2015 Hyundai Sonata fuel, hybrid & EV propulsion problems

Related recalls

No recalls on file.

What owners say

1. Filed Sep 11, 2026VAEngineFuel, Hybrid & EV Propulsion

   After receiving the Hyundai Service Campaign 9C2 update on my 2015 Hyundai Sonata on XXX, I have started having jerky acceleration when the car is first started and am driving. Also, while driving at highway speed (~65 mph)) and I take my foot off the accelerator to coast, the engine RPM drops suddenly, anywhere from 250 rpm to 750 rpm, then recovers abruptly to where it was at prior to the drop (typically around 2000 rpm). The engine rpm also drops while driving at slower…

   NHTSA complaint #11763571 · source
2. Filed Aug 19, 2026AZFuel, Hybrid & EV Propulsion

   Issue- fuel pump/supply line causing fuel to leak and fuel smell around the outside of the car. This can cause a major fire, explosion, death for myself and others around me. Problem has been confirmed by auto repair shop. No warning messages on car dash board, just strong smell of gas. Replaced gas cap and smell is still there.

   NHTSA complaint #11757985 · source
3. Filed Aug 6, 2026MAElectrical SystemFuel, Hybrid & EV PropulsionOther / Unknown

   1.) Following Hyundai's 9C2 Campaign update for the ECU that was completed back on May 27th, 2026, my 2015 Sonata went into limp mode [solid check engine light present] while I was accelerating up an on-ramp on the 2nd drive cycle since the update was performed. I was already far away from the dealership so I was forced to limp it to my local shop that I regularly use to have it checked out. It was confirmed that the code on the vehicle was P200A for intake manifold runners.…

   NHTSA complaint #11755317 · source
4. Filed May 1, 2026WIBrakesEngineFuel, Hybrid & EV Propulsion

   I have the 2015 Hyundai sonata with the 2.5 GDI engine that eventually will seize due to internal damaged caused by manufacture design flaws. My Hyundai threw a P0010 code which causes my car to idle high and causing low vacuum affecting my brakes. I had a diagnostic test done at a Hyundai dealership that told me it was a cvvt cam sprocket issue and that it was the beginning of the end of the engine, They quoted me 3700.00 but the engine was to far gone and this repair would…

   NHTSA complaint #11735056 · source
5. Filed Feb 17, 2026SCEngineFuel, Hybrid & EV PropulsionTransmission & Drivetrain

   Component/System Failed: Engine – connecting rod bearing failure consistent with Hyundai Theta II engine defect subject to federal recalls and Consent Orders. The vehicle previously received Recall Campaign 953 (KSDS software update), intended to detect premature rod bearing wear. The engine is currently knocking and has been diagnosed as requiring replacement. The vehicle and engine are available for inspection upon request. Safety Risk: Rod bearing failure can cause sudden…

   NHTSA complaint #11718641 · source
6. Filed Dec 2, 202555,300 miFLFuel, Hybrid & EV Propulsion

   The contact owns a 2015 Hyundai Sonata. The contact stated that while driving at 45 MPH, the vehicle suddenly stalled. The vehicle was parked on the side of the road and failed to immediately restart. The vehicle was later restarted and driven to the residence. The vehicle was taken to the local Auto Zone, but the cause of the failure was not yet determined. The vehicle was then taken to the local dealer to perform a diagnostic test. No further info was available, and the…

   NHTSA complaint #11702439 · source
7. Filed Aug 19, 2025TXFireEngineFuel, Hybrid & EV Propulsion

   I had a standard oil change done on my car and it was running fine afterwards. Later that evening, my car started smoking and spontaneously burst into flames from the hood. The fire originated in the hood of the car and melted the entire front of my car as well as the entire inside. It burned a lot of fuel and oil, which leaked onto the ground and continued burning on the ground. My car was overtaken by flames in a matter of a few minutes. It burned so fast that there was…

   NHTSA complaint #11681712 · source
8. Filed Jul 18, 2025TXFuel, Hybrid & EV Propulsion

   The plastic fuel pump housing cracked at a spot outside of the fuel tank. When the pump was running, the crack caused the pump to spray fuel outside of the gas tank where the fuel puddled on top of the tank and dripped down over the sides of the tank. During a non-related repair, my mechanic noticed the bottom of the fuel tank was wet with fuel. I'm lucky the plastic fuel pump crack was found before the spilled gas cause my car to catch fire.

   NHTSA complaint #11674506 · source
9. Filed Mar 19, 2025FLFuel, Hybrid & EV Propulsion

   The low pressure fuel line connector to the high pressure fuel pump failed and sprayed fuel over the hot engine. This could have easily cause a vehicle fire and death. This is a KNOW ISSUE and is covered by a safety recall on 2013-2014 Hyundai Sonatas (Hyundai Technical Service Bulletin 20-01-030H). The same issue occurred on this 2015 Sonata that was built in June 2015. A temporary repair had to be made until Hyundai could inspect it. Vehicle was taken to Holler Hyundai in…

   NHTSA complaint #11649349 · source
10. Filed Mar 18, 202585,000 miFLFuel, Hybrid & EV Propulsion

    The contact owns a 2015 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, there was an abnormally strong gasoline odor inside the vehicle. There was a warning light illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the fuel pump. The contact was informed that the fuel pump was leaking and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was…

    NHTSA complaint #11649010 · source
11. Filed Dec 23, 2024OHEngineFuel, Hybrid & EV Propulsion

    Approximately five weeks ago, my 2015 Hyundai Sonata showed a check engine light. I took it into the dealer and paid a diagnostic fee which revealed the third cylinder misfire in the engine. I paid to have the engine cleaned yet the light continues to stay on and the car has been Running low on oil every time it gets checked the dealer states that the engine needs to be replaced

    NHTSA complaint #11632108 · source
12. Filed Jul 29, 2024VAElectrical SystemEngineFuel, Hybrid & EV Propulsion

    I was driving on the highway and my engine violently started to shake and I pulled onto the shoulder and the engine shut off. I’ve had oil leak and engine problems with this car for 2 and a half out of 3 years! I’ve had to buy countless gallons of oil. Multiple spark plugs, coil packs, etc. You can’t drive the car for one whole minute without it stalling in traffic and almost causing accidents. So I can’t drive it!

    NHTSA complaint #11605266 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology