2007 Chevrolet Cobalt problems, complaints & recalls

2007 Chevrolet Cobalt recalls (4)

• Recall 14V171000Apr 10, 20142,191,014 vehicles
  ELECTRICAL SYSTEM:IGNITION

  General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.

  Risk: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.

  Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.

• Recall 14V047000Feb 10, 20142,190,934 vehicles
  AIR BAGS · ELECTRICAL SYSTEM:IGNITION:SWITCH

  This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

  Risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

  Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

• Recall 12V459000Sep 19, 201249,768 vehicles
  FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

  General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.

  Risk: Fuel leakage in the presence of an ignition source may result in a fire.

  Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.

• Recall 10V073000Mar 3, 20101,050,889 vehicles
  STEERING:ELECTRIC POWER ASSIST SYSTEM

  General motors is recalling certain model year 2005-2010 chevrolet cobalt and model year 2007-2010 pontiac g5 vehicles equipped with electric power steering. The driver may experience a sudden loss of power steering assist that could occur at any time while driving.

  Risk: If power steering assist is lost, it would require greater driver effort at low vehicle speeds, increasing the risk of a crash.

  Remedy: Dealers will replace the electric power steering motor free of charge. Owners are being notified on a rolling basis between march 29 through november 2010. A copy of the mailing schedule is located in the recall file. Owners may contact chevrolet at 1-800-630-2438 and pontiac at 1-800-620-7668 or at the owner center at www.gmownercenter.com.

NHTSA defect investigations

• PE10005Opened Jan 27, 2010Closed Jul 19, 2010led to recall 10V073000

  Electric Power Steering Failure

  In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering c…

Recent 2007 Chevrolet Cobalt complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Jul 3, 2026AZElectrical SystemFuel, Hybrid & EV PropulsionSteering

   Fuel Leak it smells and leaks it seems to be coming from the gas tank and sometimes I get random electric failure when I'm driving I lose power steering and My brakes get stiff and hard to push down and my dash will go Off and then go crazy and show that i have no gas

   NHTSA complaint #11748103 · source
2. Filed Apr 15, 2026NVFuel, Hybrid & EV Propulsion

   I observed my mother’s 2007 Chevy Cobalt was leaking fuel near the rear tire by the fuel tank. I inspected the tank with engine off and it does not leak. Only with engine running. I lowered the tank and observed a small crack on the plastic return line on the fuel pump module. I started looking online and could not find a replacement part that was plastic. I then conducted more research and found the recall. I asked my mother and she stated she never received a recall. The…

   NHTSA complaint #11731276 · source
3. Filed Mar 17, 2026MDCrashTowedAirbags

   The contact owned a 2007 Chevrolet Cobalt. The contact stated that while the son was driving at approximately 52 MPH, the vehicle crashed head-on into a second vehicle. During the crash, no air bags had deployed, and the driver sustained fatal injuries. Also, during the crash, the ignition key broke off inside the ignition switch, and the vehicle was destroyed. A police report was taken at the scene, and the vehicle was towed to a police inbound lot and later towed to the…

   NHTSA complaint #11724877 · source
4. Filed Jan 9, 202616,265 miKYCrash2 injuredTowedAirbags

   The contact owns a 2007 Chevrolet Cobalt. The contact stated that while driving at 55 MPH, a 12-point buck jumped into the roadway, causing the contact to abruptly depress the brake pedal; however, the vehicle skidded and crashed into the buck. No air bags deployed. The vehicle was drivable; however, the vehicle was towed to the residence due to the radiator being damaged. The contact stated that he sustained injuries to his left knee, and his fiancée, who was seated in the…

   NHTSA complaint #11709925 · source
5. Filed Dec 4, 2025FLSteering

   The contact owns a 2007 Chevrolet Cobalt. The contact stated that while driving at an undisclosed speed, the steering wheel seized. There was no warning light illuminated. The contact stated that the steering wheel became difficult to turn. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was unavailable.

   NHTSA complaint #11702992 · source
6. Filed Sep 26, 2025VTCrash1 injuredTowedAirbagsElectrical SystemSteering

   I was in a crash on 9/19/25 and at the incident none of my airbags deployed. My daily driver for my children and I. I was lucky I was the only passenger at the time. I never expected my airbags not to deploy in a head on crash. The car still sits in my driveway and I have and identical one just like it that I drive! I’d like them evaluated.

   NHTSA complaint #11689938 · source
7. Filed Apr 23, 2025ILBrakesElectrical SystemSteering

   The contact owns a 2007 Chevrolet Cobalt. The contact stated that while driving approximately 35 MPH, the power steering warning light illuminated, and the contact had to manually steer the vehicle. The contact continued to drive the vehicle without power steering functionality. The contact stated that additional electrical failures had occurred. The contact also stated that the ABS activated and deactivated independently, and the traction control became inoperable. The…

   NHTSA complaint #11656377 · source
8. Filed May 1, 2024160,000 miWISteering

   The contact owns a 2007 Chevrolet Cobalt. The contact stated that while her daughter was driving at an undisclosed speed, the contact became aware of a loud noise coming from the steering wheel. After the failure, while attempting to park the vehicle, the contact became aware of a crunchy sound coming from the steering wheel. The contact stated that due to the failure result, the steering wheel became abnormally stiff and difficult to maneuver. No warning lights were…

   NHTSA complaint #11586366 · source

Compare the 2007 Chevrolet Cobalt with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 11, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology