2008 Chevrolet Cobalt problems, complaints & recalls

2008 Chevrolet Cobalt recalls (4)

• Recall 14V171000Apr 10, 20142,191,014 vehicles
  ELECTRICAL SYSTEM:IGNITION

  General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.

  Risk: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.

  Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.

• Recall 14V047000Feb 10, 20142,190,934 vehicles
  AIR BAGS · ELECTRICAL SYSTEM:IGNITION:SWITCH

  This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

  Risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

  Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

• Recall 12V459000Sep 19, 201249,768 vehicles
  FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

  General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.

  Risk: Fuel leakage in the presence of an ignition source may result in a fire.

  Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.

• Recall 10V073000Mar 3, 20101,050,889 vehicles
  STEERING:ELECTRIC POWER ASSIST SYSTEM

  General motors is recalling certain model year 2005-2010 chevrolet cobalt and model year 2007-2010 pontiac g5 vehicles equipped with electric power steering. The driver may experience a sudden loss of power steering assist that could occur at any time while driving.

  Risk: If power steering assist is lost, it would require greater driver effort at low vehicle speeds, increasing the risk of a crash.

  Remedy: Dealers will replace the electric power steering motor free of charge. Owners are being notified on a rolling basis between march 29 through november 2010. A copy of the mailing schedule is located in the recall file. Owners may contact chevrolet at 1-800-630-2438 and pontiac at 1-800-620-7668 or at the owner center at www.gmownercenter.com.

NHTSA defect investigations

• PE20011Opened Jul 5, 2020Closed Aug 17, 2023

  Fuel Line Leak

  On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a pro…

• PE10005Opened Jan 27, 2010Closed Jul 19, 2010led to recall 10V073000

  Electric Power Steering Failure

  In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering c…

Recent 2008 Chevrolet Cobalt complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Jun 25, 2025TXSteering

   The contact owns a 2008 Chevrolet Cobalt. The contact stated that the power steering suddenly failed to operate as needed. The vehicle was turned off for a while and restarted for the power steering functionality to return. The failure was persistent. The contact stated that the power steering warning light flashed on the instrument panel. The vehicle was taken to a certified mechanic, who informed the contact that it was a known failure with the power steering. The mechanic…

   NHTSA complaint #11669269 · source
2. Filed Jun 6, 2025PAFuel, Hybrid & EV Propulsion

   The fuel line is leaking fuel on the drivers side near the passenger door. The leak is to the point where it is pooling under the door on the ground.

   NHTSA complaint #11665285 · source
3. Filed May 19, 2025TNElectrical SystemFuel, Hybrid & EV PropulsionSteering

   The ignition doest work right n want release the key the car dies n stalls while driving we was almost hit by a trooper n he called we spoke to 2 people n they had a gm call us n they said that this has been a big concern of these cars n we tried n tried to get it fixed n they say sorry can't can they when something they built wrong kills me or my family my vin [XXX] 2008 CHEVY COBALT [XXX] IS MY NUMBER INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA),…

   NHTSA complaint #11661851 · source
4. Filed Apr 7, 2025259,000 miORAirbagsElectrical System

   Our vehicle has had zero accidents the airbag light showed up on dashboard stating check airbags. Then as far as electrical the headlights seem to turn on there own at times. We feel this perhaps is a recall not known yet.

   NHTSA complaint #11653303 · source
5. Filed Dec 7, 2024FLOther / Unknown

   I have 2 recalls with the ignition and switch. I went to Regal chevrolet in Lakeland Florida and was told essentially there's nothing they could do and if they did look at it I'd be charged $200 to have it looked at plus $219 a hour based on what needed to be done. I then called Stingray Chevrolet in Plant City Florida and was told that there was no listed recall or it had already been serviced, which on the national website clearly states the opposite, and they refused to…

   NHTSA complaint #11629405 · source
6. Filed Dec 3, 2024GAAirbagsElectrical System

   The contact owns a 2008 Chevrolet Cobalt. The contact stated that upon starting the vehicle, the air bag warning light illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 14V047000 (Air Bags, Electrical System). The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was unknown.

   NHTSA complaint #11628474 · source
7. Filed Sep 9, 2024INFuel, Hybrid & EV Propulsion

   The gas lines rusted out and the fuel pump is pooring gas out of it. I just bought the car 2 weeks ago smelled gas hit u set the car it was pouring out. I was going to fix it my self then while looking up the parts I ran across the fact they recalled both parts but not for my vin . What can I do. I'm gonna catch on fire

   NHTSA complaint #11613382 · source
8. Filed Jul 15, 2024TXSeats & Seat Belts

   My back seat belts don’t work properly. It takes 10-20 mins to try to get it to come out to buckle up. It locks up no matter how many times to let it roll up and try again. It’s happened since I’ve owned my car since 2019-2020. It’s the back seat belts only

   NHTSA complaint #11602487 · source

Compare the 2008 Chevrolet Cobalt with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 11, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology