2019 Chevrolet Equinox fuel, hybrid & EV propulsion problems

Related recalls

• Recall 19V667000Sep 19, 2019301 vehicles
  FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

  General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Equinox all-wheel drive vehicles. The fuel tanks may have been manufactured with an improperly sealed seam, possibly allowing fuel to leak along the seam near the fuel inlet.

  Risk: A fuel leak in the presence of the ignition source can increase the risk of a fire.

  Remedy: GM will notify owners, and dealers will replace the fuel tank, free of charge. The recall began October 24, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N192271870.

What owners say

1. Filed Oct 6, 2026OHBrakesElectrical SystemFuel, Hybrid & EV Propulsion

   SAFETY VEHICLE COMPLAINT / DEFECT REPORT Vehicle: 2019 Chevrolet Equinox Complaint Type: Brake Failure / Loss of Braking Ability / Vehicle Malfunction Incident Date: XXX Location: [XXX] Request: Safety defect investigation Description of Incident On XXX, while my 2019 Chevrolet Equinox was being operated in the [XXX] area after exiting the highway, the vehicle experienced a serious and potentially life-threatening malfunction. As the vehicle approached a situation requiring…

   NHTSA complaint #11769359 · source
2. Filed Jun 4, 2026SDFuel, Hybrid & EV Propulsion

   The Fuel Pump Control Module (FPCM) connector corroded and disabled the fuel pump system. My car's fuel system failed while driving, and I had to pull over. After further research, I found that this particular FPCM and connector are located by the rear passenger axle and are exposed to the weather elements. This makes corrosion highly likely and poses a significant security threat for drivers, as there was no warning or engine light indication until moments before the…

   NHTSA complaint #11742004 · source
3. Filed Feb 6, 2026NJFuel, Hybrid & EV Propulsion

   This issue presents a serious safety concern. During the initial occurrence, the vehicle was unable to sustain highway speeds for extended periods (approximately 10 minutes or more). When coming to a stop, the vehicle would shake, rev unexpectedly, lose power, and shut off completely. During these events, the vehicle would not accelerate, creating a hazardous situation, especially in traffic. The condition has since worsened. The same symptoms now occur upon starting the…

   NHTSA complaint #11716345 · source
4. Filed Feb 5, 2026TXEngineFuel, Hybrid & EV Propulsion

   A "Reduced Engine Power" warning in a 2019 Chevrolet Equinox LT usually indicates the car has entered "limp mode" to protect the engine, most commonly caused by a dirty/faulty throttle body, loose Charge Air Cooler (CAC) tube, or sensor issues (MAF/TPS). Common codes include P0299 (turbo underboost). When this occurs, I cannot utilize my remote starter. I purchased an Innova OBD2 Code Reader, connected it to the vehicle and this code P0299 populated. There has been a few…

   NHTSA complaint #11716010 · source
5. Filed Jan 25, 2026NYFuel, Hybrid & EV Propulsion

   Could smell gas, looked under car saw gas dripping on driveway, coming from area where fuel tank is located, looks like it is coming from top of tank. Gas seems to leak only when tank is full and the outside temperature is cold ,below 20 degrees.

   NHTSA complaint #11713210 · source
6. Filed Dec 11, 202589,000 miMAFuel, Hybrid & EV Propulsion

   The contact owns a 2019 Chevrolet Equinox. The contact stated that while driving at an undisclosed speed, the contact became aware of a fuel-like odor coming from the driver’s side of the vehicle. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the sealed seam had failed and the fuel tank needed to be replaced. The vehicle was not repaired. The dealer was contacted; however, the vehicle was…

   NHTSA complaint #11704525 · source
7. Filed Nov 20, 2025MAFuel, Hybrid & EV Propulsion

   Drove car down street and the car wouldn’t accelerate. Had towed to mechanic who found the direct injection high pressure fuel pump snapped off. When removed from vehicle they found broken bolt in cylinder head and the steel fuel line from pump to injector rail leaking fuel.

   NHTSA complaint #11700669 · source
8. Filed Oct 27, 2025NJFuel, Hybrid & EV Propulsion

   I had an issue starting the vehicle. Once it started the check engine light was lit. I stopped at the nearest Autozone for a diagnostic check and the code P00C6 registered for Fuel Pump. I had the vehicle checked by a mechanic and he explained to me this vehicle has (2) fuel pumps. One in the fuel tank and one on the engine, which is considered a high pressure fuel pump. That is where the failure is and the pump requires special tools to install. It is something they can not…

   NHTSA complaint #11695922 · source
9. Filed Oct 1, 2025MIEngineFuel, Hybrid & EV PropulsionOther / Unknown

   I was stopped at a traffic light and the car just froze. All the dash lights started flashing, the brakes would not work. The car started moving slowly backing up traffic behind me. I barely made it to a parking lot off the road.

   NHTSA complaint #11690724 · source
10. Filed Feb 10, 2025229,000 miKYFuel, Hybrid & EV Propulsion

    The contact owns a 2019 Chevrolet Equinox. The contact stated that upon inspecting the vehicle, there was fuel leaking onto the driveway near the fuel tank. No warning lights were illuminated. The contact stated that the dealer was contacted. The vehicle was not taken to a dealer or independent mechanic to be diagnosed. The vehicle was not repaired. The VIN was not included in NHTSA Campaign Number: 19V667000 (FUEL SYSTEM, GASOLINE). The manufacturer was not notified of the…

    NHTSA complaint #11641676 · source
11. Filed Dec 13, 2024NCEngineFuel, Hybrid & EV PropulsionTransmission & Drivetrain

    Vehicle runs with reduced engine power. Was initially told the turbo needed cleaned, and it continued to happen. Then was told it needed to be replaced. The final result is that the tube that connects to the turbo keeps falling off. Being told there is no fix, and no recall, we just need to keep putting it back on when it pops off.

    NHTSA complaint #11630664 · source
12. Filed Oct 29, 2024CTFuel, Hybrid & EV Propulsion

    I have had my vehicle in for repair three times for an EVAP code. The first visit they found nothing wrong. The second visit they placed the EVAP canister. The third visit they said if the light comes on again it's a faulty part. The light is on again. Since the first occurence, I have noticed the some of the same issues that were reported for the 2020 Equinox fuel pump issues, e.g. hesitation, choking,

    NHTSA complaint #11622414 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology