2016 Chevrolet Volt transmission & drivetrain problems

Related recalls

No recalls on file.

What owners say

1. Filed Mar 20, 2026UTElectrical SystemTransmission & Drivetrain

   I have a 2016 Chevy volt. It had to be towed to a Chevy dealership because it will not drive. The BECM module has failed, as is apparently the case with so many volt owners. GM, as a result of lawsuits about this car, extended the warrantee to fix the issue, but my vin number is not included in the case. The gar is a brick, and there is no way to fix it now. GM doen't even replace these batteries any more, and most often just buys back the bad vehicles. I still owe 9k on…

   NHTSA complaint #11725794 · source
2. Filed Jan 14, 2026MNElectrical SystemTransmission & Drivetrain

   While I driving in the past week, a warning that "propulsion power reduced" appeared on my dashboard several times. The last time that I had driven the car, the heater would not turn off, and the smell of burnt rubber filled the car and then dissipated soon after. The car would only run in it's gas engine mode, and not switch over to electric mode, as it usually would. The next morning, the car would not start. The dash board would light up as if the car started, but when I…

   NHTSA complaint #11711001 · source
3. Filed Jul 25, 2025NCElectrical SystemFuel, Hybrid & EV PropulsionTransmission & Drivetrain

   Driving at 75 MPH on the freeway the power completely cuts off an a message appears on my dash "Propulsion Power is Reduced" - Pressing the gas barely gives any power, Imagine being in the middle of flowing traffic doing 75 mph to close to 20 mph. Research shows me this is a KNOWN issue with GM and the problem is with the BECM control module. There is also the issue of the EGR valve which apparently is tied into the BECM. I brought to the Chevy dealer and they said the BECM…

   NHTSA complaint #11676109 · source
4. Filed Jan 29, 2025FLElectrical SystemTransmission & Drivetrain

   Vehicle had the Battery Energy Control Module fail at about 87,000 miles. Vehicle will not start and will leave you stranded when this happens. This is a known defect and GM issued a special coverage to extend the warranty for this specific component, but for some reason only applies to a handful of VINs. Mine was not one of them, so I got stuck with a $2500 repair bill. I love the car and am not mad that they are breaking, engineering is hard. I am mad that even after a…

   NHTSA complaint #11639391 · source
5. Filed Oct 15, 202483,574 miCATowedElectrical SystemTransmission & Drivetrain

   The contact owns a 2016 Chevrolet Volt. The contact stated that while starting and driving at an undisclosed speed, the "Reduced Propulsion" message was displayed. Additionally, after parking the vehicle, the "Shift To Park" message was displayed, and the vehicle failed to turn off. The contact pressed the Start/Stop button and then opened and closed the front driver's side door to turn off the vehicle. The vehicle later failed to charge and start as needed. The vehicle was…

   NHTSA complaint #11619890 · source
6. Filed Oct 14, 2024NVEngineFuel, Hybrid & EV PropulsionTransmission & Drivetrain

   Faulty micro-switch from factory, causes power surge. Flawed microswitch in transaxle shift cable. Incomplete connection of microswitch resulting higher voltage to PCM.(power control module) This irregularity, shows a DTC code reducing power propulsion during movement. The car will loose power & ability to shift. During driving movement. Quite a safety concern. A "shift to park" error displays on driver display screen. An OBD2 scanner will clear code & after a few attempts…

   NHTSA complaint #11619712 · source
7. Filed Oct 11, 2024OHElectrical SystemFuel, Hybrid & EV PropulsionTransmission & Drivetrain

   My 2016 Chevrolet Volt loses power while driving and the "propulsion power reduced" warning message appears. This has happened multiple times in the past few weeks and it is very dangerous losing power while traveling. After taking it to a Chevy dealer for service, they advised that it was an internal failure of the BECM (battery energy control module) and that it would need replaced. After searching online it appears that this is a common issue with the Chevy Volt models…

   NHTSA complaint #11619238 · source
8. Filed Oct 9, 2024VAEngineFuel, Hybrid & EV PropulsionTransmission & Drivetrain

   The vehicle loses power when trying to accelerate when driving in electric mode, and the gas engine kicks on after a second at which point acceleration returns. It occurs when the battery power is high or low. Sometimes a warning pops up on the dash saying speed is limited to a specific MPH.

   NHTSA complaint #11619001 · source
9. Filed Jun 18, 2024MIElectrical SystemEngineTransmission & Drivetrain

   I was driving in clear weather (with my ICE engine as propulsion) when an Engine Warning Fault light appeared on my dash and the vehicle slowed to 5mph with no response from the throttle pedal. I pulled into a parking lot, had the vehicle towed to an independent service shop, and had them check the codes. There were a dozen faults stored, but they found the 'Non Walk Home' fuse had blown, and faults pointed to the EGR Valve as having faulty electronics. They could not find…

   NHTSA complaint #11595024 · source
10. Filed May 7, 2024VAEngineFuel, Hybrid & EV PropulsionTransmission & Drivetrain

    On [XXX], this Volt was towed to the Dealer because the Volt would not start, would not charge, and the engine light was on. The Dealer claimed that the problem was the Chevrolet Volt Battery Energy Control Module (BECM), GM Part # 24296900, which was covered under the GM hybrid VOLTEC warranty (8 years, 100,000 miles). On [XXX], 2024, this Volt (VIN [XXX] ) was towed to the Dealer again because the Volt would not start, would not charge, and the engine light was on. The…

    NHTSA complaint #11587363 · source
11. Filed Mar 26, 2024FLFuel, Hybrid & EV PropulsionTransmission & Drivetrain

    GM issued a special coverage warranty for 2016-2018 Chevrolet Volts that had a BECM failure. However, they did not include all of the Volts. We have a 2016 that has a catastrophic BECM failure. The car won't start and the only indicator was the day before it said the vehicle didn't charge. This appears to be the same issue, but Chevrolet did not include our model. We have about 87k miles and are only 3 weeks past the original warranty.

    NHTSA complaint #11579517 · source
12. Filed Jan 10, 2024NCElectrical SystemLightingTransmission & Drivetrain

    Vehicle suddenly lost power and displayed shift to park on display. Vehicle will not respond or display any status other than shift to park. Vehicle towed to dealership. Diagnosis of their mechanic is failed BECM module. Vehicle was brought to dealership 3yrs ago with infotainment center problems. Infotainment Software was updated but problem persisted. 2 years ago it was brought to dealership with complaint of intermittent inability to charge propulsion battery. Sunshine…

    NHTSA complaint #11564678 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology