2017 Kia Sorento engine problems

Related recalls

• Recall 18V907000Dec 19, 201871,653 vehicles
  ENGINE · FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

  Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.

  Risk: A fuel leak in the presence of an ignition source can increase the risk of a fire.

  Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.

• Recall 17V586000Sep 21, 201762 vehicles
  ENGINE AND ENGINE COOLING:ENGINE

  Kia Motors America (Kia) is recalling certain 2017 Sorento vehicles equipped with 3.3L engines. The engine crankshaft may have been improperly heat treated and may fail.

  Risk: If the crankshaft fails, the engine will stall, increasing the risk of a crash. A failed crankshaft also increases the risk of a fire.

  Remedy: Kia will notify owners, and dealers will inspect the crankshaft, and, as necessary, replace the engine sub assembly, free of charge. The recall began November 6, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC153.

What owners say

1. Filed Oct 6, 2026131,000 miTXElectrical SystemEngine

   The contact owns a 2017 Kia Sorento. The contact stated that while the vehicle was stopped and idling, the engine oil warning light illuminated, and the Apple CarPlay, radio, and HVAC system became inoperable. The vehicle was taken to the dealer, and the oil pressure switch was replaced under warranty. The dealer determined that the electrical system had failed due to the oil pressure switch leaking oil onto the wiring harness, and that the wiring harness needed to be…

   NHTSA complaint #11769341 · source
2. Filed Sep 24, 2026TXEngine

   Yesterday our car was making a knocking noise. It lost power temporarily. Upon pressing the gas pedal to the floor we were able to get up to 30 mph. We made it to a repair shop. They looked at it today. The Dip stick showed no oil. The did an oil change and it was down 3 quarts of oil. We just had the oil changed 3 months ago on June 20. No check engine light came on. No warning at all . We were driving on a road with no shoulder, so this was dangerous if the engine were to…

   NHTSA complaint #11766758 · source
3. Filed Sep 16, 2026149,000 miINTowedElectrical SystemEngine

   The contact owns a 2017 Kia Sorento. The contact stated that the vehicle had started independently. While the vehicle was in the driveway, the contact became aware that the vehicle had been running for a while. While driving at 45 MPH, the vehicle shut off but restarted independently. While driving 35 MPH, the vehicle stalled. The failure had occurred on several occasions. The vehicle was towed by AAA to the local dealer, where it was determined that the ignition switch was…

   NHTSA complaint #11764746 · source
4. Filed Sep 5, 2026TXEngine

   In early July, my vehicle's check engine light turned on. I took it to a reputable local mechanic in Sachse, Texas, who had the vehicle for approximately two weeks. He was unable to determine the cause of the issue but informed me that there was an existing recall and that the dealership should be able to address the problem at no cost to me. I then took the vehicle to the Kia dealership. The dealership informed me that there was an extended warranty for the engine and that…

   NHTSA complaint #11762293 · source
5. Filed Sep 1, 2026100,000 miFLTowedEngine

   The contact owns a 2017 Kia Sorento. The contact stated that the vehicle experienced excessive oil consumption. The vehicle was inspected several times; however, no oil leaks were found. The contact stated that while driving 30 MPH, the vehicle shuddered, and the check engine warning light illuminated and flashed on the instrument panel. The vehicle was taken to an independent mechanic, where it was determined that there was a hole in a valve and a piston was fractured. The…

   NHTSA complaint #11761315 · source
6. Filed Aug 22, 2026TXEngine

   My kids and I were driving when my engine started making a loud noise. I pulled over and turned it off for a few minutes then I turned it back on. It worked for another mile or so then started making the noise again and died while I was driving at about 55-60 miles an hr. I was able to pull over, put it in park and turned the key off....it wouldn't turn back on and the check engine light came on. When I had someone check it out for me it was about 4 quarts low on oil (it…

   NHTSA complaint #11758822 · source
7. Filed Jul 31, 2026INEngineTransmission & Drivetrain

   2017 Kia Sorento 2.4L GDI engine seized due to connecting rod bearing failure confirmed by P1326 diagnostic code multiple times. Vehicle entered limp mode limiting RPMs to 1800-2000 exactly as described in PI1802 campaign. Engine subsequently fully seized. Battery tested 98% healthy ruling out electrical cause. Vehicle towed to [XXX] Kia Avon Indiana. Kia Techline and Consumer Affairs denied PI1802 lifetime warranty claim citing used vehicle reconditioning despite PI1802…

   NHTSA complaint #11754083 · source
8. Filed Jul 29, 2026FLEngine

   My 2017 Kia Sorento experienced a catastrophic, sudden engine lockup on the roadway due to a known manufacturing defect involving rod bearing failure. This defect caused complete loss of motive power and stalled the vehicle on the road, creating an extreme safety hazard for myself, my passengers, and surrounding motorists.Prior to the failure, the vehicle heavily consumed its own motor oil at a dangerous rate of nearly 5 quarts every 1,000 miles. I repeatedly attempted to…

   NHTSA complaint #11753403 · source
9. Filed Jul 6, 2026NYBrakesEngine

   On XXX, the oil warning light was illuminated in our 2017 Kia Sorento SXL and that the vehicle was leaking oil. We brought the vehicle to an independent repair facility (Tire Kingdom, Cairo, NY) for diagnosis on XXX. The repair facility provided an oral assessment with photographs indicating a suspected rear main seal leak. The engine was dry on the top but excessively wet between the engine and transmission, consistent with a significant oil leak in that area. We were…

   NHTSA complaint #11748442 · source
10. Filed Jul 6, 2026NYEngine

    On February 16, 2023, the engine in our 2017 Kia Sorento SXL developed a sudden, loud knocking noise while driving. No dashboard warning lights illuminated at any time, including no oil pressure warning, check engine light, or other engine-related alerts. The vehicle remained fully operable and did not lose power or seize. I continued driving approximately 20 minutes home, including highway speeds up to ~75 mph. The following day, with the knocking noise worsening but still…

    NHTSA complaint #11748438 · source
11. Filed Jun 25, 2026MDEngine

    bought car from carmax. engine knock sensor went bad and engine is knocking. kia states engine is not origional and was taken from a junk yard, both kia and carmax are refusing to fix eventhough I am doing payments and it is a known kia issue for this car. Kia charged me 350$ to run test and cleared the light but informed me my engine is going to blow. carmax is refusing to do anything but still wants us to pay the 9k we owe on the car eventhough its broke.

    NHTSA complaint #11746572 · source
12. Filed Jun 11, 2026MDEngine

    While driving on the highway on Mother’s Day weekend with my wife and daughter, the vehicle suddenly lost acceleration and engine power while traveling on a 5-lane beltway. The vehicle would not accelerate and I was unable to maintain normal highway speed. I had to coast to the side of the road with the hazard lights activated because of the safety risk. The vehicle was eventually restarted after being towed to a dealership, but it continued to have severe loss of power and…

    NHTSA complaint #11743629 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology