiple system malfunctions. It triggered inaccurate Diesel Particulate Filter (DPF) codes and showed abnormally high idle hours that do not reflect actual vehicle use. This defect is tied to a known issue identified by Stellantis in Technical Service Bulletin #18-002-24, which acknowledges improper MAF sensor calibration or compatibility on vehicles like mine. The bulletin was verbally confirmed by the…

   NHTSA complaint #11664846 · source
8. Filed Jan 23, 2025NYTransmission & Drivetrain

   Transmission issues began at less then 10K miles when the vehicle was new. Initially experienced a noise and slam into reverse gear. The dealer initially claimed the noises were normal or could not replicate the issue. Over time, the vehicle developed a hard shift between 1st and 2nd gear and between 4th and 5th gear. Despite multiple repair attempts by the dealer, the problem persisted. After spending 94 days at the dealership, the transmission was replaced with a…

   NHTSA complaint #11637885 · source
9. Filed Dec 16, 2024MIBrakesElectrical SystemTransmission & Drivetrain

   1. Complete Brake Failure. No warning lights came on. There is no emergency warning system for Brake Failure. This could have been catastrophic. This could have turned deadly if we were driving on the highway with no warnings Dec 15, 2024 I drove the truck during the day on the highway and made various stops for Christmas Shopping. I went for dinner with my Family. After dinner climbed into the truck and depressed the break and started the truck. Once the truck started the…

   NHTSA complaint #11630887 · source
10. Filed Sep 29, 2024TXDriver Assistance & Safety TechEngineTransmission & Drivetrain

    The grid heater bolt can fail and fall into cylinder number 6 and cause catastrophic failure causing an accident. The 68RFE transmission is prone to failure and should be repaired/replaced. The hydraulic liters are subject to failure and should be replaced with solid lifters.

    NHTSA complaint #11617070 · source
11. Filed Aug 12, 2024MITransmission & Drivetrain

    4.10 Axle Ratio has manufacturing defect. Pinion bearing spins in differential housing causing miss-alignment between pinion and ring gear. Resulting in vibration, noise, binding at low RPM and slamming sensation with sudden acceleration. Full rear end lock up possible. Providing dangerous situation, especially when using as tow vehicle. Truck reported has 3rd (third) axle housing installed, with defects already present requiring another replacement.

    NHTSA complaint #11608033 · source
12. Filed Jul 3, 2024CATransmission & Drivetrain

    A driver was driving their 2022 Ram 2500 to the first job of the day on surface streets in Hollywood, CA. While driving they heard a sudden banging noise from under the truck and lost the ability to accelerate. The driver used the service brakes to stop the vehicle and attempted to put the unit in Park, but Park would not hold the vehicle. The vehicle would also not go into drive or reverse, so they used the parking brakes to secure the vehicle. The vehicle was towed back to…

    NHTSA complaint #11598661 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology