2006 Chevrolet Cobalt problems, complaints & recalls

2006 Chevrolet Cobalt recalls (3)

• Recall 14V171000Apr 10, 20142,191,014 vehicles
  ELECTRICAL SYSTEM:IGNITION

  General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.

  Risk: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.

  Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.

• Recall 14V047000Feb 10, 20142,190,934 vehicles
  AIR BAGS · ELECTRICAL SYSTEM:IGNITION:SWITCH

  This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

  Risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

  Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

• Recall 10V073000Mar 3, 20101,050,889 vehicles
  STEERING:ELECTRIC POWER ASSIST SYSTEM

  General motors is recalling certain model year 2005-2010 chevrolet cobalt and model year 2007-2010 pontiac g5 vehicles equipped with electric power steering. The driver may experience a sudden loss of power steering assist that could occur at any time while driving.

  Risk: If power steering assist is lost, it would require greater driver effort at low vehicle speeds, increasing the risk of a crash.

  Remedy: Dealers will replace the electric power steering motor free of charge. Owners are being notified on a rolling basis between march 29 through november 2010. A copy of the mailing schedule is located in the recall file. Owners may contact chevrolet at 1-800-630-2438 and pontiac at 1-800-620-7668 or at the owner center at www.gmownercenter.com.

NHTSA defect investigations

• PE10005Opened Jan 27, 2010Closed Jul 19, 2010led to recall 10V073000

  Electric Power Steering Failure

  In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering c…

Recent 2006 Chevrolet Cobalt complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Sep 18, 2025RIElectrical SystemOther / UnknownSteering

   All of these failed again after repair, the car hes been disabled for over 2 years with the same failures. < Dealer Recalls 14115 Dec 5, 2014 Product Safety - Electric Power Steering Assist 14113C Jul 17, 2014 Product Safety - Replace Ignition Lock Cylinder and Ignition Key 14113 Jul 17, 2014 Product Safety - Replace Ignition Lock Cylinder and Ignition Key

   NHTSA complaint #11688075 · source
2. Filed Jul 25, 2025TNEngineFuel, Hybrid & EV Propulsion

   The contact’s wife owns a 2006 Chevrolet Cobalt. The contact stated there was an abnormal fuel odor inside the cabin of the vehicle. While exiting the vehicle, the contact became aware that there was an oil leak underneath the rear end of the vehicle, and the fuel odor was more evident. There were no warning lights illuminated. The vehicle was jerking while accelerating and while driving from being stationary. The vehicle was not taken to the dealer to be diagnosed or…

   NHTSA complaint #11676098 · source
3. Filed Jul 13, 2025COElectrical SystemFuel, Hybrid & EV Propulsion

   The fuel tank has an evap leak that somehow breaks on top the tank so it leaks the gas vapors and could potentially start a fire but the part that breaks is a non serviceable part so it can’t be fixed without purchasing a whole new gas tank that isn’t cheap. My other concern is the infamous grounding issue with the wires on the ground g105 I believe right next to oil filter that grounds the transmission and engine control modules well it shorts at times when driving and…

   NHTSA complaint #11673114 · source
4. Filed Jun 19, 2025AKSteering

   I have been experiencing the loss of steering assist. This occurs at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds. Steering control is maintained in manual mode, but requires greater driver effort at low vehicle speeds. In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed. The occurs at speeds in excess of 60mph.

   NHTSA complaint #11667876 · source
5. Filed Sep 26, 2024VADriver Assistance & Safety TechSteering

   My Power Steering is going out and then coming back in to use. Today is the second time it has happened. It went out just now, I reversed down the road to my house, and turn it off once I crank it again the steering is back. I haven’t gotten any pictures of it as I’m more worried about making it back to my house so I’m not in the road but will be more than happy to get a picture if this happens again. I’m also not sure which ADAS this connects to so I put cruise control.

   NHTSA complaint #11616719 · source
6. Filed Sep 7, 2024COSteering

   Was driving home from work on i70 through the canyon when out of no where I wasn't able to steer my car...was able to stop the car, turned it off .waited a minute then started back up that is when power steering came across my dash .nothing was wrong with my car ,drove normal then out of nowhere going the speed limit 75mph. I'm not able to steer my car. This never happened before ,scared the crap out of me with no warning almost crashed cause I could not steer my car.

   NHTSA complaint #11613220 · source
7. Filed Jul 24, 2024OHEngineOther / Unknown

   The car idles very low when stopped and sputters/putters like it's going to die. It has now actually died on me twice while driving, luckily when you put it in park and turn the car off and back on it starts right back up but you can see how this is a severe safety hazard. The first time it died I was stopped in the turning lane waiting on traffic to go by so I could turn left (this is the busiest street in town) I go to start turning left the car just shuts off mid turn…

   NHTSA complaint #11604344 · source
8. Filed Aug 31, 2023INOther / Unknown

   I took the vehicle in for a recall repair to the ignition. After the repair, my key did not open my trunk. This is a huge problem because the battery is located in the trunk. You need power to open the trunk without a key. If your battery fails, you have no way to access it for repairs. I e-mailed the dealer who responded by advising me to contact the service manager. I did this. The service manager told me they only rekey the ignition to the original key during a recall. If…

   NHTSA complaint #11541960 · source

Compare the 2006 Chevrolet Cobalt with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 11, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology