2012 Hyundai Sonata engine problems

Related recalls

• Recall 18V934000Dec 28, 2018150,730 vehicles
  ENGINE · FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

  Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2013-2014 Santa Fe Sport vehicles previously repaired under recall numbers 15V-568 and 17V-226. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned, or improperly torqued during the engine replacement procedure, allowing fuel to leak from the pipe.

  Risk: A fuel leak in the presence of an ignition source can increase the risk of a fire.

  Remedy: Hyundai will notify owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began March 1, 2019. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's recall number for this recall is 180.

• Recall 15V568000Sep 10, 2015470,000 vehicles
  ENGINE

  Hyundai Motor America (Hyundai) is recalling certain model year 2011-2012 Sonata vehicles manufactured December 11, 2009, to April 12, 2012 at Hyundai Motor Manufacturing Alabama and equipped with either a 2.0 liter or 2.4 liter Gasoline Direct injection engine. In the affected vehicles, metallic debris may not have been fully removed during manufacturing of the engine crankshaft. If the debris was not completely removed, oil flow may be restricted through the connecting rod bearings, causing connecting rod damage. A worn connecting rod bearing will produce a metallic, cyclic knocking noise from the engine and possible engine failure.

  Risk: Engine failure would result in a vehicle stall, increasing the risk of a crash.

  Remedy: Hyundai will notify owners, and dealers will inspect the vehicles and replace the engine assembly, as necessary, free of charge. Additionally, Hyundai Motor America will increase the warranty for the engine sub-assembly (short block) to 10 years/120,000 miles for both original and subsequent owners of 2011 and 2012 Sonatas manufactured at Hyundai Motor Manufacturing Alabama equipped with 2.0 liter and 2.4 liter Gasoline Direct injection engines. Interim notifications were mailed to owners starting on October 8, 2015. A second notification will be mailed when parts are available. Owners may contact Hyundai customer service at 1-855-671-3059 or by visiting www.HyundaiUSA.com/Campaign132. Hyundai's number for this recall is 132.

What owners say

1. Filed Jul 31, 2026100,000 miDEEngine

   The contact owns a 2012 Hyundai Sonata. The contact stated that while driving at 30 MPH, the check engine warning light illuminated, the engine started knocking, and smoke emitted from under the hood. The contact decelerated to approximately 15 MPH and drove to her nearby residence. Upon inspection, the contact observed green fluid under the hood. The vehicle was towed to an independent mechanic, where it was diagnosed that the engine had failed and the head gasket was…

   NHTSA complaint #11754020 · source
2. Filed Jul 30, 2026FLFireEngineOther / Unknown

   Vehicle engine caught fire in April 2026! Tow company sold for parts without my permission! Immediately after gaining possession of my car. I didn't have comprehensive insurance, only basic. I had a brain bleed stroke Nov. 2022 and this is causing stress, setbacks. No attorneys want to take the case because there was no injuries! I jumped out in time. THANK GOD!

   NHTSA complaint #11753672 · source
3. Filed Jul 29, 2026INEngineFuel, Hybrid & EV Propulsion

   Diagnosed 07/20/2026 with catastrophic oil ring failure requiring engine replacement. Engine can stall due to oil degradation/absence of causing uncontrolled vehicle handling and fire. This would put myself and others at risk. It has been diagnosed at dealership. Complaint Narrative: The subject vehicle is experiencing its third total engine failure due to an inherent manufacturing and design defect, presenting a severe and repeating highway safety hazard. The original…

   NHTSA complaint #11753470 · source
4. Filed Jul 15, 2026VAEngineOther / Unknown

   As I was merging onto the interstate I put my foot on the gas pedal to give it a little more gas then usual to get pulled out and all of a sudden all the lights on the dash board illuminated and it slowly lost all power I was able to move it out of the road ... There was no loud ,knocking or ticking noises prior to this happening there was no type of any kind of warning .. my car is the push start button so after the car died completely I hit the push button and all the…

   NHTSA complaint #11750478 · source
5. Filed Jun 30, 2026OHEngine

   Around the end of May 2026, my vehicle stalled without warning while traveling at highway speed. The engine light and EPS warning light illuminated simultaneously. The engine cranks but will not start. The vehicle was towed to a Hyundai dealership on June 15, 2026 where the engine failure was confirmed. My safety was directly at risk. The vehicle lost power on an active highway with no warning, creating a collision hazard for myself and other drivers. The failure has been…

   NHTSA complaint #11747461 · source
6. Filed Jun 16, 2026VAAirbagsEngineTransmission & Drivetrain

   Knock sensor needs to be replaced upon evaluation of an inspection on March 27, 2026. It failed a mission codes and upon my understanding the knock sensor one circuit range performance pink wonder single sensor is an engine failure as well as I did an ODB test myself on May 19 of 2026 for the Knox sensor as well and the check engine dominator reading at 2111 the the code indicated that bank one Knox and electrical circuit was out of it upper range or had it perform problem…

   NHTSA complaint #11744374 · source
7. Filed Jun 6, 2026VAEngine

   Vehicle experienced sudden loss of motive power while merging onto interstate I accelerated to enter traffic and all dashboard warning lights illuminated at once. Engine shut off immediately with no prior knocking,smoke, or warning. Car coasted to shoulder with complete loss of power steering and power brakes. After incident vehicle will not crank or restart , push -button start activates accessories but engine does not turn over when brake is pressed. Vehicle has Campaign…

   NHTSA complaint #11742443 · source
8. Filed Jun 5, 2026VAEngine

   While merging onto the interstate my vehicle suffered sudden loss of motive power. All dash lights illuminated ,engine shut off instantly with no prior knock or warning.vehicle will not crank or restart.push button start activates accessories only .This matches TSB 22-EM-003H for connecting rod bearing seizure.No crash occured because I was able to coast to shoulder but loss of power steering/brakes at highway speed created a dangerous situation.

   NHTSA complaint #11742366 · source
9. Filed Apr 21, 2026CAEngine

   I am reporting a pattern of systemic failures on a 2012 Hyundai Sonata Hybrid with approximately 131,000 miles. This is my second NHTSA complaint regarding this vehicle and manufacturer. Primary Safety Concern — Engine Wiring Harness: During a recent engine replacement at an authorized Hyundai dealership, technicians identified damage to the engine wiring harness and documented in writing that the owner “might have issues with drive ability.” The dealership declined to…

   NHTSA complaint #11732884 · source
10. Filed Apr 21, 2026168,000 miTXEngineLighting

    The contact owns a 2012 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, there was an abnormal burning odor coming from the vehicle. While depressing the accelerator pedal, the vehicle hesitated and stalled. The contact stated that the rear driver’s side brake light was inoperative. The failure occurred on several occasions. No warning lights were illuminated. The contact researched and was made aware of an undisclosed recall; however, the VIN…

    NHTSA complaint #11732852 · source
11. Filed Apr 3, 2026GAFire1 injuredElectrical SystemEngineFuel, Hybrid & EV Propulsion

    Vehicle: 2012 Hyundai Sonata Incident Date: August 14, 2024 Location: [XXX] Description of the Problem: The vehicle experienced a sudden and catastrophic fire without warning while in normal use. There were no prior warning lights, messages, or symptoms before the incident. The failure appears to have originated from the electrical system and/or engine (exact cause UNKNOWN), which resulted in the vehicle igniting unexpectedly. Safety Risk: This failure created an immediate…

    NHTSA complaint #11729048 · source
12. Filed Apr 2, 2026AZEngine

    I purchased a used 2012 Hyundai Sonata. Within about 2 weeks it broke down while I was in the far left lane of the freeway. The car suddenly stopped accelerating and made a very loud knocking noise. Thankfully I was able to put on my hazards and make it to the right shoulder without getting into an accident but as soon as I pulled over it shut off and the panel lights all came on. Evidently there was a recall on an engine rod and the previous owners advised they were not…

    NHTSA complaint #11728889 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology