2006 Toyota Highlander brakes problems

Related recalls

• Recall 10V499000Oct 21, 2010728,544 vehicles
  SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

  Toyota is recalling certain model year 2005-2006 avalon, model year 2004-2006 highlander, model year 2004-2006 lexus rx, and model year 2006 lexus gs and is vehicles. Brake fluid containing polymers is used that acts as lubricants for certain brake system components. If replacement brake fluid is used that does not contain such polymers, or that contains only small amounts, a part of the rubber seal located at the rear of the brake master cylinder may become dry, and the seal may curl during movement of the piston. If this occurs, a small amount of brake fluid could slowly leak from the seal into the brake booster.

  Risk: A leak of brake fluid could lead to a change in brake pedal feel and overtime a degradation in braking performance increasing the risk of a crash.

  Remedy: Dealers will replace the seal with a newly designed one. This service will be performed free of charge. The safety recall began on november 15, 2010. Owners may contact toyota at 1-800-331-4331 and lexus at 1-800-255-3987.

What owners say

1. Filed Oct 7, 2026CABrakes

   Multiple warning lights appeared on the dash board including ABS, also check VSC system in the dialogue window. Code C1391 (Abnormal leak in accumulator) appeared in a diagnostic scan. After some internet research, it appears this a common problem with the 2006 Toyota Highlander and is a very costly repair $2000-$4000. The leaky accumulator creates an unsafe driving condition as the ABS and VSC system are disabled due to the leak. Due to the high number of failures for these…

   NHTSA complaint #11769614 · source
2. Filed Sep 12, 2026CABrakes

   The Antilock Braking Actuator has failed. This seems to be a known issue and was already recalled on the Toyota Camry. Toyota sells the part for $1500 locally and labor will be added to that as well - which will put the cost of replacing this critical part almost above the current value of the vehicle. This is a safety issue if I lose braking capability. It has not yet catastrophically failed, but is making a buzzing sound which is the indication of this unit losing brake…

   NHTSA complaint #11763765 · source
3. Filed Sep 1, 2026CABrakes

   The ABS/Brake Actuator is going out. There is a stuttering as I'm coming to a stop, but when I brake from normal speeds to slow down, there is no stutter/vibration. Only when I'm going very slow and about to stop the car is when I feel a vibration/stutter in the vehicle. When pressing the brakes all the way down, there is a weird chirping/clicking noise that comes from under the hood towards the passenger side of the car. I do not have and did not get any warning lights…

   NHTSA complaint #11761452 · source
4. Filed Aug 5, 2026SDBrakes

   ABS actuator/accumulator issue on 2006 Toyota Highlander hybrid limited. Internal component failure there are recalls on others but not this particular year. Was driving along hit the brakes and got hard pedal. Yes there were other indicator lights on including the VSC system and traction control I came to an intersection and I couldn't stop I couldn't even kind of stop it was all hard pedal were before it was normal as if there wasn't an issue. I've done a lot of research…

   NHTSA complaint #11755074 · source
5. Filed Jul 1, 2026195,000 miWATowedBrakes

   The contact owns a 2006 Toyota Highlander. The contact stated that while driving approximately 60 MPH, the vehicle failed to decelerate while the brake pedal was depressed. The contact stated that excessive pressure was needed on the brake pedal to stop the vehicle. The ABS and ESC warning lights were illuminated. In addition, there was an abnormal sound coming from underneath the vehicle. The vehicle was towed to a local independent mechanic, where it was diagnosed and…

   NHTSA complaint #11747659 · source
6. Filed Jan 12, 2026MDBrakes

   My 2006 Toyota Highlander Hybrid Limited has an ABS fault that has caused my vehicle to undergo several maintenance issues and poses a serious safety hazard. My vehicle has less than 150,000, and over the course of the last year, my ABS light, my emergency brake light, my TSC light, and my tire pressure sensor light have all come on and refuse to go away. Additionally, the maintenance light, along with a "CHECK VSC SYSTEM" message has been on my dash for months and will not…

   NHTSA complaint #11710274 · source
7. Filed Dec 26, 2025ILBrakes

   Toyota’s part number 44050-48190 brake actuator assembly failed, as it has in other models and is very commonly doing in the Highlander model. It is triggering other warning lights issues in the vehicle. Vehicle safety is at risk. Many others have reported the same issue.

   NHTSA complaint #11707172 · source
8. Filed Aug 13, 2025VABrakesEngine

   I was on the interstate driving about 72 mph when the car just shut off all the dash lights came on and the dash it said check hybrid system I had no brakes or steering I got it off the road turned it off and back on again it started up and I drove it home but the dash still displayed check hybrid system , a week later I get in it to go to work and there’s an alarm that won’t cut off and the abs , traction control and brake light and warning light and tire pressure light are…

   NHTSA complaint #11680473 · source
9. Filed May 23, 2025TXBrakes

   The vehicle suffers from an ABS module failure. I've been researching that this is common problem with the Toyota Highlander Hybrid and presents a danger of failing brakes while driving. My brakes partially failed with my [XXX] son in the car. When attempting to stop, I had no hydraulic pressure and luckily was able to get the vehicle stopped after the car had regained some pressure. The vehicle had been running for several minutes, so it wasn't related to a fresh start and…

   NHTSA complaint #11662789 · source
10. Filed Mar 16, 2025CA1 injuredBrakes

    The brakes on my 06 Highlander hybrid AWD have been finicky at best since I’ve owned the vehicle. The car lunges forward when braking, all the way until a complete stop. While driving at around 55 MPH a medium sized dog ran out into the road. I braked hard but the brakes just lunging and trying to stop. At one point feels like it’s not braking anymore and just hope to veer out of the way. This can be fatal not only to the driver but to others driving as well. The fact that…

    NHTSA complaint #11648546 · source
11. Filed Dec 21, 2024INBrakes

    Car is lunging forward while braking.I just had to put a new abs module and pump on the vehicle which was very expensive.Since I know there was a recall but I was not notified.Is there a way to get toyota to pay for the new pump and module ?

    NHTSA complaint #11631922 · source
12. Filed Jul 12, 2024VABrakesOther / UnknownTransmission & Drivetrain

    Two problems being reported are severe safety issues, and could result in injury, death, and/or property damage. Problem 1: While driving, the brake pedal suddenly went all the way to the floor, and the car would not stop. To avoid hitting the car in front at a stop sign, I had to turn the wheel, resulting in running through the stop sign and onto the grass and shoulder before the car finally stopped. Multiple dashboard warning lights appeared. After stopping, the brakes…

    NHTSA complaint #11601445 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology