2020 Hyundai Tucson problems, complaints & recalls

2020 Hyundai Tucson recalls (1)

• Recall 20V543000Sep 4, 2020652,024 vehiclesPark outside
  SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

  Hyundai Motor America (Hyundai) recalled certain 2019-2021 Tucson vehicles on September 4, 2020. On December 30, 2020, Hyundai expanded the recall population, and added certain 2016-2018 Tucson vehicles. The Anti-lock Brake Hydraulic Electronic Control Unit (HECU) could corrode internally and cause an electrical short, possibly resulting in an engine compartment fire.

  Risk: An engine compartment fire can increase the risk of injury or crash.

  Remedy: Hyundai will notify owners, and dealers will replace the HECU fuse. For 2019-2021 model years, the Electronic Stability Control (ESC) software will also be updated. Recall repairs will be performed free of charge. Owners are advised to park outside and away from structures as a precaution until the recall repair is complete. The recall began November 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 195.

NHTSA defect investigations

• AQ23002Opened Nov 17, 2023Open

  Hyundai and Kia ABS Module Fires

  The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, …

NHTSA 5-Star safety ratings

Recent 2020 Hyundai Tucson complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Sep 25, 2026CAEngine

   On XXX, while driving at freeway speed in [XXX] with my [XXX] son in the back seat, the engine of my 2020 Hyundai Tucson (2.4L Theta II GDI, approx. 99,108 miles) seized suddenly and without warning. I lost all motive power in moving traffic and coasted to the shoulder, where my son and I sat stranded for 30 minutes with smoke and a burning smell coming from the engine while waiting for a tow. No warning lamps or messages appeared before the failure. COMPONENT FAILED:…

   NHTSA complaint #11766998 · source
2. Filed Sep 18, 2026NJEngineFuel, Hybrid & EV Propulsion

   Engine has defect that causes oil to heat at an unusual levels there for damaging other vehicle components such as The exhaust system parts clogging up and Triggering check engine warning lights for emissions.

   NHTSA complaint #11765249 · source
3. Filed Aug 20, 202680,000 miINEngine

   The contact owns a 2020 Hyundai Tucson. The contact stated that while the vehicle was receiving a routine oil change, the contact was informed that the oil pan was empty. The contact was advised to take the vehicle to the dealer. The contact was informed about a possible oil consumption test. The contact was informed that there was carbon blowing out of the vehicle. The contact stated that three months later, the oil pan was empty. The vehicle was taken back to the dealer,…

   NHTSA complaint #11758267 · source
4. Filed Aug 9, 2026MDFuel, Hybrid & EV Propulsion

   Dealer completed update 9C2 Theta 2 emissions update. After update, the car sputters slightly and increased noise is heard from the tailpipe. Customer returned to dealer after driving the car in different temps and noted the above complaint. Dealer verified the complaint but continues to take no responsibility for the fault on the repair receipt by writing condition is “normal” and recommending “customer to allow vehicle to properly warm up for one to three minutes prior to…

   NHTSA complaint #11755723 · source
5. Filed Jul 28, 2026UTEngine

   The engine lost power while driving, and the vehicle entered a reduced-power mode. The check engine light began flashing, and the engine made a loud knocking noise during acceleration. A diagnostic scan showed code P1326 (Knock Sensor Signal Range/Performance). The knock sensor was replaced, and the engine oil was refilled after discovering an oil leak. The vehicle operated normally for a short time, but the same symptoms returned. The vehicle is available for inspection.…

   NHTSA complaint #11753365 · source
6. Filed Jul 18, 2026NYEngine

   Tried passing someone on the thruway, as I was about to the car jerked a bit then started decelerating. The check engine light started flashing and so did the oil light. Read the code as cylinder 3 misfire and a knock sensor. Changed the spark plugs and coil packs then checked the oil and saw there was no oil in the engine. Was told by my mechanic it’s a common problem with these Hyundai engines, it seems the rings are getting fried in the engine and that’s why it consumes…

   NHTSA complaint #11751269 · source
7. Filed Jul 14, 2026NCEngine

   While driving on the highway with adaptive cruise control on, car began decelerating without any vehicle in front. Started to get off highway, check engine light began flashing and came to a full stop. Car died. Tried restarting and car died. Check engine, oil and battery lights then on. Total engine failure and no warning lights prior.

   NHTSA complaint #11750442 · source
8. Filed Jul 8, 2026SCCrash1 injuredTowedAirbags

   Was in a side impact car accident last year. And have been speaking with Hyundai off and on since the accident and have basically been brushed off in my concerns about the fact my airbags never deployed when my rear passenger door was essentially ripped off during the car accident. Progressive moved quickly with my claim and Hyundai pretty much told me not their problem since progressive moved the vehicle so fast and they said they can’t locate it even though I gave them…

   NHTSA complaint #11749066 · source

Compare the 2020 Hyundai Tucson with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 10, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology