2018 Kia RIO problems, complaints & recalls

2018 Kia RIO recalls (1)

• Recall 21V622000Aug 9, 2021253,074 vehicles
  LATCHES/LOCKS/LINKAGES:TRUNK LID:LATCH

  Kia Motors America (Kia) is recalling certain 2016-2018 Forte 4-door, Forte Koup 2-door, and 2018-2019 Rio 4-door vehicles. The trunk latch may become damaged, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 401, "Internal Trunk Release."

  Risk: A person inside the trunk compartment may become trapped, increasing their risk of injury.

  Remedy: Dealers will replace the trunk latch assembly, free of charge. Owner notification letters were mailed on February 10, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC216.

Recent 2018 Kia RIO complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Aug 5, 2026FLAirbagsElectrical SystemEngine

   The Components that have malfunctioned are the airbags, exaust system, electrical systems, sensors, gaskets, and a few other things. We had 5 failed clockspring repairs. The first (3?) under warranty, we paid for another when they said it was our fault, then that mechanic said that it needed to go back to a dealership because it was defective. I advocated for months for it to be evaluated. No one at kia helped me despite this being a repeat warranty issue. I finally found a…

   NHTSA complaint #11755104 · source
2. Filed May 23, 2026INEngine

   Vehicle has excessive oil consumption defect acknowledged in Kia TSB ENG222. Repeated catalytic converter failures indicate potential overheating risk similar to 2019 Gamma engine recall for fire hazard. Engine burning oil creates risk of critically low oil levels leading to engine failure/stalling while driving. Multiple emission system failures (oil consumption, catalytic converter) suggest unsafe vehicle condition. Vehicle failed Kia’s own oil consumption tests in…

   NHTSA complaint #11739727 · source
3. Filed Mar 26, 2026AZAirbagsElectrical System

   Took my car in as the airbag light on the dashboard kept turning on and off— with or without a passenger in the seat. The dealership ran a diagnostic inspection and turns out that the passenger side OCS Mat and ECU are faulty and need to be replaced (DTC codes B176700 and B17672F). I have not been in a crash and there are no obvious signs of damage to the seat that might have caused this. There’s no active recall for this but it does seem that one other person has reported…

   NHTSA complaint #11727369 · source
4. Filed Mar 26, 2026FLAirbagsElectrical SystemEngine

   The first problem part is the airbag. The clockspring was fixed twice under warranty. Then the dealership said they wont keep doing it and blamed me wrongly. I had a private mechanic repair the same part twice due to the code it was giving but it turns out thats not what's wrong with it. The entire airbag and electrical components are bad, that is why the two repairs the dealership as well as the private mechanic made did not work. We also have some engine problems they wont…

   NHTSA complaint #11727159 · source
5. Filed Jan 27, 2026AZAirbagsSeats & Seat Belts

   My car is a 2018 Kia Rio that has a clean history and has never been in an accident. Recently my airbag light came on and I had a diagnostic run that showed a B1448 code indicating an OCS mat defect in the passenger seat. The 2015-2018 Kia Sedona models also had the same problem and were issued safety recalls. Due to this previous history I believe there could be a safety recall needed for the Kia Rio models as well.

   NHTSA complaint #11713726 · source
6. Filed Nov 22, 2025MDEngine

   My 2018 Kia Rio is burning 2 quarts of oil every 800 miles, confirmed by a Kia dealership through an official oil consumption test. The issue first started around 110,000 miles and has progressively gotten worse. I have owned the vehicle since it had 40,000 miles, and I have always had the oil changed on time and maintained the car properly. Despite proper maintenance, the engine gives off a strong burning-oil odor, and smoke enters the cabin while driving. This happens…

   NHTSA complaint #11700932 · source
7. Filed Oct 12, 2025ALEngine

   2018 Kia Rio – severe oil consumption leading to low compression (30 PSI on Cylinder 2) and engine failure. Dealership installed incorrect non-OEM spark plugs prior to failure. Kia denies warranty coverage although this matches known engine defects in other Kia models

   NHTSA complaint #11692892 · source
8. Filed Oct 6, 2025CAEngine

   My 2018 Kia Rio S (VIN [XXX] ) suffered sudden engine failure at approximately 84 000 miles. I pulled over immediately when the oil light came on, but the engine began rattling and was later diagnosed by the dealer as a bearing/seizure failure requiring full engine replacement (estimate ≈ $15 865). This vehicle uses the 1.6 L Gamma II GDI engine, which is the same engine family already included in Kia’s “Engine Litigation II” settlement and KSDS (Knock Sensor Detection…

   NHTSA complaint #11691729 · source

Compare the 2018 Kia RIO with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 10, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology