2012 Ford Expedition problems, complaints & recalls

2012 Ford Expedition recalls (3)

• Recall 16V248000Apr 27, 2016153,581 vehicles
  POWER TRAIN:AUTOMATIC TRANSMISSION

  Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford F-150 trucks, 2012 Ford Expedition, Lincoln Navigator, and Ford Mustang vehicles. The affected vehicles are equipped with an automatic transmission that may unexpectedly downshift to first gear, regardless of vehicle speed.

  Risk: An unexpected downshift into first gear can cause the vehicle to slow down suddenly without warning and the rear tires may slide or lock, increasing the risk of a crash.

  Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module with updated software, free of charge. The recall began on September 19, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S19.

• Recall 12V190000May 3, 201210,500 vehicles
  EXTERIOR LIGHTING:BACK UP LIGHTS · POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

  Ford is recalling certain model year 2011-2012 ford f-150, 2012 expedition and lincoln navigator, and 2012-2013 mustang vehicles, for failing to comply with the requirements of federal motor vehicle safety standard nos. 102, "transmission shift lever sequence, starter interlock, and transmission braking effect" and 108 “lamps, reflective devices and associated equipment.” these vehicles may have a transmission range sensor (trs) that was calibrated out of specification for reverse gear.

  Risk: If this condition exists, the transmission may not go into reverse or when the driver pushes the shift lever in the reverse “r” position and the vehicle’s transmission does go in reverse, the “r” may not illuminate on the dashboard of the f-150, expedition, or navigator models and/or the backup lamp on the rear of the f-150, expedition, navigator, or mustang vehicles may not illuminate. These conditions increase the risk of a crash or a pedestrian being struck due to the vehicle’s not signaling it is in reverse.

  Remedy: Ford will notify owners, and dealers will inspect and replace the trs as necessary, free of charge. The safety recall began on june 11, 2012. Owners may contact ford motor company customer relationship center at 1-866-436-7332.

• Recall 12V034000Feb 2, 2012569 vehicles
  SEATS:MID/REAR ASSEMBLY

  Ford is recalling certain model year 2012 expedition and lincoln navigator vehicles, manufactured from november 19, 2011, through december 2, 2011, for failing to comply with the requirements of federal motor vehicle safety standard no. 202, "head restraints." these vehicles may have inadequate welds on the head restraint support brackets for the second row, right-hand seat.

  Risk: In the event of a crash, the seat head restraint may not provide the required strength, increasing the risk of injury.

  Remedy: Ford will notify owners, and dealers will replace the head restraints as necessary, free of charge. The safety recall began on february 21, 2012. Owners may contact ford motor company customer relationship center at 1-866-436-7332.

NHTSA defect investigations

• RQ17010Opened Dec 25, 2017Closed Oct 22, 2019led to recall 19V075000

  Unexpected Transmission Downshift

  The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident cla…

Recent 2012 Ford Expedition complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Apr 7, 2026166,000 miMATowedEngineTransmission & Drivetrain

   The contact owns a 2012 Ford Expedition. The contact stated that while his wife was driving 30 MPH, the transmission unexpectedly downshifted, causing the occupants to lunge forward. The tires squealed and the wheels locked up. The vehicle was turned off but failed to restart. No warning light was illuminated. The contact stated the failure was associated with NHTSA Campaign Number: 16V248000 (Power Train). A tow truck company was contacted, and was able to restart the…

   NHTSA complaint #11729726 · source
2. Filed Nov 17, 2025KSAcceleration & Cruise Control

   The speedometer will quit working and the vehicle will not shift out of 1st gear, if you can work through it it will start throwing error messages such as zero miles to empty, tire moniter system fault, etc. This is a very dangerous situation especially in high traffic areas. There was a customer satisfaction program on it but only up to 150,000 miles. This program should last the life of the vehicle, also, if it was fixed before ownership, why did it go bad again

   NHTSA complaint #11699752 · source
3. Filed Oct 22, 2025OKTransmission & Drivetrain

   Over a period of time this problem is occurring more often. The vehicle will downshift into first gear. I pull over check engine light is on. I turn off wait turn back on and no problem for awhile. Within the last month this has occurred many times . Each time the check engine light comes on but also now the advance track light. Each time I have the same codes pulled. Driving on the highway with my daughter at 65mph it downshifted and the back tires locked up . Vehicles had…

   NHTSA complaint #11695051 · source
4. Filed Sep 10, 202578,000 miNJDriver Assistance & Safety Tech

   The contact owns a 2012 Ford Expedition. The contact stated that the image displayed on the back over prevention screen was either upside down, distorted, static only, or completely black. The failure was intermittent. During the failure, the contact was able to restart the vehicle to fix the image; however, the fix was intermittent. The vehicle was not taken to the dealer. The vehicle was not diagnosed or repaired. The contact researched and found information on NHTSA…

   NHTSA complaint #11686275 · source
5. Filed Aug 29, 2025INAcceleration & Cruise ControlTransmission & Drivetrain

   I was driving my 2012 expedition and suddenly the vehicle went from doing 60 to 40 immediately the tires squealed and threw me into the right lane . This vehicle transmission has a recall for down shifting and power train issues. My vin number does not fit the Recall but my vehicle has all the symptoms of multiple recalls and is not safe to drive . Had i not known how to drive i and my daughter would be in the hospital due to the faulty transmission lead frame and power…

   NHTSA complaint #11683830 · source
6. Filed Jul 26, 2025WIElectrical SystemAcceleration & Cruise ControlTransmission & Drivetrain

   July 2025 my 2012 ford expedition threw a p0742 code for a stuck torque converter clutch. The vehicle had just under 150k miles and started to jerk in and out of gear and the wrench light illuminated so i, thankfully was going approximately 45 mph when it happened and was able to pull the vehicle over as it was in limp mode. When i cleared the dtc code the problem went away temporarily but eventually locked back up again within a mile from my home. Unfortunately, ford…

   NHTSA complaint #11676319 · source
7. Filed Jul 25, 2025WIElectrical SystemEngineTransmission & Drivetrain

   Campaign 19N01 Description Transmission molded leadframe extended coverage Next Steps Contact your dealer for next steps. Did this and was told that the vehicle was not covered due to it being after 10 years and barely over 150,000 miles. I am experiencing transmission issues where the torque converter clutch is now stuck on and the lead frame is more than likely the cause. Thanks FORD, NEVER AGAIN.

   NHTSA complaint #11676166 · source
8. Filed Jul 25, 2025WIElectrical SystemAcceleration & Cruise ControlTransmission & Drivetrain

   I just purchased (2 months ago) a 2012 Ford Expedition EL 5.4l v8 from a private party. I wish I would have done more research as I am ALREADY EXPERIENCING TRANSMISSION ISSUES THAT I BELIEVE ARE DIRECTLY RELATED TO THE VEHICLES LEAD FRAME RECALL. IT THREW A P0742 CODE ON ME Torque Converter Clutch Circuit stuck on and decided that it would only drive in limp mode unless I cleared the code, pulled over, cycles the key, and restarted the vehicle. Even as dangerous as this…

   NHTSA complaint #11676082 · source

Compare the 2012 Ford Expedition with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 10, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology