2006 Jeep Liberty problems, complaints & recalls

2006 Jeep Liberty recalls (4)

• Recall 18V278000May 1, 2018239,904 vehicles
  SUSPENSION:REAR

  Chrysler (FCA US LLC) is recalling certain 2004-2007 Jeep Liberty vehicles. The rear suspension lower control arms can fracture due to excessive corrosion, causing a loss of vehicle control.

  Risk: A fractured control arm can cause a loss of vehicle control, increasing the risk of a crash.

  Remedy: Chrysler will notify owners, and dealers will replace the rear lower control arms, free of charge. The recall began June 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U38. Note: This recall is an expansion of recall 12V-085. Vehicles included in that campaign are not included in this recall.

• Recall 15V222000Apr 15, 201543,939 vehicles
  POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)

  Chrysler (FCA US LLC) is recalling certain model year 2006 Dodge Viper and Jeep Wrangler and Liberty vehicles manufactured July 1, 2005, to July 31, 2006. In the affected vehicles, the springs within the clutch pedal position switch that prevents the vehicle from starting unless the clutch pedal is pushed down may break. As a result, the vehicle may not be started when the clutch pedal is pushed down or the engine may crank and start without the clutch pedal being pushed down causing the vehicle to unexpectedly lurch.

  Risk: If the vehicle unexpectedly moves there is an increased risk of a crash.

  Remedy: Chrysler will notify owners, and dealers will replace the clutch ignition interlock switch, free of charge. The recall began on August 31, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R13.

• Recall 13V252000Jun 19, 20131,560,000 vehicles
  FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY · STRUCTURE

  Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.

  Risk: A fuel leak in the presence of an ignition source may result in a fire.

  Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).

• Recall 12V085000Mar 5, 2012346,900 vehicles
  SUSPENSION:REAR

  In june 2012, chrysler expanded this recall to include model year 2006 and 2007 jeep liberty vehicles, representing an additional 137,176 vehicles. This recall now concerns certain my 2004-2007 jeep liberty vehicles. The total number vehicles being recalled is now 346,900. These vehicles were manufactured from july 3, 2003 through june 29, 2007. The recall addresses those vehicles originally sold, or currently registered in, connecticut, delaware, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin, and the district of columbia. Some vehicles may be equipped with rear lower control arms that can experience a rear suspension lower control arm fracture due to excessive corrosion due to application of road salts during winter weather conditions.

  Risk: A fracture of the rear lower control arm may result in a loss of vehicle control and may lead to a vehicle crash.

  Remedy: Chrysler will notify owners, and dealers will replace the rear lower control arms on all affected vehicles originally sold in, or currently registered in, connecticut, delaware, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin, and the district of columbia, free of charge. The safety recall began on march 26, 2012. Owners may contact chrysler at 1-800-853-1403.

NHTSA defect investigations

• EA12005Opened Jun 12, 2012Closed Nov 14, 2014led to recall 13V252000

  Crash Related Fuel Tank Fires

  ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and…

• AQ10001Opened Nov 18, 2010Closed Dec 28, 2015

  Fleet Vehicle Recall Completion Audit

  On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this…

• PE07041Opened Aug 8, 2007Closed Dec 7, 2007

  Diesel fuel leak

  Overheating of the electrical connector at the fuel heater on the fuel filter / water separator assembly can cause a fuel leak through the electrical connection.operators report the smell of diesel fuel, smoke, difficulty starting and/or poor engine operation.the fuel leakage is reported by some operators as seepage, wetness, several drops, and an oz per minute.evidence of overheating of the connection was observed by some operators and reported as burned or discolored electrical connection at the fuel heater.seven operators report smelling or seeing smoke.one reported a vehicle engine compart…

• PE06056Opened Nov 21, 2006Closed Mar 12, 2007led to recall 07V089000

  Interior fire, passenger side dash area

  This investigation was opened on november 21, 2006 based on two owner reports and one e-mail report alleging an interior fire in the passenger side area of the dash panel.daimlerchrysler (dcc) has identified a defect in the blower motor of the hvac system in the subject vehicles and in certain 2007 model year liberty vehicles.the defect report states, under certain conditions the heating, ventilation and airconditioning (hvac) blower motor may overheat and cause an interior fire.dcc will recall 149,065 vehicles to replace the original hvac blower motor with one of a new design.the vehicles inc…

• EA06008Opened May 31, 2006Closed Aug 24, 2006led to recall 06V288000

  Front suspension ball joint separation

  On january 6, 2006, the office of defects investigation (odi) opened a preliminary evaluation to investigate alleged front suspension lower ball joint separationin certain model year (my) 2004 jeep liberty vehicles.odi sent a letter to the manufacturer on february 7, 2006 requesting information about these and other jeep liberty vehicles.consequently, the investigation was upgraded to an engineering analysis on may 31, 2006 and the range of subject vehicles under investigation was expanded to include all my 2002-2006 jeep liberty vehicles.odi is aware of 566 non-duplicative complaints alleging…

Recent 2006 Jeep Liberty complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Sep 12, 2026OKSuspension

   The front passenger side lower ball joint corroded, failed, or detached while I was driving, causing the front of the car to basically fall onto the tire/steering to fail. I had to immediately pull over right before entering the highway as it was undriveable. Thankfully I wasn’t going fast bc this could’ve caused a crash or flipped my car. There was a recall for this exact issue for 800,000 Jeeps of the same make, model, and year, but this exact VIN wasn’t included in the…

   NHTSA complaint #11763816 · source
2. Filed Aug 3, 2026NCCrash2 injuredTowedAirbags

   Two of my sons were involved in a rollover accident. Thankfully, they are ok with minor injuries and bruising. However, none of the airbags deployed.

   NHTSA complaint #11754588 · source
3. Filed Jul 21, 2026163,911 miCOSuspension

   ball joint recall was issues and done on paper in August 2006 on the Jeep liberty. Both ball joint have failed on this vehicle at different times this year while driving the vehicle and Jeep has declined to take any responsibility in any way. This is a major safety concern as any kind of speed while this occurs would be catastrophic. I suspect that Jeep submitted that the recall was fixed when in fact it was not and documents were falsified.

   NHTSA complaint #11751878 · source
4. Filed Apr 13, 202687,803 miMASuspension

   The contact owns a 2006 Jeep Liberty. The contact stated that while driving at an undisclosed speed, the steering wheel was loose, with a clunking sound coming from the steering wheel. The vehicle was taken for inspection and failed the inspection. The vehicle was diagnosed by a certified mechanic, and the contact was informed that the driver's side ball joint was detaching and needed to be replaced. The vehicle was taken to another certified mechanic to be repaired. Two…

   NHTSA complaint #11730737 · source
5. Filed Mar 9, 2026168,000 miTXElectrical System

   Odometer Fraud. The contact purchased a 2006 Jeep Liberty on January 16, 2026, from a used car dealer. While attempting to obtain insurance for the vehicle, the insurance company discovered a mileage discrepancy. The insurance company informed the contact that the vehicle could not be insured due to the mileage discrepancy. The dealer was contacted however, while attempting to retrieve a Carfax report; Carfax could not provide the report. At the time of the purchase, the…

   NHTSA complaint #11722911 · source
6. Filed Feb 7, 2026KYSuspension

   The front lower ball joints have repeatedly failed under recall. The dealer says I now have to pay to have it repaired properly, under recall

   NHTSA complaint #11716426 · source
7. Filed Jan 27, 2026IASteeringSuspensionTransmission & Drivetrain

   Vehicle: 2006 Jeep Liberty VIN: [XXX] Summary: The front lower ball joint on my 2006 Jeep Liberty failed while the vehicle was in normal use. This failure matches the defect described in NHTSA Recall 06V288000 (Chrysler F23), which involves corrosion and separation of the front lower ball joints. My VIN does not currently show this recall as open, but the failure occurred exactly as described in the recall documentation. Details: In November 2025, the front end of the…

   NHTSA complaint #11713720 · source
8. Filed Nov 12, 2025180,000 miIATowedBody & StructureFuel, Hybrid & EV PropulsionSuspension

   The contact owns a 2006 Jeep Liberty. The contact stated that while driving approximately 20-25 MPH, the front control arm fractured. The front wheel seized, and the vehicle drove into a driveway. There were no warning lights illuminated. The vehicle was towed to the residence. The local dealer was contacted and suggested an appointment, and that the rear control arm was not covered under warranty. The contact was informed about NHTSA Campaign Number: 13V252000 (Fuel System,…

   NHTSA complaint #11699001 · source

Compare the 2006 Jeep Liberty with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 11, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology