2015 Toyota Prius problems, complaints & recalls

2015 Toyota Prius recalls (1)

• Recall 20V369000Jun 24, 2020266,638 vehicles
  HYBRID PROPULSION SYSTEM: INVERTER

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2015 Prius and 2014-2017 Prius V vehicles not included in recall 18V-684. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.

  Risk: An unexpected hybrid power system shut down may increase the risk of a crash.

  Remedy: Toyota will notify owners, and dealers will perform a software update for the hybrid system. If the vehicle has experienced an inverter failure with certain hybrid system faults related to this condition, the inverter assembly will be repaired or replaced, prior to software update. All repairs will be performed free of charge. This recall began July 24, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is 20TB10 / 20TA10.

NHTSA defect investigations

• DP23005Opened Nov 22, 2023Open

  Brake Actuator Valve Wear

  The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additi…

• DP22005Opened Jan 27, 2023Closed Aug 7, 2023led to recall 22V063000

  Pedestrian alert sounds

  NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after Marc…

• DP19004Opened Sep 30, 2019Closed Jan 21, 2021

  Brake Actuator Valve Wear

  On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s requ…

Recent 2015 Toyota Prius complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Oct 3, 2026CABrakesDriver Assistance & Safety Tech

   The brake booster pump has malfunctioned, exactly 1 year outside of the secondary coverage supplied in the voluntary customer support program for this exact issue, despite being under 150,000 miles. Now the car is unsafe to drive since the brakes are malfunctioning.

   NHTSA complaint #11768653 · source
2. Filed Sep 17, 2026CABrakes

   I am reporting an active, severe safety hazard regarding the braking system on my 2015 Toyota Prius ( Mileage: 79,000). The vehicle has been officially diagnosed by Toyota Culver City with Diagnostic Trouble Code DTC C1391, confirming an internal failure and lack of pressure within the brake booster/actuator assembly. This component defect causes an immediate compromise to the vehicle's braking efficiency and hydraulic pressure, causing a sudden loss of braking power and…

   NHTSA complaint #11765138 · source
3. Filed Aug 31, 2026HIBrakes

   Problem: Brake Actuator is pulsing the Booster Pump to keep running intermittently, 5-10 seconds. Console lights lit up for ABS problem. Does not clear. Toyota Dealership Report: DCT C1391 Abnormal Leak: Monitored TEH Accumulator Pressure and its not holding pressure. Pump keeps running. Rec[ommend] Brake Actuator and Booster Pump Assembly [replacement].` ServCo Toyota dealership in Hawaii Report: Submitted Prior Authorization request with Toyota Hawaii Warranty. Request…

   NHTSA complaint #11760825 · source
4. Filed Aug 26, 2026NVBrakes

   On XXX, I was driving my 2015 Toyota Prius with my family in the vehicle and approaching stopped traffic on dry pavement. An emergency vehicle was approaching from behind, so I began braking earlier than usual. When I applied the brakes, the vehicle did not stop normally. The front slowed/stopped while the rear of the Prius suddenly slid sideways toward the adjacent lane, bringing the rear passenger side dangerously close to another vehicle. Had I begun braking at my normal…

   NHTSA complaint #11759804 · source
5. Filed Aug 11, 2026CABrakesDriver Assistance & Safety Tech

   Code DTC C1391 - Abnormal leak of accumulator pressure. Internal failure of the brake booster pump assembly, preventing the system from maintaining proper hydraulic pressure. This means the brakes don't work, putting the driver's and passengers' lives at risk. This DTC C1391 code and problem were reproduced and confirmed by an independent service center who specializes in 3rd generation priuses. There were warning lights that lit up when the brakes failed - the ABS, traction…

   NHTSA complaint #11756229 · source
6. Filed Jul 28, 2026NCCrash1 injuredTowedSeats & Seat Belts

   I was rear-ended by a truck in my prius and my seat laid back on impact. I'm unaware if that was an intended thing or not but it potentially could have injured my neck. My car is currently in a storage lot awaiting the adjustor's inspection so it is available for inspection if needed. No warning lights were available and it hasn't been recreated by the dealer

   NHTSA complaint #11753382 · source
7. Filed Jul 15, 2026CACrashTowedElectrical SystemEngine

   Pulling out of a parking stall, when put vehicle in drive, the engine revved up and accelerated - vehicle crashed, the brakes did not work- there was skid marks. Floor mats are factory OEM were installed properly. I did not hit the accelerator and I am in good health and mind. I have driving for over 30 years, never had and accident nor a ticket! - A county officer was at the seen and left me with vehicle that had to be towed away. The Vehicle is a total loss. I have…

   NHTSA complaint #11750516 · source
8. Filed Jun 25, 2026CABrakes

   The vehicle experienced a failure in the braking system involving the brake booster/brake actuator assembly. The vehicle displayed diagnostic trouble code C1391, which is associated with a malfunction of the brake booster pump/accumulator system on this model. The failed component is available for inspection upon request. The failure created a safety concern because the braking system warning lights illuminated and the vehicle’s brake assist system may not function properly.…

   NHTSA complaint #11746503 · source

Compare the 2015 Toyota Prius with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 10, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology