2019 Subaru Outback body & structure problems

Related recalls

• Recall 19V493000Jun 26, 20192,107 vehicles
  STRUCTURE

  Subaru of America, Inc. (Subaru) is recalling certain 2019 Legacy and Outback vehicles. Spot welds located on the duct below the cowl panel may have been improperly applied, impacting the vehicle's body strength.

  Risk: In the event of a crash, the reduced strength of the vehicle body may increase the risk of injury.

  Remedy: Subaru will notify owners, and dealers will inspect the vehicles and repair or repurchase the vehicle, as necessary, free of charge. The recall began July 26, 2019. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUH-93.

What owners say

1. Filed Jan 4, 2026LABody & Structure

   We were driving down an interstate highway going 70 mph on a foggy Christmas Eve 2025 approximately 7 a.m. No cars were close around us. We had been on the road for 30 minutes or so, and it was in the 50-60 degree temperature range. Suddenly we heard what sounded like a gunshot right above our heads. We opened the sunshade under the sunroof, and saw that our sunroof had exploded and left a hole. Before this, we heard nothing strike the sunroof or the car. It seemed like a…

   NHTSA complaint #11708662 · source
2. Filed Feb 20, 2025NCBody & StructureElectrical SystemLighting

   Parasitic battery drain when vehicle is turned off. The DCM module in these vehicles will not shut off properly and continue to drain the battery. Subaru has firmware on the vehicle that will not fully charge the battery when driving to save fuel. The vehicle has had 6 or more instances over the past two weeks where the car was undriveable unless jumped from another vehicle or a boost device is used.

   NHTSA complaint #11643837 · source
3. Filed Sep 25, 2024CABody & Structure

   continues issue with windshield cracks, cracks will spread over night across the windshield. car windshield will be replaced for a fourth time on [XXX]. I initially replaced it with in a year of purchase in North Carolina and will replace for a third time here in San Diego at the dealer Kearny Mesa Subaru address 4797 Convoy St. San Diego, CA 92111 phone number [phone removed]. Kearny Mesa has replaced my windshield for the last two times, first time was in spring of 2022,…

   NHTSA complaint #11616391 · source
4. Filed Jun 12, 2024MTBody & Structure

   Windshield just cracked on its own. My vehicle was just sitting in my backyard nothing around my vehicle. A day latter i went outside i noticed the windshield was cracked nothing touched the windshield it just cracked on its own.

   NHTSA complaint #11593806 · source
5. Filed Nov 26, 2023NCBody & Structure

   The hood popped open at 35 mph causing loss of sight. I was in traffic and luckily was able to pull the car off the road. I am taking it to the dealer as soon as I can get an appointment. There were no warning lights or messages prior. I will secure the hood with something before I drive it to the dealer. If I had been driving on the Interstate I am sure the hood would have smashed into windshield. I consider this a very dangerous problem.

   NHTSA complaint #11556840 · source
6. Filed Jul 15, 2023VA1 injuredBody & Structure

   Pressed the button on the electronic liftgate to have it raise. Half way through raising, it beeped 3 times and started closing. Had 3 dogs in the back of the vehicle and the lift gate started to close on one of them. I put my left arm underneath to stop it from closing where the lift gate put a lot of pressure on my forearm. The lift gate stopped and I was able to push it back up. Injury seems to be minor but will have it checked. Feels like it impacted the nerves going to…

   NHTSA complaint #11532428 · source
7. Filed Apr 13, 202330,000 miNJ1 injuredBody & Structure

   The contact owns a 2019 Subaru Outback. The contact stated while she was reaching inside the trunk, the trunk gate independently closed. The contact mentioned that the security sensor did not function which caused the failure. The contact sustained injuries on her right knee, right hip, right shoulder, right glutinous, and right shoulder and was seeking medical attention. The contact called the local dealer and independent mechanic and made them aware of the failure. The…

   NHTSA complaint #11516856 · source
8. Filed Sep 22, 202227,097 miCTBody & StructureElectrical System

   The contact owns a 2019 Subaru Outback. The contact stated while the vehicle was parked in the garage, she was unable to open the door with the key fob. The contact stated that she was able to open the front driver’s side door with the key manually. The contact stated she was unable to start the vehicle. The contact's boyfriend attempted to jump start the vehicle however, the vehicle failed to start. The vehicle was not diagnosed or repaired. A dealer was not contacted. The…

   NHTSA complaint #11485796 · source
9. Filed Aug 3, 2022VABody & StructureElectrical System

   The automatic liftgate fails to latch and requires extra steps that most car owner would not know to temporarily resolve the issue. My situation has been difficult to replicate. The liftgate will open but not close. It will also close but not open. It will also latch but not securely. This evening, the hatch opened but failed to close. It also latched but found out at 55mph that it was not properly secured when my dog leaned against it. It did not open but the light turned…

   NHTSA complaint #11477271 · source
10. Filed Apr 26, 2022CABody & StructureElectrical SystemOther / Unknown

    Rear tailgate fails to open consistently making it impossible to enter or exit the vehicle from the rear, through the rear tail gate door (the 5th door). Nine times we have brought vehicle back to authorized Subaru dealerships over the last two years of ownership in Hanover Ma-Planet Subaru; San Francisco -Serramonte Subaru and lastly in San Diego- Kearny Mesa. The rear tail gate does not open consistently while pressing the open button on either of the key fobs or from…

    NHTSA complaint #11462225 · source
11. Filed Mar 2, 2022CABody & Structure

    Windshield cracked spontaneously without impact. Upon further investigation, this is a common issue observed with Subaru on multiple models from previous and current years. There has been a couple of class action lawsuits against Subaru in other states for the same issue, and both cases were ruled in favor of the plaintiff and the court deemed these windshield defective. My concern and question is, why is Subaru still using parts/models that aren’t safe and getting away with…

    NHTSA complaint #11454907 · source
12. Filed Feb 18, 2022TXBody & Structure

    I purchased this car in July 2019. Three times the windshield has cracked without any explanation or cause. Three weeks ago, I replaced the second cracked windshield at my own expense. Three weeks later -- just yesterday, Feb. 17, 2022 -- the brand new windshield simply cracked. All three times the crack has appeared in roughly the same place. There was no road debris or anything else that came into contact with the windshield.

    NHTSA complaint #11452711 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology