2020 Hyundai Elantra engine problems

Related recalls

• Recall 21V301000Apr 28, 2021158,493 vehicles
  ENGINE

  Hyundai Motor America (Hyundai) is recalling certain 2019-2020 Elantra, 2019-2021 Kona and Veloster vehicles equipped with 2.0L Nu MPI engines. The piston oil rings may not have been properly heat-treated, which could result in engine damage.

  Risk: A damaged engine may stall, increasing the risk of a crash. In addition, oil may leak onto hot exhaust components, increasing the risk of a fire.

  Remedy: Dealers will inspect and, if necessary, replace the engine, free of charge. In addition, Hyundai will deploy Piston Ring Noise Sensing System (PNSS) software. Owner notification letters were mailed August 24, 2021. Owners may contact Hyundai customer service at 1-855-371-9460.

What owners say

1. Filed Oct 7, 2026CAEngineOther / Unknown

   2020 Hyundai Elantra, VIN [XXX], ~79,239 mi. On or about [XXX], while entering a parking lot at low speed on an incline, I pressed the accelerator but the car had severe power loss and then stalled. It would not move in reverse. All dashboard lights came on only after the stall. I restarted it; the lights cleared. It was towed to Westlake Hyundai, 3610 Thousand Oaks Blvd, Thousand Oaks, CA 91362; checked in Sep 29, 2026 8:59 AM. Dealer found engine oil below the low mark, no…

   NHTSA complaint #11769728 · source
2. Filed Sep 29, 2026FLEngine

   Back in early July, I noticed a ticking sound coming from my engine so when I took it in to a Hyundai dealership, they told me the only way I could pursue any help further was by completing a oil consumption test, which I complied and paid for out-of-pocket very soon after within 48 hours my check engine light came on and was flashing. after pulling the code at an AutoZone which I have documentation of it was a P 1327 which signals that the car had entered limp mode. I very…

   NHTSA complaint #11767885 · source
3. Filed Sep 24, 2026102,474 miVAEngine

   The contact owns a 2020 Hyundai Elantra. While driving at an undisclosed speed, the vehicle suddenly shut off without warning. The contact referenced NHTSA Campaign Number: 21V301000 (Engine) as a potential cause for the failure; however, the VIN was not included in the recall. The contact stated that the vehicle shook violently with an abnormal electrical wire burning odor. The manufacturer was notified of the failure. The vehicle was taken to an authorized dealer, where it…

   NHTSA complaint #11766673 · source
4. Filed Sep 10, 2026CAEngine

   The vehicle entered limp mode. The Hyundai dealer diagnosed a camshaft problem, said the repair would be covered, ordered the part, and began the work. After the engine was opened, the dealer noted sludge/varnish and denied coverage, claiming lack of maintenance. This VIN is included in safety recall 21V301 for improperly heat-treated piston oil rings on the 2.0L Nu MPI engine. Hyundai told NHTSA that chipped rings can scuff the cylinder bore, cause accelerated oil…

   NHTSA complaint #11763344 · source
5. Filed Sep 9, 2026CACrash1 injuredTowedElectrical SystemEngineOther / Unknown

   2020 HYUNDAI [XXX], VIN: [XXX] Incident Description: On XXX I was pulling into a parking spot and had my foot firmly on the brake pedal. When I attempted to shift the vehicle into Park the engine suddenly revved up excessively. The vehicle then accelerated forward on its own and crashed into a building. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint #11763045 · source
6. Filed Sep 2, 202646,961 miCATowedEngine

   The contact owns a 2020 Hyundai Elantra. The contact stated that while driving 25 MPH, there was an abnormal rattling sound coming from the engine, with the check engine warning light illuminated. The contact pulled over to the side of the road. The vehicle was restarted but unexpectedly stalled. The vehicle was taken to an independent mechanic and was diagnosed with camshaft failure. The vehicle was towed to the dealer and was diagnosed with engine failure caused by a…

   NHTSA complaint #11761736 · source
7. Filed Aug 9, 2026AZEngine

   At 105,000 MI. My car stalled out and the engine stopped. It needs a new cam shaft, timing chain set, cam phaser and timing cover. We also had to replace the Variable valve timing solenoids as the metal melted.

   NHTSA complaint #11755778 · source
8. Filed Jul 28, 2026AZEngine

   "I was not notified of Campaign 974 and later experienced engine problems/failure. I am requesting review of whether the campaign was completed and whether the failure is related to the condition the campaign was intended to detect. My engine failed while pulling up to a house, stopping, then preparing to move again the car stalled, car stalled, car would not start for several times tried, then started was able to drive for about 10 miles then stalled again and would not…

   NHTSA complaint #11753202 · source
9. Filed Jun 9, 2026NJEngineAcceleration & Cruise ControlTransmission & Drivetrain

   Currently, there are 30,564 miles on my vehicle and I am the original owner of the vehicle since early 2021. This is a continuous intermittent problem that can occur at any time when trying to accelerate the vehicle. The vehicle could be moving down the road and you go to accelerate and the RPM's drop dramatically, giving you no power. The same thing has happened when trying to accelerate from a stop. The vehicle would start to accelerate and then all of a sudden the RPM's…

   NHTSA complaint #11742932 · source
10. Filed May 26, 2026105,000 miCAEngine

    The contact owns a 2020 Hyundai Elantra. The contact stated that while driving, the vehicle unexpectedly stalled. The vehicle was able to restart. The check engine light illuminated. The vehicle was taken to an independent mechanic Camshaft sensor failure. The camshaft sensors were replaced; however, the issue persisted. The vehicle was then taken to the dealer where it was diagnosed with engine failure but the vehicle was not repaired. The manufacturer was notified of the…

    NHTSA complaint #11740154 · source
11. Filed May 25, 2026MDBrakesEngineOther / Unknown

    This complaint documents a recurring automatic transmission failure resulting in three complete vehicle shutdowns during active operation — two at highway speed and one in an active turning lane. The most recent failure occurred within 15 minutes of the vehicle being released from an authorized Hyundai dealership in College Park, Maryland, whose general manager admitted in a recorded call that the vehicle was released knowing the transmission was unrepaired and unsafe. The…

    NHTSA complaint #11739852 · source
12. Filed May 15, 202676,000 miNCEngineTransmission & Drivetrain

    The contact owns a 2020 Hyundai Elantra. The contact stated that while driving at an unknown speed and at a stop, the vehicle lunged forward. The RPM increased and decreased without applying the accelerator pedal. The check engine light was illuminated. A mobile mechanic reset the codes but was unable to determine the failure. The vehicle was taken to an independent mechanic who referred him to the local dealer. The local dealer was contacted, who stated there was a…

    NHTSA complaint #11738079 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology