2018 Tesla Model X driver assistance & safety tech problems

Related recalls

• Recall 22V169000Mar 18, 2022947 vehicles
  BACK OVER PREVENTION:DISPLAY FUNCTION

  Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model S, Model X, and 2017-2020 Model 3 vehicles equipped with Autopilot Computer 2.5 and operating certain firmware releases. The rearview image may not immediately display when the vehicle begins to reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

  Risk: A delayed rearview camera image reduces the driver's rear view, increasing the risk of a crash.

  Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed May 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-004.

• Recall 21V846000Oct 29, 202111,728 vehicles
  FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING · FORWARD COLLISION AVOIDANCE: SENSING SYSTEM: CAMERA · FORWARD COLLISION AVOIDANCE:SOFTWARE · FORWARD COLLISION AVOIDANCE: WARNINGS

  Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.

  Risk: Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.

  Remedy: Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.

• Recall 21V035000Jan 29, 2021134,951 vehicles
  BACK OVER PREVENTION:SOFTWARE · EXTERIOR LIGHTING:TURN SIGNAL · VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

  Tesla, Inc. (Tesla) is recalling certain 2012-2018 Tesla Model S and 2016-2018 Model X vehicles with a center display equipped with a NVIDIA Tegra 3 processor and an 8GB eMMC NAND flash memory device. When the 8GB eMMC NAND flash memory device for the center display reaches lifetime wear, the eMMC controller will no longer be able to maintain the integrity of the filesystem, causing a failure in some of the center display functions.

  Risk: The eMMC controller wear-out condition can cause the loss of the rearview camera display, defrost/defog control settings, and exterior turn signal lighting, reducing visibility and increasing the risk of a crash.

  Remedy: Owners should ensure their vehicles are operating firmware release 2020.48.48.12 or newer, which will alert owners if the eMMC is approaching lifetime wear. Tesla will notify owners, and will replace the VCM daughterboard with one containing an enhanced eMMC controller, free of charge. The recall began March 29, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-21-001.

What owners say

1. Filed Aug 16, 2026MIDriver Assistance & Safety Tech

   My vehicle intermittently and without warning disables Autopilot/cruise control while driving, most consistently during hard acceleration from a stop or low speed. The touchscreen displays "Take Over Immediately" and Autopilot becomes completely unavailable for the remainder of the drive. The system only resets after the vehicle is parked and allowed to sit. This has occurred repeatedly over multiple weeks, documented via the vehicle's own Service Mode diagnostic logs,…

   NHTSA complaint #11757282 · source
2. Filed Aug 3, 2026WACrash2 injuredTowedDriver Assistance & Safety TechAcceleration & Cruise Control

   While driving on FSD (Full Self Driving) the vehicle was turning off the road into a parking lot and sped up and hit a vehicle while I was pressing the brake to the floor! I had to brace for impact when I hit the vehicle. I have requested the data and telemetry logs from Tesla. Everything was fine before the crash. Husband had a similar incident a few weeks ago where he was turning with FSD engaged and the vehicle stopped in the middle of the turn with a vehicle coming right…

   NHTSA complaint #11754460 · source
3. Filed Jul 1, 2025CACrashTowedDriver Assistance & Safety Tech

   Tesla X in full self driving mode failed to lower speed and detect stopped in-lane vehicle on a very sharp turn, crashing into the back of the vehicle at significant speed.

   NHTSA complaint #11670550 · source
4. Filed Jun 30, 2025NCDriver Assistance & Safety TechSuspension

   I was driving down the road and my car started shaking, I was about 5 or 6 miles from an exit so continued and within 1 mile a rod broke and fell on top of my tire causing me to catastrophically have to stop n swerve off the road in 5 o'clock traffic. I just purchased this car 3 months ago, no issues just happend all of sudden. There are reports of weak suspension parts for tesla specifically the model x and y. The suspension parts need to be recalled. I was VERY lucky to…

   NHTSA complaint #11670369 · source
5. Filed May 5, 2025MADriver Assistance & Safety Tech

   Our Tesla Model X is failing recently with several issues as listed below: 1. 'Autiopilot disabled' - Autopilot was not available to use since 09/2024 after upgraded to 12.x FSD upgrade. Tesla service diagnosed in 11/2024 with some error connected to evaporator fan, advised me to replace the kit at an estimated $580 2. 'Unable to start' - HV battery failed on 03/06/2025 with series of failures that was reported to NHTSA (VOQ#11651899). Tesla replaced the battery, and service…

   NHTSA complaint #11659042 · source
6. Filed Mar 23, 2025AZBrakesDriver Assistance & Safety Tech

   Based on thousands of posts, replies, etc, this seems to be a well known issue with this model/year Tesla as well as other years/models. It seems that the Wheel Sensor Cable is not fastened properly, and over time, the cable runs against the tire, causing the internal wires to be exposed, this in turn causes numerous faults to occur, which includes causing ABS, lane departure avoidance, traction control, stability control, ABS, and regenerative braking to stop working. This…

   NHTSA complaint #11650036 · source
7. Filed Jan 23, 2025FLTowedAirbagsDriver Assistance & Safety TechSeats & Seat Belts

   ‘safety restraint system issue’ error pops up when ever car is turned on was told that can cause airbag to not be deployed when needed.

   NHTSA complaint #11638080 · source
8. Filed Oct 29, 2024CADriver Assistance & Safety TechTransmission & Drivetrain

   While driving on highway with autopilot on . I received the message "Steering Assist reduced .Vehicle will require additional force to steer". I believe I hit a rough patch on the highway and my steering lost power and became very hard to steer the vehicle. Somehow I managed to drive for 20 miles to safety. When I recached home I did power reset few times and the issue went away. I noticed similar issues with model x but not for year 2018 Model x. I have opened a service…

   NHTSA complaint #11622588 · source
9. Filed Mar 25, 2024NVDriver Assistance & Safety TechElectrical SystemSteering

   I was driving on [XXX] from Carson City to Reno in Washoe Valley while on autopilot, the car suddenly alerted with very loud alarms, showed 1. steering assist reduced, 2. Automatic Emergency Braking is unavailable 3. Traction Control disabled 4. Stability control disabled 5. Park Assist unavailable. I pulled over to a safe parking area. Then the car locked out for 75 mins, in Neutral gear, can't shut off, can't park, can't reset the car at all even after talking to Tesla…

   NHTSA complaint #11579414 · source
10. Filed Feb 27, 2024CADriver Assistance & Safety Tech

    The vehicle was in cruise control and had a phantom braking event. The vehicle was going at 70 mph and suddenly braked even though there was significant distance between the car in front and nothing on the road. The sun was glaring on the road and possibly the car detected the shadow on the road as an object and braked because of it.

    NHTSA complaint #11574320 · source
11. Filed Feb 23, 2024PADriver Assistance & Safety Tech

    The Tesla recall under NHTSA Recall No: 23V-838 has not been completed by Tesla. The upgraded computer I purchased from Tesla and had installed in December 2021 cannot accept the OTA update. Tesla is requesting that I replace the computer again for 2 thousand dollars for the recall OTA. Telsa said my current computer has an internal bug and needs to be replaced. I should not have to spend 2K for another computer that barely lasted 2 years.

    NHTSA complaint #11573662 · source
12. Filed Nov 10, 2023ORCrashTowedDriver Assistance & Safety Tech

    The Full Self Driving System failed to operate correctly. This caused my car to hit another car. I have asked Tesla for the data they use to tell what the driver was doing when the system was on but the Tesla staff who respond to my requests plead ignorance of what data I am referring to. I am not ready to spend the money it would cost to hire a lawyer to force Tesla to hand over the data from their system. I have video from the Tesla camera showing what happens. I will try…

    NHTSA complaint #11554607 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology