2021 Ford Explorer brakes problems

Related recalls

• Recall 23V199000Mar 24, 2023674 vehicles
  PARKING BRAKE:ELECTRICAL · POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

  Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L RWD, 3.3L GAS, 3.3L FHEV, or 3.0L ST powertrain. The previous powertrain control module (PCM) update completed under recall 22V-255 did not include the automatic electronic parking brake feature when the vehicle is shifted to park, as intended. In addition, the rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.

  Risk: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.

  Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.

What owners say

1. Filed Jul 14, 2026MIBrakesDriver Assistance & Safety TechTransmission & Drivetrain

   I am reporting a safety concern involving a delayed transmission gear engagement and delayed rearview camera activation. Intermittently, when shifting the vehicle from Park into Reverse or Drive, there is a noticeable delay before the transmission actually engages the selected gear. During this delay, the rearview camera also fails to activate immediately. Because there is no immediate indication that the requested gear has engaged, I have experienced situations where I…

   NHTSA complaint #11750264 · source
2. Filed Jul 9, 202689,200 miMOBrakesTransmission & Drivetrain

   The contact owns a 2021 Ford Explorer. The contact stated that while driving at approximately 35 MPH down a hill, the engine and powertrain were resistant when the brakes were applied. No warning lights illuminated. A mobile mechanic was sent by a local dealer to inspect the vehicle. The mechanic determined that the failure was due to the transfer case but was not related to NHTSA Campaign Number: 26V402000 (Power Train). After test driving the vehicle, the mobile mechanic…

   NHTSA complaint #11749324 · source
3. Filed Apr 16, 2026NJBrakesElectrical System

   While I drive my vehicle down the road the car all of a sudden sounds like you throw it in park, it screeches and grinds in the front and will not let you push the gas pedal down even when on the highway. This causes sever risk to the people around me as well as my children who drive in this car… ford has an open recall for this which my vehicle falls under year and build wise. But does not correlate with my vin #

   NHTSA complaint #11731738 · source
4. Filed Apr 13, 202654,230 miNYBrakes

   The contact owns a 2021 Ford Explorer. The contact stated that while driving on several occasions at various speeds, the master warning, brake, battery, ABS, and brake system warning lights illuminated. Additionally, the message "STOP Safely Now" was displayed. The vehicle then went into LIMP Mode each time, but the vehicle failed to respond while the contact was attempting to turn off the vehicle or accelerate. The contact stated that while the vehicle was in neutral(N), it…

   NHTSA complaint #11730769 · source
5. Filed Jan 20, 2026FLBrakes

   While applying brakes coming to a stop light, the vehicle gave a message stating service brakes. The brakes still felt normal. Then after a few minutes, the brakes felt like they suddenly stopped working and then the rear tires started locking up and releasing. The frong brakes felt like they were not working at all. Stopping distance approximately tripled and not really any way to adjust braking pressure. Releasing the pedal would give a 2ish second delay before the brakes…

   NHTSA complaint #11712289 · source
6. Filed Aug 27, 2025MDBrakes

   Hi, i am concerned about the safety of my vehicle. i brought it to the attention of ford motor company and an authorized dealer that i am getting a parking brake warning on my dashboard. the authorized dealer inspected it, and said that the braking system is contaminated due to liquid spilling from the damaged cupholders. i communicated to them, that 1. the cupholders are clearly not strong enough to be placed over a critical component of the vehicle such as a braking…

   NHTSA complaint #11683418 · source
7. Filed Aug 7, 202585,000 miMABrakes

   The contact owns a 2021 Ford Explorer. The contact stated that while her husband was driving at an undisclosed speed, the brake pedal was sticking on three occasions. The contact stated that while driving at an undisclosed speed in a parking lot, the contact had to raise the brake pedal with her foot after the brake pedal was depressed. The contact stated that it felt like the parking brake was engaged. There were no warning lights illuminated. The vehicle was taken to the…

   NHTSA complaint #11679130 · source
8. Filed Jul 14, 2025MOBrakesEngineOther / Unknown

   I was stoped at a red light with cars in front of me and behind me when with my foot on the break the car accelerated forward like my foot was on the gas pedal but my foot was not on pedal, the car surged forward and came close to hitting the car in front of me I pressed the break and got stopped didn’t happen again but sometimes I can feel the car wanting to keep surging forward when breaking. If there is a problem this could cause me to hit someone in the rear or even…

   NHTSA complaint #11673262 · source
9. Filed Jul 30, 2024WIBrakes

   Part 573 Safety Recall Report 23V-675 The recall that is has been applied causes safety issues with the car when driving forward or in reverse. When putting the car into park the parking break auto applies. Now that is great however.. When putting the car into reverse or drive it does not release until the accelerator is applied. Now the problem is that the electric parking brake is delayed vs the acceleration causing the car to jerk forward or in reverse when the…

   NHTSA complaint #11605306 · source
10. Filed Jul 22, 2024TXBrakesDriver Assistance & Safety Tech

    All of the ADAS along with the brakes of my vehicle fail. The dealership failed to inform me of the recalls prior to purchase. The dealership in town shows all of the parts in stock in their parts department but claim not to have any parts available. When I called, I was given the runaround then sent to a voicemail. When I showed up to the dealership they stated they can only order certain amount of parts and I wasn’t on the list yet was told over the phone I was placed on…

    NHTSA complaint #11603758 · source
11. Filed Apr 10, 2024WICrashBrakesEngineFuel, Hybrid & EV Propulsion

    The recall to replace the rear axle bolt was completed and new boil installed. They left the automatic emergency brake program engager which results in the vehicle lurching forward or backward when shifted into gear and results in collisions with other vehicles as the collision detection system is not working.

    NHTSA complaint #11582046 · source
12. Filed Mar 5, 2024FLBrakesSuspensionTransmission & Drivetrain

    I hope this letter finds you well. I am writing to you regarding a persistent issue I have been experiencing with my 2021 Ford Explorer For some time now, I have noticed a loud sound when braking and when navigating obstacles such as speed bumps or when entering and exiting the ramp of my parking lot. Concerned about this situation, I took my vehicle to the service department at your dealership, where I was informed that there was a recall to replace a part related to this…

    NHTSA complaint #11575463 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology