2016 Kia Optima body & structure problems

Related recalls

• Recall 23V594000Aug 24, 2023319,436 vehicles
  LATCHES/LOCKS/LINKAGES:TRUNK LID:LATCH

  Kia America, Inc. (Kia) is recalling certain 2016-2017 Rio, 2016-2018 Optima, 2017-2018 Optima Hybrid and Optima Plug-in Hybrid vehicles. The trunk latch base may crack, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 401, "Internal Trunk Release."

  Risk: A person inside the trunk compartment may become trapped, increasing their risk of injury.

  Remedy: Dealers will replace the trunk latch base subassembly, free of charge. Owner notification letters were mailed October 19, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC278.

What owners say

1. Filed Apr 22, 2026CABody & Structure

   I am submitting a defect complaint regarding the paint on my vehicle, which has been progressively deteriorating. The issue begins as small bubbles in the paint, which eventually lead to peeling and complete paint loss in affected areas. This condition is currently present on the trunk, roof, and rear sides of the vehicle, and early signs are now appearing on the hood. This defect is more than cosmetic. As the paint peels, it exposes the underlying metal panels to…

   NHTSA complaint #11733116 · source
2. Filed Aug 21, 2025FLAirbagsBody & Structure

   Dashboard shows a crack right where the passenger airbag is and Kia Motors wont change it, also the paint is flaking and noticed other Kia models with that same paint scheme that’s peeling off.

   NHTSA complaint #11682167 · source
3. Filed Jun 10, 2025CABody & Structure

   My paint has begun bubbling up and feeling out of nowhere. I’ve always taken good care of my car yet spots are beginning to pop up along the passanger side. The paint continues to peel more as time goes on. I’ve found many complaints online of people saying they’ve had the same issue with their kia in the Snow White Pearl color I have, but there’s no recall and kia refuses to pay for it.

   NHTSA complaint #11665961 · source
4. Filed Dec 27, 2024PABody & Structure

   While driving on the highway, the roof antenna assembly flew off our car. Inspection of the area shows that the screws that were supposed to hold the antenna on had all become sheared off. It looks like there is a recall for this exact issue covering 2016 Kia Optimas produced through June 1, 2016 (SA272), but our Optima was produced on June 23, 2016 and is therefore not covered according to Kia.

   NHTSA complaint #11632732 · source
5. Filed Sep 30, 2024CABody & StructureOther / Unknown

   All the window regulators continue to turn but the windows stay down and won't go up. Leading cause, the gear that connects to the motor and window regulator wires is plastic and erdes over time causing it to shred itself. Now my windows will not go up.

   NHTSA complaint #11617321 · source
6. Filed Aug 29, 2024NCBody & StructureOther / Unknown

   I apologize if this is not filed in the correct place. Issue: 2016 Kia Optima, peeling paint on the hood and quarter-panel. New areas are popping up and old areas are getting worse. Color Paint: Snow White Pearl

   NHTSA complaint #11611711 · source
7. Filed Aug 21, 202485,000 miMSBody & StructureElectrical SystemVisibility & Wipers

   The contact owns a 2016 Kia Optima. The contact stated that the front driver’s and passenger’s side windows and the rear driver’s side and passenger’s side windows were inoperable and would not open or close. The vehicle was taken to the local dealer who diagnosed the vehicle and determined that the window regulators for each window had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was not contacted regarding the failure. The contact…

   NHTSA complaint #11609924 · source
8. Filed May 9, 2024NCFireBody & StructureEngineFuel, Hybrid & EV Propulsion

   I was told that my engine had a recall on it so I had an upcoming appointment with Kia in like 2 weeks for them to check my engine but the car didn’t make it. I was driving my car on interstate 20 my car had began to have a bad chemical smell and started smoking so I pulled over on the interstate and my car was in flames. Me and my daughter was in the car we could have lost our lives thank God we were able to make it out just in time. The fire department came and made a…

   NHTSA complaint #11587870 · source
9. Filed Jan 1, 2024FLBody & Structure

   I bought this car with just under 48k miles September 2023, it had a very small chip on the bumper that I assumed was from a rock. After driving this car for a while, I noticed that chip got bigger and eventually other parts of my bumper and hood started bubbling and chipping as well.90% of my bumper is now lacking paint and it’s starting to chip on my hood more. I’ve only driven it an additional 12k miles since I’ve bought it. Auto body shops are saying it’s delaminating…

   NHTSA complaint #11562899 · source
10. Filed Nov 16, 2023LABody & StructureVisibility & Wipers

    2 of my windows drop when i go over a speed bump....i have already gotten the motors replaced for the windows (front driver, and back driver sides)....i don't even use the POWER up/down FOR the back windows AT ALL because i am the only one that drives my car (wondering why this is happening for this)....when i took my vehicle for these windows to be replaced, even my mechanic says there should be a recall on these windows and that this should not be happening....NOW my back…

    NHTSA complaint #11555457 · source
11. Filed Nov 16, 202314,000 miFLBody & Structure

    The contact owns a 2016 Kia Optima. The contact stated that while driving in a heavy rainstorm, the vehicle experienced water intrusion causing the sub frame undercarriage to become damaged and unsecured. The vehicle was not yet repaired. The local dealer was notified of the failure, but no assistance was offered. The manufacturer was not yet contacted. The failure mileage was 14,000.

    NHTSA complaint #11555410 · source
12. Filed Nov 3, 2023FLBody & StructureOther / Unknown

    My 2016 Optima has the Pearl White paint. In April 2018 I noticed that it started peeling on the hood. The dealership told me that since I was past the 36k mile warranty (I was at 39k miles then) that I would have to cover the cost out of pocket. It's sad that the vehicle was not even 2 years old and that the paint was coming off and the dealership basically told me "oh well". I am now scared to hand wash the vehicle for fear of it getting any worse. If Kia knew/knows there…

    NHTSA complaint #11553421 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology