2015 Subaru Outback engine problems

Related recalls

No recalls on file.

What owners say

1. Filed Jun 26, 2026CAEngineFuel, Hybrid & EV Propulsion

   NHTSA issued a notice for a recall on the 2015 Subaru Outback for an exhaust pipe bellows crack which causes exhaust noise and odor which affects emission and engine performance. I had noticed our Subaru's exhaust smoke coming in through the air vents while idling and also a general loss of power for the vehicle. When I dug into the causes, I came across this recall and did the VIN look up on the NHTSA website and also the Subaru website for active recalls. The Subaru…

   NHTSA complaint #11746783 · source
2. Filed Jun 5, 2026244,000 miAZEngine

   The contact owns a 2015 Subaru Outback. The contact stated that while driving at an undisclosed speed, the exhaust manifold detached from the vehicle. Due to the failure, the vehicle was towed to the residence. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The dealer advised the contact that a recall repair was previously performed on the vehicle, which was related to an exhaust pipe cracking, and that additional repairs would be at the…

   NHTSA complaint #11742301 · source
3. Filed Oct 31, 2025110,000 miCAEngine

   The contact owns a 2015 Subaru Outback. The contact stated that while driving at an undisclosed speed, and while at a stop light, there was an abnormal exhaust fumes odor inside the vehicle. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed with a cracked exhaust pipe. The vehicle was not repaired. The manufacturer was contacted and confirmed that the vehicle was previously repaired under Service Program Bulletin:…

   NHTSA complaint #11696838 · source
4. Filed Sep 25, 2025135,000 miWAEngine

   The contact owns a 2015 Subaru Outback. The contact stated that while starting the vehicle, there was an abnormal exhaust odor entering the cabin of the vehicle through the vents. No warning lights were illuminated. The contact stated that the vehicle was consuming an excessive amount of fuel. Before the contact purchased the vehicle, the contact became aware that the vehicle had been repaired under recall for the catalytic converter. The vehicle was not diagnosed or…

   NHTSA complaint #11689788 · source
5. Filed Sep 22, 2025INCrashTowedBrakesEngineAcceleration & Cruise Control

   I was within the town limits so I was driving slowly. When I approached the first stop light in town I saw that it was red. There were of three or four vehicles stopped at that light. At that point I was probably only going 5mph. I took my foot off of the gas pedal and put my foot on the brake to make a slow stop. Instead, the car accelerated rather quickly. I continued to brake but the car seemed to speed up. I was able to avoid hitting the truck in front of me by going…

   NHTSA complaint #11689049 · source
6. Filed Dec 5, 2023CAEngine

   The cam carrier has a leak that is causing oil to slowly leak out of the car. The current issue is causing me to have to regularly add oil to the car. My safety is at risk as the car engine could fail while driving which would be me and others at risk. My understanding is that the leaking oil could also cause other parts to fail such as the O2 sensor. The recommended repair from the local Subaru dealer is to reseal the cam carrier at an estimated cost of $4,744. I attempted…

   NHTSA complaint #11558634 · source
7. Filed Nov 2, 2023NHEngine

   The car had a recall on it for the catalytic converter and front pipe and bellows being cracked. It was replaced under a service bulletin put out by Subaru at 104,000 miles in 2020. I just went to get the vehicle inspected in 5/2023 and the exact same part is failing once again. It will not pass inspection. This causes exhaust to leak back into the car (including carbon monoxide) given the converter/bellows are parts that come off the engine right under the…

   NHTSA complaint #11553298 · source
8. Filed Aug 17, 2023NYElectrical SystemEngine

   #1. I replaced the battery in June of 2022 after all the dash warning lights came on. My eyesight safety feature was rendered in operative. After the battery was replaced, all the warning lights eventually went out. In July of 2023 the same scenario happened again. I returned to Advance Auto retailer and the store manager checked the battery. She replaced the battery with a new one of greater cold cranking amps. she was most knowledgeable and extraordinarily gracious. I…

   NHTSA complaint #11539168 · source
9. Filed Jun 22, 202380,700 miCABrakesEngine

   The contact owns a 2015 Subaru Outback. The contact stated that while driving 67 MPH with the cruise control activated, the vehicle suddenly decelerated to approximately 25-30 MPH while depressing the brake pedal. The contact stated that the vehicle stalled. After pulling over to the side of the roadway, the contact was able to restart the vehicle and drove to the residence. The vehicle was taken to the dealer however, the cause of the failure could not be determined. The…

   NHTSA complaint #11528332 · source
10. Filed Mar 21, 2023NCElectrical SystemEngine

    Oil consumption issues. The oil is burning more then it should. Oil light would come after 2 to 3 more after an oil change. The dealership has been notified and is working on ordering new parts for the engine. Replacing the small block of the engine. Had less the 100k miles when this problem accured. Electrical issues. The battery is being drained after the car is turned off. Car would not start in the morning and need to be jumped. Additionally, battery eventually dies and…

    NHTSA complaint #11512993 · source
11. Filed Sep 10, 2022NDCrashAirbagsEngineFuel, Hybrid & EV Propulsion

    Entering a residential garage to park; experienced sudden acceleration while braking. Vehicle went through drywall/wall about 2 feet. Placed vehicle in park to stop vehicle. No airbags went off. Driving vehicle to repair shop later; experienced same rapid unexpected acceleration with different driver. No issue with floor mats. OEM mats. Service center cannot provide any insight or reproduction of event.

    NHTSA complaint #11483793 · source
12. Filed Jun 1, 2022120,000 miCAFire1 injuredTowedEngine

    The contact owned a 2015 Subaru Outback. The contact stated that while driving at 60 MPH, he was alerted by another driver that the vehicle was smoking and flames were coming from under the vehicle. The contact stated that warning lights flashed off and on. The contact stated that he pulled over, exited the vehicle, and saw flames coming from underneath the vehicle before it was engulfed in flames and exploded. The contact stated that he sustained minor burns on his hands…

    NHTSA complaint #11467050 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology