2023 Chevrolet Trailblazer engine problems

Related recalls

No recalls on file.

What owners say

1. Filed Oct 6, 2026NCBrakesElectrical SystemEngine

   purchased brand new December 2022. 7000 miles had issues with brake noise. dealership resurfaced rotors. 28000 miles turbo had to be replaced due to "reduced engine power". Was told a seal was the problem in the original design. 45000 miles a/c would stop blowing and produce extensive condensation on middle vents and "shift to park" became a problem. dealership cannot "reproduce" issues and therefore states nothing is wrong, although research shows problems exists and there…

   NHTSA complaint #11769263 · source
2. Filed Sep 23, 2026CAFireEngineOther / Unknown

   This incident is in regards to a fire that occurred in the engine bay area, post having turbo replacement and spark plug replacement done by a local dealership where this car was purchased new. Car had roughly approximately 60,000 miles and had a check engine light and engine reduce power notification on dash. Was taken to the aforementioned dealership for general scope of work while in the possession and actively being test driven for the repair the vehicle was driven 5…

   NHTSA complaint #11766531 · source
3. Filed Aug 28, 2026ILEngine

   While driving to work last Thursday morning suddenly my 2023 Trailblazer let out a sorta growl and then a dragging noise thankfully I was able to get over and stop on the shoulder only to discover that my tail pipe was dragging from just after the catalytic converter as the bolts apparently sheared off leaving only the head of the bolts intact. Lucky for me I there wasn’t major damage. I did however have to get my vehicle towed and have the bolt heads cut off in order to…

   NHTSA complaint #11760189 · source
4. Filed Jul 10, 202633,000 miGAEngine

   The contact owns a 2023 Chevrolet Trailblazer. The contact stated that on several occasions while driving at various speeds, the vehicle went into LIMP Mode with the check engine warning light illuminated. The contact stated that on three occasions, the vehicle was stopped and restarted, but the failure persisted. The vehicle was taken to an independent mechanic, where it was determined that the wastegate actuator needed to be replaced, and DTC: P0299 was retrieved. The…

   NHTSA complaint #11749624 · source
5. Filed Jun 10, 202688,251 miGAEngine

   The contact owns a 2023 Chevrolet Trailblazer. The contact stated that, while driving on several occasions with the auto start-stop feature activated, the vehicle appeared to shut down at a complete stop as the infotainment screen and dashboard lights turned off. The vehicle restarted automatically but shuddered during startup. The dashboard lights and the infotainment screen became operable. The vehicle was not diagnosed or repaired. Additionally, the contact stated that…

   NHTSA complaint #11743152 · source
6. Filed May 13, 2026103,000 miALEngine

   The contact owns a 2023 Chevrolet TrailBlazer. The contact stated while driving 70 MPH on the interstate , the vehicle independently went into engine power reduce mode. The contact mention she pulled off the interstate, turned the vehicle off for five to ten minutes then turned the vehicle back on and the vehicle began to work as intended. A dealer was contacted. The vehicle was taken to a dealer where it was diagnsonesd the turbo booster needed to be replaced. The vehicle…

   NHTSA complaint #11737558 · source
7. Filed Mar 16, 2026WIEngine

   The bolts holding the exhaust to the catalytic converter broke while I was driving my car. The car could have flipped, the exhaust could have busted through the vehicle, or I could have caused an accident and died. This comes on the heels of the EXACT SAME THING happening to my wife's Chevy Trailblazer with nearly the same mileage as mine. I have 97K miles and she 96K. This is a KNOWN ISSUE to them and it is NOT THE FIRST time this has occurred. There are thousands of…

   NHTSA complaint #11724711 · source
8. Filed Feb 5, 2026INEngine

   Had p1098 code come up on car at 67000 issue coolant control valve assembly went bad. This a commons issue with trailblazers and other cars similar to it. Bad design cause extremely expensive repair for this component.

   NHTSA complaint #11715776 · source
9. Filed Dec 16, 2025ILEngineOther / Unknown

   Exhaust fell off under normal operating conditions. Dealership (Dekalb Sycamore Chevrolet- Sycamore Illinois) stated this has been a common issue with this year group of Chevrolet Trailblazer SUVs. Dealership stated the bolts/exhaust pipe junction between the catalytic converter and pipe that goes to the muffler rusts through and the entire exhaust system from the cat back falls out of the undercarriage of the vehicle, which is what happened here.

   NHTSA complaint #11705260 · source
10. Filed Sep 5, 2025CAEngine

    Coolant Vavle malfunction Engine could overheat Yes Manufacturer No warning lights..check engine light came and I had the car diagnosed

    NHTSA complaint #11685297 · source
11. Filed Aug 27, 2025OHEngine

    at around 42,000 miles my Trailblazer displayed a message that engine power had been reduced and the check engine light came on. I took it to my dealer who diagnosed as a problem with the engine turbo fixed it and returned the car to me. I drove for 2 weeks and the same thing happened. I traded it in on an Equinox after the service manager said the turbo was a know issued. I did not want to be driving on the interstate with reduced power. Also I took a financial hit on the…

    NHTSA complaint #11683446 · source
12. Filed Jun 25, 2025MDEngine

    The turbo went out on the car for absolutely no reason. Message popped up on dash board saying "Engine power reduced". I have seen this happen to many many many other card across the country. It does not many how many miles are on the car. some Ive seen 25k and some ive seen at 60k. Shouldn't Chevy be recalling and fixing the part? Seems unfair to me as a consumer. Who has thousands of dollars to get that repaired?

    NHTSA complaint #11669095 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology