2011 Hyundai Sonata engine problems

Related recalls

• Recall 18V934000Dec 28, 2018150,730 vehicles
  ENGINE · FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

  Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2013-2014 Santa Fe Sport vehicles previously repaired under recall numbers 15V-568 and 17V-226. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned, or improperly torqued during the engine replacement procedure, allowing fuel to leak from the pipe.

  Risk: A fuel leak in the presence of an ignition source can increase the risk of a fire.

  Remedy: Hyundai will notify owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began March 1, 2019. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's recall number for this recall is 180.

• Recall 15V568000Sep 10, 2015470,000 vehicles
  ENGINE

  Hyundai Motor America (Hyundai) is recalling certain model year 2011-2012 Sonata vehicles manufactured December 11, 2009, to April 12, 2012 at Hyundai Motor Manufacturing Alabama and equipped with either a 2.0 liter or 2.4 liter Gasoline Direct injection engine. In the affected vehicles, metallic debris may not have been fully removed during manufacturing of the engine crankshaft. If the debris was not completely removed, oil flow may be restricted through the connecting rod bearings, causing connecting rod damage. A worn connecting rod bearing will produce a metallic, cyclic knocking noise from the engine and possible engine failure.

  Risk: Engine failure would result in a vehicle stall, increasing the risk of a crash.

  Remedy: Hyundai will notify owners, and dealers will inspect the vehicles and replace the engine assembly, as necessary, free of charge. Additionally, Hyundai Motor America will increase the warranty for the engine sub-assembly (short block) to 10 years/120,000 miles for both original and subsequent owners of 2011 and 2012 Sonatas manufactured at Hyundai Motor Manufacturing Alabama equipped with 2.0 liter and 2.4 liter Gasoline Direct injection engines. Interim notifications were mailed to owners starting on October 8, 2015. A second notification will be mailed when parts are available. Owners may contact Hyundai customer service at 1-855-671-3059 or by visiting www.HyundaiUSA.com/Campaign132. Hyundai's number for this recall is 132.

What owners say

1. Filed Sep 3, 2026OHElectrical SystemEngineSteering

   I was driving down the road going the speed limit and all of a sudden it felt like I hit a brick wall my car staked out and I was stuck in the middle of the road for about 20 minutes and finally I got it to start and drove home it did it again 2 months later

   NHTSA complaint #11762026 · source
2. Filed Aug 29, 2026ILElectrical SystemEngineLighting

   I had taken my Sonata to Mike Miller Hyndia in Peoria,I'll and they agreed to do the recall although they had my vehicle for two weeks. They did not service it and when I picked it up they said I had to drive it till the service engine light come on. I was driving it five days later and heard a loud noise and car started malfunctioning I was stuck in a middle of a intersection and I had to push vehicle off road. I broke my right hand in this process and I have also lost my…

   NHTSA complaint #11760651 · source
3. Filed Aug 18, 2026CAEngine

   The vehicle suffered an internal connecting rod bearing failure, a known manufacturing defect affecting the Theta II GDI engine. The failure was explicitly diagnosed via the manufacturer - specific OBD-II fault code p1326 Knock Sensor Detector System. This defect causes sudden engine stalling poses an immediate risk of catastrophic engine failure or fire while driving. Hyundai Motor America has denied financial reimbursement for the required engine repair because the work…

   NHTSA complaint #11757692 · source
4. Filed Jul 22, 2026OKEngineAcceleration & Cruise Control

   I test drove the vehicle at an auction, watched several other people test drive the vehicle. Before the auction I test drove it one more time and put my obd scan tool on it to make sure there were no hidden codes or problems. I won the bid,and picked up the vehicle. I drove it approximately 6 miles from the auction and the falshing engine light popped on. I immediately pulled over in heavy freeway traffic. Put my scan tool on it and found out the knock sensor had triggered.…

   NHTSA complaint #11752063 · source
5. Filed Jul 1, 2026CAEngine

   Rod bearing issue due to particles in engine causing engine to not accelerate as normal and jerk when goes over 10 MPH can’t exceed 50 miles causing safety issues and knocking/clicking noise took it to Hyundai and was informed it is apart of the recall but wont replace engine my vehicle has ALL the same issues as the Hyundai recall but my VIN isn’t registered on the site for recall on carfax it shows a pattern of the previous owners being car in for maintenance and engine…

   NHTSA complaint #11747821 · source
6. Filed May 29, 2026MNEngine

   My 2011 Hyundai Sonata (VIN [XXX] ) was brought to Gateway Hyundai in [XXX] for the mandatory P1326/KSDS engine recall inspection. I had a confirmed appointment on XXX at 7:30 AM. The dealership acknowledged the P1326 code and that the KSDS test was required.Instead of performing the recall, the dealership refused to inspect the vehicle. They contacted a third party who was not in possession of the vehicle and released the vehicle to that person without my authorization. The…

   NHTSA complaint #11740786 · source
7. Filed May 19, 2026CAEngine

   My 2013 Hyundai Sonata suffered engine failure consistent with Hyundai Theta II engine defects. The vehicle became inoperable/unsafe. Hyundai denied warranty coverage despite my maintenance records and documentation.

   NHTSA complaint #11738819 · source
8. Filed Apr 27, 2026190,000 miTXTowedEngine

   The contact owns a 2011 Hyundai Sonata. The contact stated that while driving at 60 MPH, the vehicle lost automotive power. There was no warning light illuminated. The vehicle failed to restart and had to be towed. The vehicle was towed to the dealer, but was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 190,000.

   NHTSA complaint #11734124 · source
9. Filed Mar 31, 2026GAEngine

   On March 18, 2026 I brought my vehicle to AutoNation Hyundai for an oil change and full diagnostic. Your dealership’s own diagnostic report showed no knock sensor code, no engine issues, and no active warning lights. My car was fully drivable when I dropped it off. Within 30 minutes of picking my vehicle up, the check engine light began blinking and the car became completely undrivable. It has not moved since March 20, 2026 at the dealership. The dealership did an additional…

   NHTSA complaint #11728334 · source
10. Filed Mar 25, 2026MDEngine

    The vehicle suddenly stopped and died while driving. The mechanic confirms that the engine is gone, contact Hyundai. Ourisman of Rockville and Hyundai Motor America (HMA) refuses to replace the engine for free. The vehicle has now developed a severe engine knock consistent with the well-documented defect affecting Hyundai’s Theta II engines. Hyundai has publicly acknowledged this issue and issued a major recall covering approximately 470,000 vehicles with the following…

    NHTSA complaint #11726946 · source
11. Filed Mar 16, 2026FLEngine

    My 2011 Hyundai Sonata experienced sudden engine failure and the engine is now locked up. The vehicle became inoperable and had to be taken to a Hyundai dealership. The dealership confirmed the engine is locked and not drivable. Hyundai denied the engine replacement claim stating the vehicle has A04/A08 branding indicating the engine originates from a scrapped or rebuilt vehicle. However, Hyundai refused to provide any documentation supporting this claim. They also refused…

    NHTSA complaint #11724779 · source
12. Filed Jan 26, 2026NYEngine

    My Hyundai Sonata has encounter two failing cylinders (compression loss) due to scoring. When driving in the highway I got engine shudder and loss of power (speed) that could have put me in dangerous driving condition, accident or other. These GDI engines are notorious for poor oil circulation due to faulty designed piston rings. Hyundai has long history with these poorly manufactured engines and class action lawsuits. I notified Hyundai but they are not willing to remedy…

    NHTSA complaint #11713510 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology