2014 Ram 2500 engine problems

Related recalls

• Recall 17V562000Sep 12, 2017443,874 vehicles
  ENGINE AND ENGINE COOLING:ENGINE:DIESEL

  Chrysler (FCA US LLC) is recalling certain 2013-2017 RAM 2500, 3500, 3500 Cab Chassis, 4500 Cab Chassis, and 5500 Cab Chassis vehicles, equipped with Cummins 6.7L Turbo Diesel engines that have Concentric-brand water pumps without a vent hole. These water pumps may leak coolant.

  Risk: The leaking water pump can increase the risk of an engine compartment fire.

  Remedy: Chrysler will notify owners, and dealers will replace the water pumps, free of charge. The recall began February 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T51.

• Recall 14V635000Oct 8, 2014315,325 vehicles
  ENGINE AND ENGINE COOLING:ENGINE:DIESEL · FUEL SYSTEM, DIESEL

  Chrysler Group LLC (Chrysler) is recalling certain model year 2010-2014 Ram 2500, 3500, 4500, and 5500 trucks manufactured March 27, 2009, to September 5, 2013. In the affected vehicles, the electrical connectors of the diesel fuel heater may overheat.

  Risk: If the connectors overheat, the fuel heater may leak fuel, increasing the risk of a fire.

  Remedy: Chrysler will notify owners, and dealers will replace the harness side connector with a silver plated beryllium copper terminal service kit, and inspect the fuel heater for leaks, replacing it as necessary, free of charge. Chrysler issued interim notification to owners on December 8, 2014. The recall began on April 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P65.

What owners say

1. Filed Jan 7, 2026WAEngine

   Check engine light came on end of November 2025 and stayed on. Immediately I took the truck to two different independent mechanics. They both said it was a problem with the turbocharger but I never received a recall regarding this. They both said I could still drive it and that it would not leave me stranded. The last recall done was the 67A a year ago. There are currently no recalls for my particular vehicle through the NHTSA. The truck is currently having the very…

   NHTSA complaint #11709430 · source
2. Filed Dec 13, 2024177,038 miPAEngine

   The contact owns a 2014 Ram 2500. The contact stated while driving 45 MPH, the vehicle started to jerk, slipped into neutral, with the RPM being raised abnormally. The check engine warning light was illuminated. The contact pulled over to the side of the road and continued driving the vehicle very slowly. The vehicle was taken to a local AutoZone to be diagnosed. The contact was informed that 5th and 6th gears were in incorrect gear ratio. The local dealer was not contacted.…

   NHTSA complaint #11630539 · source
3. Filed Dec 2, 2024165,000 miVAEngineFuel, Hybrid & EV Propulsion

   The contact owns a 2014 Ram 2500. The contact stated that after parking the vehicle, there was diesel fuel leaking from the vehicle. Upon inspection, the contact discovered that there was diesel fuel leaking from the fuel filter connected to the diesel fuel heater. The vehicle was not yet repaired. The local dealer and manufacturer were contacted but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 14V635000…

   NHTSA complaint #11628326 · source
4. Filed Jul 22, 2024GAEngine

   I was contacted to complete a recall on my truck, (67A), which I had performed by the local dealer. The recall notice also said "If you have already experienced this condition and previously paid for a repair, you may be eligible to receive a reimbursement." I spoke to an individual and followed the instructions to submit a claim. With no response, I tried to get a status; to confirm proper items were received electronically. I was told, they were received and the claim was…

   NHTSA complaint #11603850 · source
5. Filed Jul 7, 2024OKEngine

   I recently received a letter in the mail from FCA US LLC, about an emissions recall (Emissions Recall VB6 or 67A) on this 2014 ram. The recall covered many emissions components including the diesel exhaust fluid components. The recall letter also said that if I had replaced or repaired any of these components in the past, I may be eligible for a reimbursement. I had previously had to replace my Diesel Exhaust Fluid Pump back in 2021 and turned in the receipt for the work,…

   NHTSA complaint #11599813 · source
6. Filed Jul 2, 2024COElectrical SystemEngineTransmission & Drivetrain

   Upon starting the trucks engine, putting the transmission in gear (either Reverse or Drive), at idle engine speed (approx 700-800 rpm) or very low (near idle speed) the trucks engine starts to surge from idle then drops down to 500 rpms with a voltage drop (5V) too. It will do this a couple of times and then the trucks engine dies (engine stops) while in gear and no codes are shown on the CEL or saved in the vehicle control module. When I put the transmission in Park, the…

   NHTSA complaint #11598270 · source
7. Filed Feb 6, 2024MTEngine

   After the vehicle sits at night and then started in the morning the engine has a ticking sound. ( cold start ticking) Then when I was on the hiway the vehicles motor locked up.

   NHTSA complaint #11570276 · source
8. Filed Jul 5, 2023WABrakesEngine

   RAM has Turbocharger/actuator high failure rate. I have had 2 turbo failures in under 80,000 miles. When I lost the turbo I loose the exhaust brakes. This is very dangerous when towing and coming down a mountain road. This could lead to vehicle damage and loss of life. IN FACT: RAM on the 2015 model year only, issued a warranty extension for Turbo failures. This is serious safety concern due to NO exhaust brakes or no acceleration when needed to avoid a collision.

   NHTSA complaint #11530456 · source
9. Filed May 12, 2023UTEngine

   There is a ticking noise from the 6.4L Hemi that is in this truck. I took it into the dealer and I was told that it was normal. Recently The ticking got so loud that it sounds like the lifters or a rod that will shoot through the engine compartment and injure or kill someone.

   NHTSA complaint #11521699 · source
10. Filed Mar 27, 2023COEngine

    on the 6.7L cummins diesel engines, as part of the cold start system, there is a bolt in the intake plenum that can come loose and eventually break off getting sucked into the #6 cylinder. when this happens, there will be catastrophic failure of the engine. This boltis barely visible looking from the top driver side of engine, a sure sign of this problem is the preheater wire connected to the intake plenum will seem loose and you can wiggle it. This is not repairable from…

    NHTSA complaint #11514036 · source
11. Filed Mar 13, 2023NDEngine

    The heater in my pickup was not working correctly on the driver's side, so I took it into a shop to have the engine coolant flushed ($150). Within a few weeks, I had a check engine light appear and discovered the thermostat had failed ($350). I had this replaced. Still no heat. It was discovered that my heater core was plugged, could not be flushed, and the sediment from the coolant breaking down caused the failure in the thermostat, the heater core, and had plugged the EGR…

    NHTSA complaint #11511506 · source
12. Filed Sep 17, 2022OREngine

    While towing a moderately loaded trailer, the cooling fan on the engine turned on. It appears the fan shroud got sucked into the fan causing pieces of the shroud to get thrown into the radiator, which in turn destroyed the radiator and leaked all the coolant onto the ground. A quick google search shows this seems to be an extremely common issue with these trucks. It seems that the design of the shroud is poor and should be remedied by the manufacturer. With such a sudden…

    NHTSA complaint #11484937 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology