2019 Toyota C-HR transmission & drivetrain problems

Related recalls

• Recall 18V710000Oct 11, 2018681 vehicles
  POWER TRAIN:AXLE HUBS

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019 Toyota C-HR vehicles. The rear axle hub bearing bolts may have been insufficiently tightened, causing the bolts to loosen and damage the rear brake components or cause a rear wheel to detach.

  Risk: If the bolts loosen and damage the rear brake components, or cause a rear wheel to detach, it would increase the risk of a crash.

  Remedy: Toyota will notify owners, and dealers will inspect the rear axle hub bearing bolts. If a bolt is found to be loose or detached, the dealer will replace the rear axle hub bearing assembly and rear axle carrier sub-assembly, free of charge. The recall began November 6, 2018. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0Y.

What owners say

1. Filed Sep 23, 2026GATransmission & Drivetrain

   Driving home from work on the freeway, the loud droning and whining sound was already present. Same issue that I thought had been previously resolved by replacing the transmission from the dealership it was purchased from. Though this time it was accompanied by a horrible grinding sound coming from the bearings in the transmission. After much research into this issue, iI found that it is a very common issue wtih this particular vehicle. Specifically the K1114 transmissions…

   NHTSA complaint #11766496 · source
2. Filed Sep 23, 2026TXTransmission & Drivetrain

   The transmission has failed twice. It was replaced once in 2020, right after we bought the vehicle in 2019. We have serviced the car as required at the same dealership. We were told in August 2026 by the dealership, after having the transmission serviced in the Spring of 2026, that the transmission needed to be replaced. We received a Customer Support Program letter from Toyota in September 2026 that the transmissions on 2018-2019 vehicles are being replaced because of known…

   NHTSA complaint #11766376 · source
3. Filed Sep 21, 2026CATransmission & Drivetrain

   While driving my 2019 Toyota C-HR normally on [XXX] in [XXX] at approximately 8:00 PM, traffic began slowing due to congestion. When traffic began moving again, the vehicle accelerated very slowly and did not respond normally to the accelerator. Shortly afterward, the dashboard displayed a “Pull Over Safely” warning. The vehicle then completely lost its ability to move under its own power. It would not move normally in either Drive or Reverse and had to be towed off the…

   NHTSA complaint #11765841 · source
4. Filed Aug 15, 2026MATransmission & Drivetrain

   Transmission won’t shift out of manual mode and car won’t move at all even when in drive or reverse. Was working completely fine then all of a sudden got drive start malfunction and won’t move. Called mechanic they came looked at it and they diagnosed it as a transmission problem. Did some research and this is a well known issue that Toyota Canada has acknowledged but Toyota USA won’t. Car is barely over 100k miles and all maintenance has been kept up on. Transmission only…

   NHTSA complaint #11757110 · source
5. Filed Jul 31, 2026VATransmission & Drivetrain

   While driving my vehicle, it is a consistent clicking loud noise. I had the vehicle checked out twice and both places said the same thing as it is explained down below: Transmission Replacement (Automatic): SEVERE INTERNAL TRANSMISSION NOISE- NOISE LOUDER W/ SPEED. NEED TO REPLACE TRANSMISSION ASSEMBLY- DO NOT RECOMMEND DRIVING VEHICLE MAY BE CATASTROPHIC AND COME APART This statement is from the Toyota dealership.

   NHTSA complaint #11754044 · source
6. Filed Jul 29, 2026CATransmission & Drivetrain

   No warning lights, only noticed a new noise like a whirring sound that matches car speed, not acceleration. Had the car looked at and determined it was likely the same CVT transmission bearing failure most CHR owners are experiencing. Toyota is no help and estimates for repair are $6k to $10k from private transmission repair places. Now we have a dud of a car that we still owe money on that isn't even worth the price to repair it.

   NHTSA complaint #11753623 · source
7. Filed Jul 7, 2026NCTransmission & Drivetrain

   Noise from front left axel began on XXX. Taken to local garage for diagnostic on XXX at approximately 149,000 miles. Was informed that it likely was the transmission. This was confirmed when taken to Toyota dealership on XXX. National recall was issued in [XXX] by Toyota for the known transmission failure that occurs in the CH-r CVT transmission. No other issues or alerts had occurred prior to the transmission failure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF…

   NHTSA complaint #11748913 · source
8. Filed Jun 30, 2026MAOther / UnknownTransmission & Drivetrain

   2019 C-HR is experiencing transmission failure due to a faulty joint. Metal shavings flow into the fluid. Am being told I will need to replace the entire transmission. Toyota is fully aware of the issue with the failures occurring between 75,000 & 120,000 miles. My vehicle is at 107,000. Perfect maintenance record, never missed a service & all work done at the dealership where it was purchased. Research shows Toyota Canada acknowledged the issue & extended the warranty to…

   NHTSA complaint #11747544 · source
9. Filed Jun 28, 2026VAAcceleration & Cruise ControlTransmission & Drivetrain

   The CVT transmission failed at approximately 60,000 miles. The vehicle was fully maintained by Toyota dealerships. The failure of the transmission bearing will cause the car to lose power and could fail while driving, creating a risk of being stranded in traffic or being unable to accelerate to avoid a collision. Toyota Canada has extended the warranty for this same transmission issue up to 119,924 Miles (193,000 KM) and 10 years on comparable Toyota C-HR vehicles, but…

   NHTSA complaint #11746996 · source
10. Filed Jun 26, 2026TXTransmission & Drivetrain

    Transmission is making metallic type noise from below. Had rotors ,brakes,cv axles replaced thinking those were the culprits until reputable automotive repair informed me that noise was from Toyota cv transmission. And a repair or replacement would be around $10k I researched and found many Toyotas in the United States have same problem and Canadian residents with same issue have been granted an extended warranty to resolve this issue. I live in Texas. This is my wife’s car…

    NHTSA complaint #11746732 · source
11. Filed Jun 23, 2026OHTransmission & Drivetrain

    Before 2024, my friend heard a noise coming from my car, he wasn’t sure what it was and I couldn’t hear it. December 2024, I took my car in to the Toyota dealership for the 100,000 mile transmission service (~107,000 miles) but I didn’t mention the sound because I didn’t hear it. The dealership didn’t find any issues. My friend could still hear the sound but we thought that the service done ruled out the transmission. 18 months and 36,000 miles later a louder noise started.…

    NHTSA complaint #11745946 · source
12. Filed Jun 11, 2026TXTransmission & Drivetrain

    The vehicle experienced a sudden and catastrophic internal failure of its Continuously Variable Transmission (CVT) at 139,000 miles. While driving, a heavy grinding noise began coming from the vehicle during acceleration. A certified technician at a Toyota dealership inspected the vehicle and officially diagnosed it with an internal center differential grind and noted that the transmission fluid was burnt and filled with metal flakes. The dealership stated the entire…

    NHTSA complaint #11743556 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology