2012 Dodge Durango electrical system problems

Related recalls

• Recall 19V813000Nov 14, 2019528,594 vehicles
  ELECTRICAL SYSTEM

  Chrysler (FCA US LLC) is recalling certain 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles equipped with a 3.6, 5.7, or 6.4 liter engine and previously recalled under NHTSA Recall 14V530 or 15V115. The fuel pump relay inside the Totally Integrated Power Module (TIPM-7) may fail, causing the vehicle to stall without warning.

  Risk: A vehicle stall increases the risk of a crash.

  Remedy: Chrysler (FCA US LLC) will replace the affected fuel pump relay and related wire harness. Interim notices informing owners of the safety risk were mailed beginning December 19, 2019. Vehicles that experience a fuel pump failure will receive an interim repair. Owners will receive a second notice when the final remedy becomes available. Owner notification letters were mailed on December 10, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V62.

• Recall 17V435000Jul 10, 2017442,214 vehicles
  ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

  Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Challenger, Dodge Charger, Chrysler 300, Dodge Durango, and 2012-2014 Jeep Grand Cherokee vehicles. The affected vehicles have electro-hydraulic power steering (EHPS) and are equipped with a 5.7L or a 3.6L engine and a 160, 180 or 220 amp alternator. In the affected vehicles, the alternator may suddenly fail.

  Risk: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash. There is also the possibility that the alternator may short circuit, increasing the risk of a fire.

  Remedy: Chrysler will notify owners, and dealers will inspect the alternator and depending on the part number, will replace the alternator, if necessary, free of charge. The recall began February 12, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T36.

• Recall 15V879000Dec 28, 2015389,252 vehicles
  ELECTRICAL SYSTEM:WIRING · INTERIOR LIGHTING

  Chrysler (FCA US LLC) is recalling certain model year 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured December 3, 2009, to September 1, 2012. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after having been remedied for a prior recall for the vanity lamp wiring. This recall is also addressing certain vehicles that have not been remedied under that prior recall.

  Risk: The vanity lamp wiring may short, increasing the risk of a vehicle fire.

  Remedy: Chrysler will notify owners, and dealer will install clearance for sun visor wiring, protection from sharp edges, and replace the sun visor, free of charge. The recall began on July 28, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R71.

• Recall 15V115000Feb 27, 2015339,525 vehicles
  ELECTRICAL SYSTEM

  Chrysler (FCA US LLC) is recalling certain model year 2012-2013 Jeep Grand Cherokee vehicles manufactured September 17, 2010, to August 19, 2013, and equipped with a 3.6, 5.7 or 6.4 liter engine, and 2012-2013 Dodge Durango vehicles manufactured January 18, 2011, to August 19, 2013, and equipped with a 3.6 or 5.7 liter engine. In the affected vehicles, the fuel pump relay inside the Totally Integrated Power Module (TIPM-7) may fail, causing the vehicle to stall without warning.

  Risk: A vehicle stall increases the risk of a crash.

  Remedy: Chrysler will notify owners, and dealers will replace the fuel pump relay with one external to the TIPM. The recall began on August 7, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R09. Note: This recall is an expansion of recall 14V-530. Note: This recall has been superseded by recall 19V813.

• Recall 14V634000Oct 8, 2014435,081 vehicles
  ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

  Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Chrysler 300, Dodge Charger, Challenger, and Durango; and 2012-2014 Jeep Grand Cherokee vehicles manufactured April 22, 2010, to January 2, 2014, and equipped with a 3.6L engine and a 160 amp alternator. In the affected vehicles, the alternator may suddenly fail.

  Risk: If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash.

  Remedy: Chrysler has notified owners, and dealers will replace the alternator, free of charge. The recall began on February 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P60.

• Recall 14V391000Jul 2, 2014653,562 vehicles
  ELECTRICAL SYSTEM:WIRING

  Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles manufactured January 5, 2010, through December 11, 2013. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after a service repair is performed.

  Risk: If the vanity lamp wiring shorts, there is an increased risk of fire.

  Remedy: Chrysler will notify owners, and dealers will inspect and repair any damaged wiring, and install a new sun visor that properly routes the wire, free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P36.

What owners say

1. Filed Sep 7, 2026INCrashBrakesElectrical SystemSteering

   The component or system failed or malfunctioned, is the accelerator, brakes, stirring and electrical. The car is available for inspection upon your request. The car is having problems coming to a stop and it is very difficult to control the vehicle because the steering becomes so hard when the power shuts down on the vehicle as I'm driving it. I think and believe that that poses a high risk of someone getting hurt or injured and then some cases perhaps death. the problem…

   NHTSA complaint #11762564 · source
2. Filed Aug 19, 2026MOElectrical System

   Vehicle was unable to start upon attempts in the morning. Was able to get it jumped and started. Less than 5 minutes later the dash lights along with radio lights began to flicker, the front windshield wipers activated, and the battery light came on. Immediately after the vehicle completely stopped, steering wheel got tight and hard to turn and a pole was barely missed as I attempted to maneuver the vehicle as close to the side of the road as possible. There was a complete…

   NHTSA complaint #11757912 · source
3. Filed Aug 16, 2026KYElectrical System

   We were driving on the interstate in northern Kentucky when the battery alert LED appeared on the dash. We exited the highway while looking up info on possible car repair shops to go to when the vehicle stalled on the exit ramp. We immediately engaged the emergency flashers but they failed eventually due to a completely dead battery. It was determined that the alternator was fried, unable to charge the battery.

   NHTSA complaint #11757232 · source
4. Filed Mar 5, 2026162,000 miNJElectrical System

   Odometer Fraud. The contact purchased a 2012 Dodge Durango. The contact discovered a mileage discrepancy after the purchase. The vehicle was a dealer sale. At the time of purchase, the mileage was 96,000. A Carfax Report was provided at the time of purchase. It was later discovered that the mileage on the Title was 162,000 when the vehicle was taken to the dealer for an engine issue, and upon receiving the Carfax Report.

   NHTSA complaint #11722172 · source
5. Filed Oct 21, 2025MTElectrical System

   Alternator went out and fried the pcm. I know certain vehicles were on the recall for this and mine was not one of them but odd that it happened anyways.

   NHTSA complaint #11694892 · source
6. Filed Jun 17, 2025186,488 miIAFireElectrical System

   The contact owned a 2012 Dodge Durango. The contact stated that while the vehicle was parked, the contact opened the door and noticed that the interior of the vehicle was completely burned. The vehicle was unoccupied. The contact stated the exterior of the vehicle had no signs of fire. The vehicle was towed to the local tow yard. The vehicle was condemned as a total loss. In addition, the contact stated that prior to the failure, there was an unknown warning light…

   NHTSA complaint #11667452 · source
7. Filed Aug 15, 2024UTFireElectrical System

   While driving our 2012 Dodge Durango in town, we noticed the battery warning light come on and a hot smell coming from the vehicle. We were not far from home so we limped it back home to the garage to see what was going on. When we lifted the hood, there was a very overwhelming burning smell, our alternator was literally glowing red hot, and there was smoke pouring out from around it. We quickly put out the fire and disconnected the battery. Afterwards, we had it towed to a…

   NHTSA complaint #11608818 · source
8. Filed Mar 15, 2024140,000 miCAElectrical System

   The contact owns a 2012 Dodge Durango. The contact stated while driving at various speeds, the vehicle would intermittently stall upon depression of the accelerator pedal without warning. The vehicle was taken to a local dealer where it remained in their possession for four days; the contact was later informed that the defect was related to the battery. Upon investigation, the contact discovered NHTSA Campaign Number: 19V813000 (Electrical System) which was linked to the…

   NHTSA complaint #11577651 · source
9. Filed Sep 13, 2023WIElectrical SystemTransmission & Drivetrain

   While picking my son up from religion my vehicle suddenly stalled without warning. Thankfully I was pulling into the church parking lot and was in no real danger. I tried to jump start the vehicle with no success, but did notice the insulation on the jumper cables had started to melt. Towed to mechanic and was told the alternator had failed, in turn fried the battery. He replaced both, but then discovered the PCM was fried as well. Took it to the dealer here and was told…

   NHTSA complaint #11544238 · source
10. Filed Aug 10, 2023LAElectrical SystemTransmission & Drivetrain

    I bought this vehicle second hand and was not warned of any recalls. I started having problems in April of 2023. Windshield wipers would turn on by themself, car would randomly shut off. I brought to several shops and nobody could figure out why it was reading “high voltage”. The car then started having occasional problems shifting. I eventually got on MOPAR website to be made aware there were 3 recalls and alternator was one of them. I called musson patout dodge in new…

    NHTSA complaint #11537620 · source
11. Filed Apr 24, 2023NEElectrical SystemEngineFuel, Hybrid & EV Propulsion

    I Came into dealership for scheduled service appointment on Apr 5, 2023 10:30:00 AM at EDWARDS CDJR OF OMAHA to get recall fixed on fuel pump relay and an oil change after receiving my 2012 Dodge Durango Citadel back my lights randomly starting blanking and my vehicle stalled and it wouldn’t start or turn over. So I spoke to service rep [XXX] at EDWARDS CDJR OF OMAHA 17950 Burt St and had the car towed back to the dealership that fixed on it EDWARDS CDJR OF OMAHA. I was…

    NHTSA complaint #11518792 · source
12. Filed Apr 10, 2023OHElectrical SystemOther / UnknownSteering

    I’ll be driving down the road and my car just shuts off. Steering becomes tight, no engine lights come on radio is still playing no warning except driving down the road and all of a sudden you can’t steer. It’s very dangerous especially when it happens while you are driving around the curve with children in the car. My mechanic can’t tell me why this happens. No explanation. This has happen several times

    NHTSA complaint #11516383 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology