2021 Kia Telluride body & structure problems

Related recalls

• Recall 22V626000Aug 15, 202236,417 vehiclesPark outside
  TRAILER HITCHES

  Kia America, Inc. (Kia) is recalling certain 2020-2022 Telluride vehicles potentially equipped with a Genuine Kia 4-pin tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

  Risk: A fire while parked or driving can increase the risk of injury.

  Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a new fuse and a wiring harness extension. Dealers will also inspect and replace the tow hitch harness assembly, as necessary. All repairs will be performed free of charge. Owner notification letters were mailed April 12, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC247.

What owners say

1. Filed Sep 4, 2026MABody & StructureDriver Assistance & Safety TechOther / Unknown

   After having a recall, performed on the emergency parking brake it would engage while parked, but when trying to put it in drive or reverse, it would not disengage this began happening approximately two weeks to one month after the recall was performed. It isn’t happening constantly, but it does happen often. On occasion, while driving, it will engage and pull the car to the side nearly pulling me off the road. After looking for other instances of this online, I came across…

   NHTSA complaint #11762168 · source
2. Filed Aug 26, 2026MDBody & Structure

   Vehicle sunroof came off track on July 22, 2025. Possibly by the fault of the customer. Customer sought repair. Authorized Kia dealer recommended complete replacement of sunroof. On August 29, 2025, Customer paid authorized Kia dealer to replace sunroof with official Kia parts. On June 25, 2026, sunroof broke again through no fault of the customer. Wind deflector arms broke, got stuck open, and caused the glass to go off-track, rendering the sunroof inoperable and completely…

   NHTSA complaint #11759860 · source
3. Filed Jul 29, 2026NCBody & StructureOther / Unknown

   My 2021 Kia Telluride (60,500 miles) experienced failure of the panoramic sunroof wind deflector arm/mechanism. The broken component is available for inspection. The failure prevents the sunroof system from operating properly and may result in improper sealing, water intrusion, or further mechanical damage. The issue was confirmed by a Kia dealership. Kia has issued Technical Service Bulletin BOD 319 addressing Telluride sunroof wind deflector arm and mechanism failures.…

   NHTSA complaint #11753524 · source
4. Filed Jun 8, 2026TXBody & Structure

   Sunroof won't fully close which becomes a big issue when driving or parking the vehicle in the rain. Kia dealership diagnosed that the full sunroof assembly needs to be replaced at a total expense of $6,441.56 since the vehicle is out of the 5-year warranty period. No warning messages were displayed on the vehicle prior to this issue.

   NHTSA complaint #11742831 · source
5. Filed May 12, 2026TXBody & Structure

   I have used the sunroof on my 2021 Kia Telluride probably less than ten times in the 5 years I've owned it. I started getting a leak in front of my rearview mirror so I searched for the drains by opening the sunroof and fond them. Cleaned them out as best I could. closed the sunroof but was still having a leak. The next time I opened it to look at it, it jammed and wouldn't open completely or close. With a little help, i was able to get it back on track and close but still…

   NHTSA complaint #11737292 · source
6. Filed Apr 9, 2026PRBody & StructureTransmission & Drivetrain

   Hello, I've contacted customer service for Kia America and also, customer service in Puerto Rico since I'm a resident in Puerto Rico, so that I can address the safety recall with number SC303 and also a technical service bulletin with number BOD319. However, customer service advised that they can't pull up my SUV vehicle information with the VIN provided. I'm unable to address the safety recall and the technical service bulletin since Kia can't pull up the vehicle…

   NHTSA complaint #11730234 · source
7. Filed Mar 22, 2026TNBody & Structure

   Sunroof mechanism failure in May 2025. Had sunroof repaired and paid out of pocket at KIA dealership. The sunroof was off track therefore the roof was exposed to elements. March 2026 sunroof mechanism has broken again. Sunroof has not been operated since repair in May 2025 for fear of getting stuck open again.

   NHTSA complaint #11726125 · source
8. Filed Nov 20, 2025OKBody & Structure

   The door belt molding trim detached. It is available for inspection. If not caught before it completely detached it would have caused a road hazard. Models from 2023-2025 have already been recalled but not my 2021 model which has the same issue. The vehicle was inspected by the dealership I bought it from but they were unwilling to take responsibility since the recall didn't encompass my 2021 model. Kia Corp also was unwilling to take responsibility after I brought the issue…

   NHTSA complaint #11700613 · source
9. Filed Jan 16, 2025ILBody & Structure

   While driving at interstate speeds the sunroof window shattered outward. This was not the result of a rock or flying ice event as no other cars where near by at the time. I have found that many others have experienced this issue and Kia refuses to cover the repairs even though it appears to be an issue with Kia Telluride sunroofs. If the sun shade had been open at the time both me and my 12 year old son would have been covered with glass and this could have caused a high…

   NHTSA complaint #11636399 · source
10. Filed Jan 4, 2025ALBody & Structure

    In November 2024, the sunroof mechanism failed in a crooked, partially open position and would no longer move. The motor operated, but there was a grinding noise and no movement of the sunroof. I had to return from North Carolina to Alabama in the rain with a partially open sunroof. The service department at Bramlett Kia in Decatur, Alabama, confirmed the sunroof mechanism has to be replaced. The service technician said the electrical cable to the sunroof was caught in the…

    NHTSA complaint #11634123 · source
11. Filed Dec 17, 2024FLBody & Structure

    Sunroof has got jammed in open position. You have issued a statement on this now Kia will not manufacture the parts to the roof (backorder really) and wants to charge you $5000 to put a whole new roof on -

    NHTSA complaint #11631234 · source
12. Filed Nov 19, 2024FLBody & Structure

    Vehicle sunroof has become stuck in it’s tilted open position. The spoiler at the front has detached. Since the sunroof cannot close, if there is a wind, hitting the car, the sunroof can’t detach from the car at this point, and fly into another car. This issue has been reported with the numerous Kia telluride’s as seen on the Internet. It is not nearly anesthetic problem. It is a safety issue.

    NHTSA complaint #11626120 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology