2016 Kia Sorento engine problems

Related recalls

• Recall 18V907000Dec 19, 201871,653 vehicles
  ENGINE · FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

  Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.

  Risk: A fuel leak in the presence of an ignition source can increase the risk of a fire.

  Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.

What owners say

1. Filed Sep 28, 2026NCEngine

   Vehicle equipped with 3.3L V6 Lambda II engine, covered under active Kia Warranty Extension Campaigns WTY035/WTY039 for engine block head bolt/gasket failure.In July, the vehicle experienced a cooling system issue and was brought to authorized dealer Westgate Kia. Despite explicit campaign guidelines mandating a coolant pressure test and chemical combustion block test for cooling complaints on this engine, the dealership failed to follow the TSB protocol. They attributed the…

   NHTSA complaint #11767550 · source
2. Filed Sep 20, 2026NYEngineTransmission & Drivetrain

   Upon a catastrophic engine failure Tasca Kia replaced engine under Theta II settlement. I picked up my kia on 9/12. Engine is not running properly. It’s jerking and there is loud mechanical knocking. I don’t feel safe driving. I’ve contacted Kia corporate beginning 9/16 who contacted Tasca to arrange for tow and loaner. They said Tasca service mgr would contact soon to set up. They never did. I called corporate again later that day and after they called Tasca they were told…

   NHTSA complaint #11765637 · source
3. Filed Sep 8, 2026TXEngine

   I am filing this complaint regarding a 2016 Kia Sorento, VIN [XXX]. The vehicle suddenly broke down while my [XXX] daughter was driving in [XXX] and was taken to Sooner Kia in [XXX]. The dealership diagnosed the engine as seized and stated that it failed because there was no oil, requiring engine replacement. We dispute that conclusion. Within approximately five minutes of the breakdown, my daughter checked the oil at her father’s direction, and the level appeared normal. A…

   NHTSA complaint #11762746 · source
4. Filed Aug 31, 2026VAEngine

   On or about XXX, my KIA Sorento LX FWD Auto 2.4-liter engine with an approximate mileage of 36,000, began having drivability problems, none of which occurred before that date. On XXX the vehicle was serviced at Ourisman Chantilly Kia (VA051) for a Voluntary Emissions Service Campaign (SC340) THETA II 2.4L GDI ECM S/W Upgrade. Records reflect that it was a Theta II Emissions Logic Improvement 250A21R1 0.3 M/H. This was a voluntary campaign from Kia America, Inc., [XXX].…

   NHTSA complaint #11761133 · source
5. Filed Aug 24, 2026GAEngineOther / Unknown

   I went in a few months ago for a routine oil change. My car has had zero operating issues since I had the engine replaced around 5 years ago. They told me that I need to have a voluntary emissions update performed, so I gave consent. (The letter I received a few days later referred to it as "Voluntary Emissions Service Campaign.")On the way home, it seemed to drive rougher. I figured it was relearning some of the basic operating values. The following morning, it idled rough…

   NHTSA complaint #11759097 · source
6. Filed Jul 26, 2026TXEngine

   While I was driving, my 3.3 V6 engine on my 2016 Kia Sorento seized up with no warning. There is no visible oil on the dip stick, although I have changed my oil routinely. There has never been visible oil outside of the engine or on the ground. I never had any warning light come on. I believe the engine burns an extreme amount of oil, which is putting people in a dangerous situation and financial hardship.

   NHTSA complaint #11752935 · source
7. Filed Jul 23, 2026WAEngine

   On Saturday the 18th of July, the car was fine, on Sunday 07/19/2026 got ready to take car to regular scheduled oil change and it was making a blown engine noise, the rod had failed, Safety issues where the people at oil change could have had a rod thrown out the bottom of the engine, or my car could have failed in the middle of the road causing an accident. No warning signs, no limp mode, no engine light, no noted metal in oil on previous oil changes. Inspected at Kia, does…

   NHTSA complaint #11752340 · source
8. Filed Jul 19, 2026TXEngineTransmission & Drivetrain

   I recently took my 2016 Kia Sorento L to the Kia dealership for the Emissions update recall. The next day when I started it up and put it in drive, it started jerking hard when I was trying to speed up (going from first to second gear). I had to stop and then slowly push the gas so it wouldn't jerk so hard, then it finally switched gears and was smooth. Ever since it's happening only at the first cold start up of the day, and have sluggish acceleration throughtout the day.…

   NHTSA complaint #11751409 · source
9. Filed Jul 12, 2026MIEngineFuel, Hybrid & EV PropulsionTransmission & Drivetrain

   I took my 2016 Kia Sorento to the dealership for an emissions service update as a result of a service bulliten (SC340) After recieving the car back, the transmission acts unpredictably and the throttle is erratic. This happens when started cold and continues until the engine reaches temperature. It did not do this previous to the update. It is a safetey hazard and almost caused a collision. The throttle response was sluggish, it hunted for gears and as a result I was unable…

   NHTSA complaint #11749807 · source
10. Filed Jul 7, 2026RIElectrical SystemEngineFuel, Hybrid & EV Propulsion

    (Transmission and motor) I had taken my car to the dealership on XXX for recalls and all the signal were fine before going there. They took my car back to do the recalls and my son and I waited . Once they were done we left closer to closing time is noticed there was a burn mark on my dash board that wasn’t there before the recalls. Going forward on the way home. We were waved down by a man stating that my signal and brake light weren’t working . So that next day we took my…

    NHTSA complaint #11748819 · source
11. Filed Jul 1, 2026NCEngineFuel, Hybrid & EV PropulsionOther / Unknown

    Hello. I just started smelling gas fumes when my car has been running. I see no drips , etc. It happens everytime I drive it to the point where someone pointed it out to me. I had a new engine put in by KIA for my old engine "going to sleep" about 4 years ago. I have been told that this is a on going problem with the Model I have. I want to know what I should do at this point. Im [XXX] and [XXX] so I dont have the money to take it all over the place if this engine issue is…

    NHTSA complaint #11747800 · source
12. Filed Jun 24, 2026OHEngine

    Took 2016 kia sorento april 22nd to kia services eastgate batavia oh 45103 to have all recalls fixed, few weeks later engine blew, kia services replaced engine then had to replace my battery because they had to for a month and my good battery was now a total loss, replaced my battery then my car started jerking and won't start unless in neutral, now they say my inhibitor switch needs replaced when I NEVER had any issues in the past with shifting and they wont fix it because…

    NHTSA complaint #11746307 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology