2021 Chevrolet Silverado 1500 engine problems

Related recalls

• Recall 25V274000Apr 24, 2025597,571 vehicles
  ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL

  General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.

  Risk: Engine failure increases the risk of a crash.

  Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.

What owners say

1. Filed Oct 6, 2026MIEngineFuel, Hybrid & EV Propulsion

   I was traveling on a 55mph road. My Chevy Silverado started to shake and lose propulsion. I pulled off on the side of the road. In idle it shook. The dealership was one mile to my south. I turned on the hazard lights and went to the dealership. I could only get the vehicle to 45mph as in shook very bad the whole way. It felt as if the engine was going to explode the whole way there. The vehicle was taken to the dealership where it has been initially diagnosed as a bad lifter.

   NHTSA complaint #11769475 · source
2. Filed Oct 6, 2026172,000 miPAEngine

   The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving approximately 35 to 40 MPH, the vehicle stalled and failed to restart. The contact retrieved DTC: P228C and P030 after scanning the vehicle. The vehicle was towed to a service center, where the contact was provided DTC: P228C, P0340, and P0C6. The contact was informed that the timing chain and guide had failed and that the engine needed to be replaced. The vehicle was not repaired. The…

   NHTSA complaint #11769427 · source
3. Filed Oct 6, 202678,000 miVAEngine

   The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the vehicle was smoking. The contact stated that the engine was smoking heavily with a strong oil odor, before the vehicle shut off. The contact stated that the engine warning light was illuminated. The vehicle was restarted and driven to the dealer. The manufacturer was notified of the failure. The vehicle was taken to the dealer, and the technicians confirmed…

   NHTSA complaint #11769394 · source
4. Filed Oct 4, 2026TXEngineFuel, Hybrid & EV PropulsionTransmission & Drivetrain

   I am submitting this complaint regarding a 2021 Chevrolet Silverado 1500 Trail Boss 4WD with the [6.2L V8 (L87)], VIN [XXX], 101,000 miles. The truck was assembled in Mexico in XXX, about six weeks before XXX, just outside the build range of GM recall 25V-274 (N252494000, Engine Failure). On 10/2/2026, [XXX], [XXX] a certified GM dealership, diagnosed crankshaft and lifter failure, matching the recall condition. Codes: P0300, P050D, P0016. The truck was shaking violently,…

   NHTSA complaint #11768822 · source
5. Filed Oct 2, 202637,100 miOHEngine

   The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that the vehicle experienced excessive oil consumption at 2,600 miles. The vehicle was taken to the dealer, where it was diagnosed with a blown engine. The engine was replaced; however, the contact stated that the replacement engine continued to consume a significant amount of engine oil. The vehicle was taken back to the dealer, where the replacement engine was diagnosed with premature engine failure at…

   NHTSA complaint #11768486 · source
6. Filed Sep 30, 2026MIEngine

   My truck is the 2021 with the 6.2l L87 motor. My truck is not in the scope of the recall but i had the same failure and received a remanufactured engine without any warranty coverage.

   NHTSA complaint #11768073 · source
7. Filed Sep 29, 2026AZEngineTransmission & Drivetrain

   This vehicle's engine failed on a high-volume roadway in [XXX] which resulted in a significant safety issue. The vehicle was taken to a certified Chevrolet dealership in Scottsdale (Van Chevrolet) whereby the engine in this 5.3L V8 was replaced due to catastrophic engine failure with the lifters being the suspected cause of the failure. Aside from the $10,400 cost of the remanufactured engine replacement, I have had considerable discussions (live and written) with GM Arizona…

   NHTSA complaint #11767705 · source
8. Filed Sep 24, 2026IDEngine

   the engine seized. I tore into the motor to inspect what caused it and it spun a connecting rod bearing on cylinder 1. I have been paying 600 a month on it without being able to drive it since this happened in november of 2024.

   NHTSA complaint #11766765 · source
9. Filed Sep 20, 2026GAEngineOther / Unknown

   My truck started skipping and over time the check engine light came on. I took it in and they are saying it is the lifters, which is costly. I know this truck was built during COVID and I know a lot of the manufacturers were dealing with skeleton crews. I heard this was an issue with the 2021 Silverado trucks, and a recall. Can you please advise?

   NHTSA complaint #11765689 · source
10. Filed Sep 20, 2026NJEngine

    The water pump went bad at 31,000 miles. If I continued driving and the pulley fell off the engine would overheat. I took it to the dealer and they confirmed the pump failure and want me to pay over $1,400 for repair that should be covered under warranty. There was no warning lamps lit, the pump just started making a grinding sound.

    NHTSA complaint #11765602 · source
11. Filed Sep 17, 2026PAElectrical SystemEngineTransmission & Drivetrain

    2021 silverado engine failure. Yes it was inspected by a dealership and my extended warranty company and serviced by the dealership. Back on August 5th I experienced a misfire cylinder 3 and felt loss of power. On August 7th the dealership diagnosed both camshafts, 1 lifter, 1 valve, and 1 fuel injector was damaged and never received at warning lights or messages on the dashboard. I was without the vehicle for 39 days and within 10 hrs after picking up the truck i got an…

    NHTSA complaint #11764947 · source
12. Filed Sep 12, 2026CAEngine

    LM2 engine coolant control valve failure. My vehicle VIN is not listed for the repair i dont know how it is not but they want me to pay outa pocket

    NHTSA complaint #11763762 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology