2009 Volkswagen Routan problems, complaints & recalls

2009 Volkswagen Routan recalls (5)

• Recall 16V083000Feb 11, 20161,037 vehicles
  AIR BAGS:FRONTAL · AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE

  Volkswagen Group of America, Inc. (VW) is recalling certain model year 2009 Volkswagen Routan vehicles manufactured February 7, 2008, to August 28, 2008. In the affected vehicles, the air bag control units may corrode and fail.

  Risk: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.

  Remedy: VW will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began April 2016. Owners may contact Volkswagen customer service at 1-800-893-5298.

• Recall 15V194000Apr 1, 201520,676 vehicles
  ELECTRICAL SYSTEM:IGNITION:SWITCH

  Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009 Routan vehicles manufactured June 25, 2008, to July 8, 2009, and 2010 Routan vehicles manufactured October 1, 2009, to August 11, 2010. This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

  Risk: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including, but not limited to, air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.

  Remedy: Volkswagen will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on June 23, 2015. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 28H1. Note: This recall supersedes recalls 11V151 and 14V396. Vehicles that previously received an ignition switch trim ring as a recall remedy must have their vehicles remedied again under this campaign. Vehicles that have already received a new ignition switch are not covered by this campaign.

• Recall 14V396000Jul 1, 201418,526 vehicles
  ELECTRICAL SYSTEM:IGNITION

  This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009 Routan vehicles. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

  Risk: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.

  Remedy: Volkswagen will notify owners, and dealers will modify the ignition switch, free of charge. Owners may contact Volkswagen customer service at 1- 800-822-8987. An interim notice was mailed to owners on August 29, 2014. Volkswagen's number for this recall is 28G1/U8. Note: This campaign is an expansion of NHTSA Recall No. 11V-151.

• Recall 14V055000Feb 11, 2014130 vehicles
  SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY

  Freedom Motors Inc., (Freedom Motors) of Savaria Vehicle Group (formerly The Liberty Motor Company) is recalling one model year 2009 Volkswagen Routan and certain model year 2008-2010 Dodge Grand Caravan and Chrysler Town & Country wheelchair accessible vehicles modified by The Liberty Motor Company from February 2008 through January 2011. Over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure.

  Risk: Failure of the rear axle may increase the risk of a crash.

  Remedy: Freedom Motors will notify owners, and dealers will replace the affected axles, free of charge. The recall began on April 1, 2014. Owners can contact Freedom Motors at 1-800-561-9600. Freedom Motors' number for this recall is ENGF0216-3.

• Recall 10V252000Jun 10, 201015,902 vehicles
  ELECTRICAL SYSTEM:WIRING

  Volkswagen is recalling certain model year 2009 routan vehicles manufactured from june 2008 through july 2009. These vehicles may have been built with an improper routed wire harness that may have a condition where the lower sliding door hinge bracket can make contact and wear through the wire insulation. Contact with a 12v power feed circuit within the harness may cause a high resistive short circuit within the latch mechanism located inside of the sliding door.

  Risk: This could result in an overheated latch and a fire within the rear sliding door could occur.

  Remedy: Volkswagen will inspect the sliding door wire track wire assembly and the sliding door power drive unit wire assembly for damage, repair/replace as necessary, tie strap the two harnesses together and route the harnesses under the sliding door weather strip. This service will be performed free of charge. The safety recall began on october 15, 2010. Owners may contact volkswagen at 1-800-822-8987.

Recent 2009 Volkswagen Routan complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Aug 26, 2026CAElectrical System

   The contact owns a 2009 Volkswagen Routan. The contact received notification for NHTSA Campaign Number: 15V194000 (Electrical System); however, the part to complete the recall repair was not available. The local dealer was contacted to schedule the recall repair, but the part remained unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. The contact had not…

   NHTSA complaint #11759820 · source
2. Filed Jun 25, 2024150,000 miMOCrash1 injuredTowedAirbags

   The contact owned a 2009 Volkswagen Routan. The contact stated that while driving at 65 MPH, the contact suffered a medical emergency and lost control of the vehicle. The contact's vehicle crashed into the rear of a semi-truck. In addition, the contact's vehicle crashed into a ditch. The contact stated that the air bags did not deploy. The paramedics and the Police arrived on the scene. A Police report was filed, however thePolice report information was unavailable. The…

   NHTSA complaint #11596563 · source
3. Filed Jul 31, 2023170,000 miMETowedElectrical System

   The contact owns a 2009 Volkswagen Routan. The contact received notification of the NHTSA Campaign Number: 15V194000 (Electrical System) however, the parts to do the recall repair were not yet available. The contact stated while attempting to start the vehicle, the engine failed to turn over. No warning lights were illuminated. The vehicle was towed to the dealer where it was diagnosed that the ignition switch failed and needed to be replaced; however, the dealer confirmed…

   NHTSA complaint #11535458 · source
4. Filed Jun 20, 2023TXElectrical System

   While driving the vehicle flashed several of the dashboard waring lights, starting dinging and then stopped, started flashing and dinging again then the vehicle completely turned off. I was able to pull over out of traffic but the vehicle would not restart. None of the interior lights would come one and the emergency lights would not come on. I could not unlock any of the doors. The battery has been replaced with in the last year and is working correctly.

   NHTSA complaint #11527937 · source
5. Filed Feb 27, 2023WIElectrical System

   the car shuts off while driving which is scary. requires restarting while in traffic. there was a recall in past and the fix clearly did not work. This incident has occurred multiple times.

   NHTSA complaint #11509291 · source
6. Filed Jun 8, 2022OHElectrical System

   The contact owns a 2009 Volkswagen Routan. The contact received notification of NHTSA Campaign Number: 15V194000 (Electrical System) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect

   NHTSA complaint #11468194 · source
7. Filed May 13, 2022TXElectrical SystemSeats & Seat BeltsVisibility & Wipers

   After getting wires regrounded at the mechanic, the car continues to malfunction. The wiper blades turn on, the entire dash blinks, the seat moves back and forth, resetting repeatedly. If seat is disconnected for safety, the seatbelt does not register as secured. Eventually doors stop functioning, have completely lost lock function, tried replacing battery and sending to mechanic specialist. Still the car malfunctions at random.

   NHTSA complaint #11464597 · source
8. Filed Dec 5, 2021TXElectrical System

   My vehicle shows no pending recalls, but ignition switch still malfunctioning whenever it is bumped or a lanyard is on the key. Brakes malfunction, car seat moves, windshield wipers move, car seems to think it is resetting as original recall states is a problem.

   NHTSA complaint #11442749 · source

Compare the 2009 Volkswagen Routan with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 11, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology