2010 Chevrolet Cobalt problems, complaints & recalls

2010 Chevrolet Cobalt recalls (5)

• Recall 15V500000Aug 10, 201559,474 vehicles
  AIR BAGS:SIDE/WINDOW

  General Motors LLC (GM) is recalling certain model year 2010 Chevrolet Cobalt vehicles manufactured January 4, 2010, to June 23, 2010. The affected vehicles may be equipped with an improperly routed Side-Impact Sensor (SIS) wiring harness in the driver side front door. The misrouted wiring harness could cause an electrical short that disables the driver side curtain air bag.

  Risk: A disabled driver side roof-rail air bag will not deploy in the event of a crash necessitating deployment of that air bag, increasing the risk of injury to the driver.

  Remedy: GM will notify owners, and dealers will inspect the sensor's wiring in the driver's door and make repairs as necessary, free of charge. The recall began on September 8, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15075.

• Recall 14V171000Apr 10, 20142,191,014 vehicles
  ELECTRICAL SYSTEM:IGNITION

  General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.

  Risk: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.

  Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.

• Recall 14V153000Mar 31, 20141,373,177 vehicles
  STEERING:ELECTRIC POWER ASSIST SYSTEM

  General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

  Risk: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

  Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.

• Recall 14V047000Feb 10, 20142,190,934 vehicles
  AIR BAGS · ELECTRICAL SYSTEM:IGNITION:SWITCH

  This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

  Risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

  Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

• Recall 10V073000Mar 3, 20101,050,889 vehicles
  STEERING:ELECTRIC POWER ASSIST SYSTEM

  General motors is recalling certain model year 2005-2010 chevrolet cobalt and model year 2007-2010 pontiac g5 vehicles equipped with electric power steering. The driver may experience a sudden loss of power steering assist that could occur at any time while driving.

  Risk: If power steering assist is lost, it would require greater driver effort at low vehicle speeds, increasing the risk of a crash.

  Remedy: Dealers will replace the electric power steering motor free of charge. Owners are being notified on a rolling basis between march 29 through november 2010. A copy of the mailing schedule is located in the recall file. Owners may contact chevrolet at 1-800-630-2438 and pontiac at 1-800-620-7668 or at the owner center at www.gmownercenter.com.

NHTSA defect investigations

• PE20011Opened Jul 5, 2020Closed Aug 17, 2023

  Fuel Line Leak

  On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a pro…

Recent 2010 Chevrolet Cobalt complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Aug 15, 2026IAAirbags

   Walked out to the car and the side air bags deployed and now it won't start. No power No accident. Drove it to the driveway and parked it. Now it won't start.

   NHTSA complaint #11757142 · source
2. Filed Sep 24, 202554,000 miILSteering

   The contact's daughter owns a 2010 Chevrolet Cobalt. The contact stated that while driving at various speeds, the power steering assist failed to operate as needed. There was no warning light illuminated. Due to the failure, extra effort was needed to steer the vehicle. The vehicle was not diagnosed or inspected for the failure. The manufacturer was notified of the failure and informed the contact that there were no recalls related to the failure for the VIN. Upon…

   NHTSA complaint #11689350 · source
3. Filed Sep 3, 2025TXCrash3 injuredTowedAirbags

   The contact owned a 2010 Chevrolet Cobalt. The contact stated that, while her daughter was driving at an undisclosed speed during an ice and rainstorm with poor visibility, a vehicle parked sideways in the middle of the roadway suddenly appeared. Unable to stop in time, the vehicle collided with the driver's side rear of the other vehicle, causing it to spin and veer onto the shoulder of the roadway before coming to a complete stop. The air bags deployed but failed to…

   NHTSA complaint #11684808 · source
4. Filed Jul 15, 2025MOOther / Unknown

   Our daughter observed a significant puddle forming under her vehicle and noticed a strong smell of gasoline. She sent us a video, which clearly showed gasoline leaking from the driver-side rear area of the car. Due to the proximity of the fuel leak to the exhaust pipe, we had the car towed to a mechanic, as it was too dangerous to drive. The mechanic diagnosed the issue as a severely rusted-out fuel line that required immediate repair. At no point did the vehicle display any…

   NHTSA complaint #11673793 · source
5. Filed Oct 25, 2024ILBody & Structure

   Internal mechanism of the driver-side door handle broke and the door would not open from the inside. Tne dealership confirmed that the inside door ah glue is broken. The cable retainer snapped apart and the cable cannot stay connected. This might be available for inspection. Driver must exit the vehicle by crawling over to the passenger side. The problem has been confirmed by a Chevrolet dealer. There were no warning lamps or messages. The manufacturer no longer makes this…

   NHTSA complaint #11621929 · source
6. Filed Jul 8, 2024OHFireFuel, Hybrid & EV Propulsion

   I found out about the recall on the 2007-2009 on the corrosion of the gas lines on drivers side rear wheel when i took my car to a chevy dealer and they said its the same thing thats happening to my car.and that they only did the recall on 2007-2009 colbalt models .the last colbalt's made was the 2010 models.why didnt they recall them also.i took it to another chevy dealer in amelia and they said the same thing.this needs to be recalled asap.its a safety related defect from…

   NHTSA complaint #11600169 · source
7. Filed Feb 5, 2024260,000 miMDTowedBrakesElectrical SystemSteering

   The contact owns a 2010 Chevrolet Cobalt. The contact stated while driving 55 MPH, the power steering and brakes became inoperable. The driver was able to coast to the side of the road. The check engine warning light was illuminated after the failure. The vehicle was towed to her parent's residence. The vehicle was serviced by an independent mechanic, who stated that the failure was due to the ignition switch. The local dealer was contacted, but the vehicle was not diagnosed…

   NHTSA complaint #11569973 · source
8. Filed Jan 17, 2024NDSeats & Seat BeltsAcceleration & Cruise Control

   Seatbelts lock up and do not move. Seatbelts are front driver and passenger side. Seatbelts can't be worn because they do not work

   NHTSA complaint #11565908 · source

Compare the 2010 Chevrolet Cobalt with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 11, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology