2023 Hyundai Santa FE problems, complaints & recalls

2023 Hyundai Santa FE recalls (1)

• Recall 23V181000Mar 17, 2023584,784 vehiclesPark outside
  TRAILER HITCHES

  Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

  Risk: A fire while parked or driving can increase the risk of injury.

  Remedy: Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.

NHTSA 5-Star safety ratings

Recent 2023 Hyundai Santa FE complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Oct 5, 2026CTTransmission & Drivetrain

   My 2023 Hyundai Santa Fe Calligraphy has experienced transmission problems since it was new and currently has approximately 20,000 miles. I brought it to the dealership approximately three to four times for these concerns, but I was told they could not find a problem or any diagnostic codes. Recently, while driving on the highway, the vehicle lost power and would not accelerate even with the accelerator pedal pressed all the way down. I had to pull over to the side of the…

   NHTSA complaint #11769015 · source
2. Filed Sep 24, 2026MIOther / Unknown

   The AWD coupler has failed and the rear wheels feel like they are slipping and catching when I accelerate from a stop, particularly when turning. The car was taken to the dealership and inspected, but no longer under warranty as we are not the original owners.

   NHTSA complaint #11766705 · source
3. Filed Sep 24, 2026MAOther / Unknown

   I bought my 2023 Hyundai Santa Fe at Auto Fair Hyundai in [XXX] in XXX new. This is my third Hyundai from this location over the years. I have always serviced it there ever since I bought it. ( oil changes, tire rotation etc.) Back in XXX while driving home from [XXX] to [XXX] on [XXX] I hit the brakes in the left hand lane, in traffic and my vehicle shut off and wouldn’t restart. Very scary luckily a young man helped push my car off the highway. I sat 5 minutes or so and it…

   NHTSA complaint #11766702 · source
4. Filed Sep 23, 2026NCBrakesDriver Assistance & Safety TechAcceleration & Cruise Control

   While traveling on [XXX] from [XXX] to [XXX] XXX, I initiated the adaptive cruise control. While engaged, with no other vehicles or other impediments on the roadway in front of me, the emergency braking system engaged and attempted to stop the vehicle. The first time this happened, I pressed the accelerator which disengaged the braking action. Later I reengaged the cruise control and after a few minutes, with no traffic near the vehicle, the same action happened again. I…

   NHTSA complaint #11766470 · source
5. Filed Sep 6, 2026INTransmission & Drivetrain

   I own a 2023 Hyundai Santa Fe Calligraphy AWD equipped with the 2.5L turbo engine and 8-speed wet dual-clutch transmission. At approximately 39,900 miles, the check-engine light illuminated. Hyundai Bluelink diagnostics reported powertrain/TCU diagnostic trouble code P1C2D03, identified as a high-pressure electric oil pump motor position sensor fault. I am concerned because this same diagnostic trouble code and high-pressure electric oil pump/transmission issue was…

   NHTSA complaint #11762417 · source
6. Filed Sep 3, 2026MNBrakesDriver Assistance & Safety TechElectrical System

   Collision warning sensor alarm randomly comes on my dash and my car slams on the breaks. Very dangerous, I’m scared to drive down the highway going 60mph. 80,109 miles 2023 Hyundai Santa Fe. I have not brought it in to a Hyundai dealership because they want a diagnosis fee and everything else. Hyundai should fix it. This alarm has happened several times than it will go away and come on like 3 times in a row, usually daily when I use the car

   NHTSA complaint #11762036 · source
7. Filed Aug 12, 2026NYTransmission & Drivetrain

   Subject: Formal Dispute: Warranty Breach and Failure to Repair – 2023 Hyundai Santa Fe Timeline & Facts:11/2/25 (~52,000 miles): I officially reported an intermittent loss of power and severe engine revving (up to 7,000 RPM). This created a severe safety hazard when merging and accelerating from an idle stop.3/28/26 (Under 60k miles): After months of diagnostic delays, Hyundai confirmed the Dual-Clutch Transmission (DCT) needed replacement under the 60,000-mile warranty. A…

   NHTSA complaint #11756570 · source
8. Filed Aug 10, 2026NCFuel, Hybrid & EV PropulsionOther / UnknownTransmission & Drivetrain

   This complaint concerns a serious, unresolved powertrain/propulsion safety defect in my 2023 Hyundai Santa Fe. While traveling approximately 70 mph, the vehicle suddenly lost propulsion and would not accelerate normally while surrounded by highway traffic.MOST IMPORTANTLY, THERE WAS NO WARNING OR ADVANCE INDICATION. No warning lights, messages, or symptoms appeared before the loss of propulsion. I had no opportunity to anticipate the failure or prepare to safely exit…

   NHTSA complaint #11755949 · source

Compare the 2023 Hyundai Santa FE with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 11, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology