2020 Kia Telluride body & structure problems

Related recalls

• Recall 22V626000Aug 15, 202236,417 vehiclesPark outside
  TRAILER HITCHES

  Kia America, Inc. (Kia) is recalling certain 2020-2022 Telluride vehicles potentially equipped with a Genuine Kia 4-pin tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

  Risk: A fire while parked or driving can increase the risk of injury.

  Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a new fuse and a wiring harness extension. Dealers will also inspect and replace the tow hitch harness assembly, as necessary. All repairs will be performed free of charge. Owner notification letters were mailed April 12, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC247.

What owners say

1. Filed Oct 7, 2026NYBody & Structure

   This afternoon i noticed that my 2020 Kia Telluride paint has and continues to peel in large chunks in my driveway. All was good this morning and then all of the sudden large pieces of paint started to break away. Near the windshield hood area.

   NHTSA complaint #11769498 · source
2. Filed Sep 23, 2026CABody & StructureEngine

   I am the original owner of a 2020 Kia Telluride that was purchased new in December 2019 and currently has approximately 98,000 miles. The vehicle has been routinely serviced, including regular maintenance performed through authorized Kia dealerships. Recently, the vehicle developed a serious apparent engine problem. An independent repair facility inspected the engine oil and found it was very low and visible metallic particles/shavings in the oil. The oil also appeared…

   NHTSA complaint #11766500 · source
3. Filed Sep 15, 2026VABody & Structure

   In March of 2025 I noticed that my Kia Telluride had a quarter size piece of paint missing in the middle of the roof near my windshield. As the past year has progressed paint delamination has occurred across the roof of my vehicle with other delamination spots being noticed in other areas of the body. My vehicle is a 2020 with 66,000 miles and is a white pearlescent coat. The delamination is exposing the body of my vehicle to the elements, causing rust and deterioration at a…

   NHTSA complaint #11764510 · source
4. Filed Sep 10, 2026MDBody & StructureOther / Unknown

   On December 9, 2025, the factory exterior paint on my 2020 Kia Telluride (Snow White Pearl) began experiencing massive, sudden delamination, shearing completely off the roof down to the factory primer layer in a sheet larger than a hand towel. The peeling is continuing to spread due to wind exposure while driving. Furthermore, the paint failure has compromised the protective coating, causing specs of rust to actively break through the paint throughout the trunk and exterior…

   NHTSA complaint #11763418 · source
5. Filed Jul 27, 2026AZBody & Structure

   I attempted to open the moonroof on our 2020 Kia Telluride. When it opened, it was cockeyed and off track. I pushed the button to close it, and I heard a plastic piece break and the moonroof remained stuck open. I took this car to Kia of Olympia, Kia of St. Cloud and Horne Kia, all confirmed that the plastic parts that broke are related to to their issued TCB#BOD319. This is well known and frequent issue on 2020-2022 Kia Tellurides, where the plastic for the wind guard snaps…

   NHTSA complaint #11753133 · source
6. Filed Jul 6, 2026GABody & Structure

   The power sunroof and its sliding track/rail assembly failed. While operating the sunroof using its normal electric open/close function during highway driving, the sunroof glass/panel traveled to full open and the track mechanism broke at that point, preventing normal closure. The vehicle and damaged sunroof/track assembly are available for inspection upon request. The failure occurred while the vehicle was in motion on the road, creating a distraction and an unexpected open…

   NHTSA complaint #11748612 · source
7. Filed Jul 2, 202630,000 miFL1 injuredBody & Structure

   The contact owns a 2020 Kia Telluride. The contact stated that four door belt molding trim pieces had become loose and unsecured, but the front driver’s side door belt molding trim piece had become unsecured and detached from the vehicle. Additionally, the contact stated that while touching the unsecured molding, the arm became bruised and scratched. No medical treatment was required. The cause of the failures was not yet determined. The local dealer was contacted, but no…

   NHTSA complaint #11747891 · source
8. Filed Jul 1, 2026NCBody & Structure

   Sunroof issue with the air dam that lifts up when the sunroof opens breaks off and throws the the sunroof off track so your stuck with it open or it breaks the track or glass

   NHTSA complaint #11747748 · source
9. Filed Jun 23, 2026CABody & Structure

   My vehicle’s white exterior paint and clear coat are delaminating and peeling off in pieces while driving. Loose paint pieces fly off the vehicle, creating a potential road hazard for other drivers. The defect affects the hood, the front, and the area above the windshield. The vehicle is available for inspection upon request. The paint delamination has been visually confirmed and is worsening over time. I have contacted Kia customer service multiple times by phone and email…

   NHTSA complaint #11746035 · source
10. Filed Jun 20, 2026ALBody & Structure

    What component or system failed or malfunctioned, and is it available for inspection upon request? The factory paint on my 2020 white Kia Telluride has failed. The paint is peeling and flaking from the hood and the roof of the vehicle. The vehicle is available for inspection upon request, and I have photographs documenting the paint failure. How was your safety or the safety of others put at risk? The peeling paint exposes the underlying metal to the elements, which may lead…

    NHTSA complaint #11745343 · source
11. Filed Mar 16, 2026CABody & Structure

    the paint, it is flaking and rusting underneath. yes it is avail for inspection the paint flakes off in sheets while driving down the road it has been seen by the local dealership i first started noticing it when i was washing the vehicle.

    NHTSA complaint #11724744 · source
12. Filed Mar 4, 2026CABody & Structure

    Paint failure and delamination on a 2021 Kia Telluride with Snow White Pearl (SWP) paint. The paint on the roof above the windshield and the hood has begun peeling in sheets, exposing the underlying layer. The vehicle has not been in any accidents and has never been repainted. The paint failure appears to be a manufacturing defect involving the adhesion of the factory paint. The issue began around year 4–5 of ownership at approximately 60,000 miles. The affected areas…

    NHTSA complaint #11722085 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology