2008 Saturn Outlook problems, complaints & recalls

2008 Saturn Outlook recalls (3)

• Recall 15V415000Jun 30, 2015691,144 vehicles
  STRUCTURE:BODY:HATCHBACK/LIFTGATE

  General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.

  Risk: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.

  Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.

• Recall 14V118000Mar 17, 20141,176,407 vehicles
  AIR BAGS:SIDE/WINDOW

  General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.

  Risk: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.

  Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.

• Recall 10V240000Jun 4, 20101,365,070 vehicles
  ELECTRICAL SYSTEM

  Gm is recalling certain model year 2006-2009 buick, lucerne; cadillac dts; hummer h2; model year 2008-2009 buick enclave; cadillac cts; model year 2007-2009 cadillac escalade, escalade esv, escalade ext; chevrolet avalanche, silverado, suburban, tahoe; gmc acadia, sierra, yukon, yukon xl; saturn outlook; and model year 2009 chevrolet traverse vehicles equipped with a heated washer fluid system (hwfs). A recall was implemented in 2008 to add a fuse to the control circuit harness to address the potential consequences of a printed circuit board (pcb) electrical short. However, there have been new reports of thermal incidents on hwfs modules after this improvement was installed. These incidents resulted from a new failure mode attributed to the device's thermal protection feature. The significance varies from minor distortion to considerable melting of the plastic around the hwfs fluid chamber.

  Risk: It is possible for the heated washer module to ignite and a fire may occur.

  Remedy: Dealers will permanently disable and remove the heated washer fluid module. An updated page for the owner manual will be provided and inserted in the owner manual to document that the feature has been permanently disabled and removed from the vehicle. The safety recall began on june 11, 2010. Owners may contact buick at 1-866-608-8080, cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, saturn at 1-800-972-8876, gmc at 1-866-996-9463 and hummer at 1-800-732-5493 or at the owner center at www.gmownercenter.com.

NHTSA defect investigations

• DP12003Opened Jun 4, 2012Closed Jul 24, 2014

  Loss of Headlamp Illumination

  As of July 16, 2014, out of a population of 248,453 subject vehicles, NHTSA received 473 consumer complaints of inoperative head lamp. Many of these complaints indicated that the head lamp harness suffered damage from overheating. After reviewing the complaints, ODI found: -69% (328) alleged that a single head lamp was inoperative. -18% (86) alleged that both head lamps were inoperative but not at the same time. -9% (41) alleged that both head lamps were inoperative but the complaints did not indicate whether the failures had occurred at the same time. -4% (17) alleged that both head lamps wer…

• EA08010Opened Jun 12, 2008Closed Sep 8, 2008led to recall 08V441000

  Non-crash engine compartment fires

  In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. According to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. This may cause other electrical features…

Recent 2008 Saturn Outlook complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Oct 30, 2024PATransmission & Drivetrain

   Transmission is failing. Reverse is slipping. Low torque trying back up inclines. Known problem with 2008 Acadia, Enclave, Traverse & Outlook per transmission shop who test drove and scanned. No code via dashboard, but scan tools and professional diagnostics verify failure. Techem has been replaced in February 2019, by GM service @ owners expense when forward drive failed.

   NHTSA complaint #11622653 · source
2. Filed Nov 14, 2023ILAirbags

   Over this summer I went to start my truck and all the airbags pop out expect for the steering wheel air bag and dashboard air bag

   NHTSA complaint #11555105 · source
3. Filed Oct 3, 2023OHTransmission & Drivetrain

   This has been a big problem for all Saturn owners. The transmissions are always going out in them. This transmission is starting to slip. I’m surprised there is no recalls. Very disappointed.

   NHTSA complaint #11548011 · source
4. Filed Apr 26, 2022MAAirbagsElectrical System

   airbag sensor on passenger seat stays off even when passenger is in seat. I have read many complaints from same vehicle since they were new. Also has electrical issues intermittently possibly from water leaking thru sunroof

   NHTSA complaint #11462196 · source
5. Filed Feb 9, 2022197,357 miOHVisibility & Wipers

   The contact owns a 2008 Saturn Outlook. The contact stated that while driving at an undisclosed speed, the front windshield wiper failed to operate as needed. The vehicle was taken to an independent mechanic and diagnosed with windshield wiper motor failure. The contact was informed that the windshield wiper motor cover assembly needed to be replaced. The manufacturer was made aware of the failure but provided no assistance. The contact related the failure to NHTSA Campaign…

   NHTSA complaint #11451200 · source
6. Filed Aug 31, 2021180,000 miWAAirbags

   The contact owns a 2008 Saturn Outlook. The contact stated that while starting the vehicle, the airbag warning light illuminated and remained illuminated. The contact took the vehicle to a local dealer to be diagnosed. The contact was informed that the MDS was not communicating with the airbags. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 180,000.

   NHTSA complaint #11431261 · source
7. Filed Aug 26, 2021155,692 miMIWheels & Tires

   The contact owns a 2008 Saturn Outlook. The contact stated while inspecting the vehicle, the contact noticed that all 4 tires had started cracking along the tread. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 15T002000 (Tires) however, the tires were not included. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 155,692.

   NHTSA complaint #11430651 · source
8. Filed Aug 23, 2021ORElectrical SystemLighting

   My low beam headlight started to intermittently go out for a while. Then it went out completely. I go to replace the bulb only to find that the bulb wasn’t the actual issue. The harness, wires, and socket to the bulb were blackened, burnt and melted. So now it all needs to be replaced. I’ve seen on several forums that has happened to so many people that have a car manufactured by GM. The original wiring is not quality enough for the heat and current that goes through there.

   NHTSA complaint #11430215 · source

Compare the 2008 Saturn Outlook with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 10, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology