2015 Toyota Prius brakes problems

Related recalls

No recalls on file.

What owners say

1. Filed Oct 3, 2026CABrakesDriver Assistance & Safety Tech

   The brake booster pump has malfunctioned, exactly 1 year outside of the secondary coverage supplied in the voluntary customer support program for this exact issue, despite being under 150,000 miles. Now the car is unsafe to drive since the brakes are malfunctioning.

   NHTSA complaint #11768653 · source
2. Filed Sep 17, 2026CABrakes

   I am reporting an active, severe safety hazard regarding the braking system on my 2015 Toyota Prius ( Mileage: 79,000). The vehicle has been officially diagnosed by Toyota Culver City with Diagnostic Trouble Code DTC C1391, confirming an internal failure and lack of pressure within the brake booster/actuator assembly. This component defect causes an immediate compromise to the vehicle's braking efficiency and hydraulic pressure, causing a sudden loss of braking power and…

   NHTSA complaint #11765138 · source
3. Filed Aug 31, 2026HIBrakes

   Problem: Brake Actuator is pulsing the Booster Pump to keep running intermittently, 5-10 seconds. Console lights lit up for ABS problem. Does not clear. Toyota Dealership Report: DCT C1391 Abnormal Leak: Monitored TEH Accumulator Pressure and its not holding pressure. Pump keeps running. Rec[ommend] Brake Actuator and Booster Pump Assembly [replacement].` ServCo Toyota dealership in Hawaii Report: Submitted Prior Authorization request with Toyota Hawaii Warranty. Request…

   NHTSA complaint #11760825 · source
4. Filed Aug 26, 2026NVBrakes

   On XXX, I was driving my 2015 Toyota Prius with my family in the vehicle and approaching stopped traffic on dry pavement. An emergency vehicle was approaching from behind, so I began braking earlier than usual. When I applied the brakes, the vehicle did not stop normally. The front slowed/stopped while the rear of the Prius suddenly slid sideways toward the adjacent lane, bringing the rear passenger side dangerously close to another vehicle. Had I begun braking at my normal…

   NHTSA complaint #11759804 · source
5. Filed Aug 11, 2026CABrakesDriver Assistance & Safety Tech

   Code DTC C1391 - Abnormal leak of accumulator pressure. Internal failure of the brake booster pump assembly, preventing the system from maintaining proper hydraulic pressure. This means the brakes don't work, putting the driver's and passengers' lives at risk. This DTC C1391 code and problem were reproduced and confirmed by an independent service center who specializes in 3rd generation priuses. There were warning lights that lit up when the brakes failed - the ABS, traction…

   NHTSA complaint #11756229 · source
6. Filed Jun 25, 2026CABrakes

   The vehicle experienced a failure in the braking system involving the brake booster/brake actuator assembly. The vehicle displayed diagnostic trouble code C1391, which is associated with a malfunction of the brake booster pump/accumulator system on this model. The failed component is available for inspection upon request. The failure created a safety concern because the braking system warning lights illuminated and the vehicle’s brake assist system may not function properly.…

   NHTSA complaint #11746503 · source
7. Filed Jun 10, 2026121,000 miAZBrakes

   The contact owns a 2015 Toyota Prius. The contact stated that while driving at 45 MPH, the brake warning lights illuminated. The brakes were inoperable and entered manual mode. The contact stated that the brake warning lights were red and yellow. The vehicle was taken to Brake Masters, where it was diagnosed with brake actuator failure. The local dealer was contacted but did not provide assistance. The vehicle was not repaired. The manufacturer was not notified of the…

   NHTSA complaint #11743224 · source
8. Filed Jun 9, 2026GABrakesElectrical System

   The incident involved having to press extremely hard on the brake pedal to stop the car, while it was uphill in the middle of the road. The car started going backward and was throwing ABS, Master Warning Light, Brake System Warning Light and Warning Buzzer, Brake System Warning Light, and SLIP Indicator signals. This was a highly distraughtful situation on the road. Diagnostics showed C1391 Diagnostic Trouble Code on the 2015 Toyota Prius: brake booster and brake booster…

   NHTSA complaint #11742921 · source
9. Filed Jun 3, 2026GABrakesElectrical System

   The brake pump and actuator on my 2015 prius has been faulty and the repair was apparently covered under the customer support program but it expired in December. I had no knowledge of it and when I took my car in to a toyota dealership, no one told me about about the profram but told me that they needed to be replaced. I did not get the repair because of the hefty cost and I missed the deadline. My safety and the safety of other drivers were put at risk for not allowing me…

   NHTSA complaint #11741829 · source
10. Filed May 26, 2026CABrakesDriver Assistance & Safety Tech

    Code C1391 200k miles All the warning signs for brake booster issue came up. The cost is too high and I just missed the Customer Support Program timelines because the code came up late. This needs to be a RECALL, based on how many people experience this issue consistently.

    NHTSA complaint #11740166 · source
11. Filed May 26, 2026CABrakes

    I was driving my 2015 prius for years and occasionally the brake, abs and traction light would come on this is a sign of a failing Brake actuator and booster. Toyota and the Ntsb ordered the following warranty enhancement https://static.nhtsa.gov/odi/tsbs/2020/MC-10181800-9999.pdf My Brake Booster had been exhibiting signs of failing for years and I tried to get a toyota dealership to replace and repair the parts under the warranty extension but I was told I had to wait…

    NHTSA complaint #11740085 · source
12. Filed May 10, 2026CABrakes

    Toyota Prius has a known problem with the brake actuator and booster. A notice was sent out in 2019 under the Customer Support Program Expansion with repairs up to 10 years or 150k miles. This is a safety issue and should be covered under a recall with NO TIME OR MILEAGE LIMITS since these problems are not showing up until after 10 years if the car has low mileage, as in our case. We just passed the 10 year mark, but only has 114k miles. No mention of repairs needed were…

    NHTSA complaint #11736895 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology