2009 Jeep Wrangler problems, complaints & recalls

2009 Jeep Wrangler recalls (6)

• Recall 18V021000Jan 9, 2018328,177 vehiclesDo not drive
  AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

  Chrysler (FCA US LLC) is recalling certain 2009-2013 Jeep Wrangler, Chrysler 300, Dodge Challenger and Dodge Charger vehicles, and 2009-2011 Dodge Dakota vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Chrysler is recalling certain 2009-2010 RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Chrysler is also recalling certain 2009 RAM 3500, RAM 2500, RAM 4500 Cab Chassis, RAM 5500 Cab Chassis, Dodge Durango, Chrysler Aspen, RAM 3500 Cab Chassis, Jeep Wrangler, Chrysler 300, Dodge Dakota, Dodge Challenger, and Dodge Charger vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflator may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

  Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

  Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 28, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U03.

• Recall 16V352000May 24, 20164,648,270 vehiclesDo not drive
  AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

  Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.

  Risk: These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

  Remedy: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.

• Recall 16V290000May 11, 2016388,532 vehicles
  AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

  Chrysler (FCA US LLC) is recalling certain model year 2007-2010 Jeep Wrangler JK vehicles manufactured March 2, 2006, to August 13, 2010. The clockspring assembly may become contaminated with dust and cause the air bag circuit to fail.

  Risk: Failure of the air bag circuit may prevent the driver's frontal air bag from deploying in the event of a crash, increasing the risk of injury.

  Remedy: Chrysler will notify owners, and dealers will replace the clockspring, wheel back cover, and column shroud, free of charge. The recall began on December 14, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S33.

• Recall 13V176000May 7, 20135,440 vehicles
  AIR BAGS

  Chrysler Group LLC (Chrysler) is recalling certain model year 2008-2012 Jeep Wrangler right-hand drive vehicles manufactured February 1, 2007, through October 10, 2011. The affected vehicles have airbag clockspring assemblies that could experience broken airbag circuits.

  Risk: In the event of a crash necessitating airbag deployment, a broken electrical circuit in the airbag clockspring wiring assembly can lead to non-deployment of the driver-side frontal airbag and will not be able to properly protect the driver, increasing the risk of injuries.

  Remedy: Chrysler will notify owners, and dealers will replace the clockspring and add a steering wheel dust shield, free of charge. The recall began on June 10, 2013. Owners may contact Chrysler at 1-800-247-9753. This recall supercedes NHTSA recall 11V-528. Chrysler's recall campaign number is M31.

• Recall 11V528000Nov 2, 20115,437 vehicles
  AIR BAGS:FRONTAL

  Chrysler is recalling certain model year 2008-2012 right hand drive (rhd) jeep wrangler vehicles manufactured from february 1, 2007, through october 10, 2011. Some vehicles may be equipped with driver's airbag clockspring assemblies that could experience a compromised airbag circuit resulting in an airbag lamp illumination, which indicates that the airbag may not deploy.

  Risk: A broken electrical circuit in the airbag clockspring wiring assembly can lead to non-deployment of the driver frontal airbag and will not be able to properly protect the driver in the event of a crash, increasing the risk of injuries.

  Remedy: Chrysler will notify owners and remedy the vehicles as necessary free of charge. Chrysler will mail to owners an interim notification during march 2012. Owners may contact chrysler at 1-800-853-1403.

• Recall 10V236000Jun 3, 2010287,653 vehicles
  SERVICE BRAKES, HYDRAULIC

  Chrysler is recalling certain model year 2007 through 2010 jeep wrangler left and right hand drive passenger vehicles manufactured from may 15, 2006 through april 22, 2010. There may be contact between the right and left front inner fender liners and the right front and left rear brake tubes which could cause wear of the tubes causing a brake fluid leak.

  Risk: A brake fluid leak can cause partial loss of service brakes at the affected wheel increasing the risk of a crash.

  Remedy: Chrysler will notify owners and dealers will repair the vehicles free of charge. Owners may contact chrysler toll-free at 1-800-853-1403.

NHTSA defect investigations

• EA21002Opened Sep 17, 2021Open

  Desiccated Air Bag Inflator Rupture

  From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.C…

• EA15007Opened Dec 4, 2015Closed Jul 6, 2016led to recall 16V288000

  Air Bag Clockspring Wiring Failure

  On May 10, 2016, Fiat Chrysler America (FCA) submitted a Part 573 Defect Information Report announcing NHTSA recall 16V290 involving 394,258 model year (MY) 2007-2010 Jeep Wrangler vehicles.Under the recall FCA will replace the clockspring and install a steering wheel back cover and steering wheel column shroud.This recall also includes approx. 4,524 MY2007-2010 right hand drive (RHD) Jeep Wrangler vehicles commonly used for rural postal delivery services.In addition 7,180 MY 2011-2016 right hand drive Jeep Wrangler vehicles were also recalled under 16V288, the same remedy repair will be used.…

• PE15025Opened Jun 19, 2015Closed Dec 7, 2015

  Air Bag Clockspring Wiring Failure

  In it's response to ODI's PE15-025 Information Request letter, FCA identified 1,703 consumer complaints, field reports and legal claims responsive to the subject defect condition on the subject Wrangler vehicles.Six of these reports alleged an air bag non-deployment in a crash in which either the air bag warning light was allegedly on or came on afterward the crash, one of which also alleged injuries as a result of the non-deployment.FCA also provided data on other make, model and model year vehicles using the same clockspring.Additionally FCA provided 16,955 warranty claims related to the rep…

• DP14004Opened Sep 25, 2014Closed Jul 24, 2015

  Totally Integrated Power Module Failure

  In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to…

Recent 2009 Jeep Wrangler complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Sep 17, 2026NVCrash1 injuredTowedAirbags

   oN 5-22-26 I was involved in a MVA. I was in a head on collision. My airbags did not deploy. I suffered a brain bleed and now have an aneurysm thought to have been caused by the trauma. My head hit the windshield. The vehicle is in my warehouse and has not been tampered with since the accident. I feel that the airbag should have deployed and in the very least the seatbelt should have kept me from hitting the windshield.

   NHTSA complaint #11764877 · source
2. Filed Aug 17, 2026NJBrakes

   The ABS control module (part 68032358AC, ATE 25.0212-1155.4) on my 2009 Jeep Wrangler Unlimited failed at approximately 109,600 miles with stored diagnostic code C2200 (Anti-lock Brake Module Internal). The ABS, BRAKE, ESP/BAS, and traction control warning lights illuminate intermittently and the fault is permanently stored. When active, the vehicle loses anti-lock braking, electronic stability control, and traction control; base hydraulic braking remains. This internal…

   NHTSA complaint #11757521 · source
3. Filed Apr 17, 2026NYAirbagsBrakes

   The contact owns a 2009 Jeep Wrangler. The contact received notifications of NHTSA Campaign Numbers: 10V236000 (Service Brakes, Hydraulic), 16V290000 (Air Bags), and 18V021000 (Air Bags); however, the parts required to complete the recall repairs were not available. The contact stated that the dealer had been contacted several times. The vehicle was not diagnosed or repaired. The dealer confirmed that parts were not yet available and were on back order. The dealer informed…

   NHTSA complaint #11731832 · source
4. Filed Apr 2, 2026NYAirbags

   The contact owns a 2009 Jeep Wrangler. The contact received notifications of NHTSA Campaign Numbers: 18V021000 (Air Bags) and 16V290000 (Air Bags); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The dealer was contacted and confirmed that the parts were not yet available. The dealer had been waiting for parts for over a month and a half for parts to repair…

   NHTSA complaint #11728825 · source
5. Filed Jan 21, 2026MICrash1 injuredTowedAirbags

   I was driving approximately 55mph 10/22/2024 on a two-lane roadway in my 2009 Jeep Wrangler X (VIN: [XXX] ) when another vehicle pulled out in front of me. I struck that vehicle in a frontal collision. The force of the impact caused my Jeep to ride up and over the vehicle, enter the opposite lane of travel, and roll over a second vehicle before continuing to roll down the road. Despite the high-speed frontal impact and subsequent rollover, none of the airbags in my vehicle…

   NHTSA complaint #11712530 · source
6. Filed Jun 27, 2025TXElectrical SystemLightingVisibility & Wipers

   Turned on ignition and wipers and headlights turned on with no control, car ignition beeped constantly, all dash lights illuminated, all gauges stopped working (speedometer, fuel, tachometer, temperature) and there was a clicking noise on the transmission. Had to drive home hoping my electrical system wouldn’t shut down while driving home. Narrowed down to faulty TIPM.

   NHTSA complaint #11669688 · source
7. Filed Jun 23, 2025NCBrakes

   My wrangler's brakes locked up repeatedly and I took it to the dealer. They said that it needs a new ABS module but that part is not made anymore. This is a safety issue and I now have a car that I can't sell, can't fix, and can't drive. My wife almost got into an accident.

   NHTSA complaint #11668711 · source
8. Filed Dec 28, 2024NYFuel, Hybrid & EV Propulsion

   When filling my tank, it spits gas back out of the nozzle. I’ve been told in several forums that this is a warranty issue and is to be replaced by a dealership for free. The item that needs to be repaired is a fuel filler tube. I don’t wanna spend the money on buying the part myself if this is something that is covered by the dealership through the factory. This happens every time I fill the tank and has been an ongoing problem for over a year almost 2 years. I have to fill…

   NHTSA complaint #11632876 · source

Compare the 2009 Jeep Wrangler with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 11, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology