2007 Chevrolet Avalanche problems, complaints & recalls

2007 Chevrolet Avalanche recalls (3)

• Recall 21V052000Feb 5, 2021557,023 vehicles
  AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

  General Motors, LLC (GM) is recalling certain 2009 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

  Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

  Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 23, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on September 20, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-458-8006, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328780.

• Recall 21V050000Feb 5, 20212,641,272 vehicles
  AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

  General Motors, LLC (GM) is recalling certain 2007-2011 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL, and 2009-2011 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500 and Sierra 3500 vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

  Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

  Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on March 1, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328760.

• Recall 10V240000Jun 4, 20101,365,070 vehicles
  ELECTRICAL SYSTEM

  Gm is recalling certain model year 2006-2009 buick, lucerne; cadillac dts; hummer h2; model year 2008-2009 buick enclave; cadillac cts; model year 2007-2009 cadillac escalade, escalade esv, escalade ext; chevrolet avalanche, silverado, suburban, tahoe; gmc acadia, sierra, yukon, yukon xl; saturn outlook; and model year 2009 chevrolet traverse vehicles equipped with a heated washer fluid system (hwfs). A recall was implemented in 2008 to add a fuse to the control circuit harness to address the potential consequences of a printed circuit board (pcb) electrical short. However, there have been new reports of thermal incidents on hwfs modules after this improvement was installed. These incidents resulted from a new failure mode attributed to the device's thermal protection feature. The significance varies from minor distortion to considerable melting of the plastic around the hwfs fluid chamber.

  Risk: It is possible for the heated washer module to ignite and a fire may occur.

  Remedy: Dealers will permanently disable and remove the heated washer fluid module. An updated page for the owner manual will be provided and inserted in the owner manual to document that the feature has been permanently disabled and removed from the vehicle. The safety recall began on june 11, 2010. Owners may contact buick at 1-866-608-8080, cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, saturn at 1-800-972-8876, gmc at 1-866-996-9463 and hummer at 1-800-732-5493 or at the owner center at www.gmownercenter.com.

NHTSA defect investigations

• EA21002Opened Sep 17, 2021Open

  Desiccated Air Bag Inflator Rupture

  From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.C…

• EA08010Opened Jun 12, 2008Closed Sep 8, 2008led to recall 08V441000

  Non-crash engine compartment fires

  In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. According to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. This may cause other electrical features…

Recent 2007 Chevrolet Avalanche complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Apr 21, 2026MSEngine

   Traveling hiway on cruise. My 5.3l down shifted to accelerate to go up an incline. Shortly after that there was low to almost no power. Check engine light then came on. I was able to do 30mph on freeway to get it home. Took it to a local garage since gray Daniels chevy wouldn’t service it since I recently transitioned to MS. The problem was the #4 lifter had collapsed. It costed me just shy of $4k out of pocket. I’ve read that this was a recall item for my vehicle, I was…

   NHTSA complaint #11732748 · source
2. Filed Jun 18, 2025HIAirbagsVisibility & Wipers

   First recall, Only dealer on Island (Hawaii) went out of business and couldn't be done by a GM dealer. Windshield washer fluid heater was removed by a mechanic shop at my own expense. Second recall, The passenger airbag inflator hasn't been done due to the fact that 2007 - 2014 Chevy Avalanche, Tahoe, Suburban & GMC Yukon are known for cracked dashboards which includes my Avalanche. My dashboard was cracked before the airbag recall and I covered the dashboard with fiberglass…

   NHTSA complaint #11667854 · source
3. Filed Jul 2, 2024AZElectrical SystemEngineAcceleration & Cruise Control

   Code p2128 code p2122 have replaced tps, throttle body, accelerator pedal (×3) and bypassed connectors with direct wiring from accelerator pedal to ecm continue to get codes with check engine light with decreased engine power, check stabilitrak, and stabilitrak disabled. Have to clear codes with bluedriver multiple times even while driving short distances and sometimes on start up.

   NHTSA complaint #11598334 · source
4. Filed Jun 11, 2024100,000 miNYCrash1 injuredTowedAirbags

   The contact owned a 2007 Chevrolet Avalanche. The contact stated that while driving at approximately 60 MPH, he lost control of the vehicle after driving over a pothole and crashed into a telephone pole. The pole fell on the vehicle and the fire department had to remove the contact from the vehicle. The front passenger's side of the vehicle was damaged. The air bags in the vehicle failed to deploy during the impact. The contact sustained three fractured ribs and one…

   NHTSA complaint #11593712 · source
5. Filed Feb 28, 2024TNAirbagsSeats & Seat Belts

   Was going down the road and there was a big load bang or pop that sounded like a bomb went and the seatbelts sucked us back and locked us in place and then the service airbag light came on the light stays on the seatbelts are locked up can remove and it was like the air bags says will no longer deploy/work and now can't use the seatbelts and the law says no seatbelt use we get a ticket so now can't drive truck unless I want a ticket. So what do I do now I am disabled and…

   NHTSA complaint #11574539 · source
6. Filed Nov 8, 2023MIAirbagsOther / Unknown

   Dash is cracked in so many spots and missing peices to where it is unsafe. In an accident those loose and broken peices can hurt a passenger/driver. Can't even get the airbag recall taken care of because the dash is too damaged.

   NHTSA complaint #11554131 · source
7. Filed Nov 6, 2023125,675 miINBody & Structure

   The contact owns a 2007 Chevrolet Avalanche. The contact stated that while the vehicle was at the dealer for a service appointment, the contact was informed that the subframe was severely corroded. The contact was informed that the subframe and parts connected to the frame would also need to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 125,675.

   NHTSA complaint #11553865 · source
8. Filed Jun 23, 2023AZAirbags

   Have a 2007 Chevy Avalanche LTZ 5.3L that has a dashboard panel that is completely falling apart and cracking everywhere. This includes MULTIPLE cracks and broken pieces surrounding the airbag. I am worried these pieces could get propelled by the airbag if the airbag were to deploy. These cracks and broken parts of the dash have also caused multiple other things to become loose. The controls on the front of the dash are falling out because they can no longer be bolted to the…

   NHTSA complaint #11528542 · source

Compare the 2007 Chevrolet Avalanche with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 11, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology