2010 Toyota Prius problems, complaints & recalls

2010 Toyota Prius recalls (10)

• Recall 18V684000Oct 4, 2018807,329 vehicles
  HYBRID PROPULSION SYSTEM

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.

  Risk: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.

  Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.

• Recall 16V487000Jun 30, 2016482,002 vehicles
  AIR BAGS:SIDE/WINDOW

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.

  Risk: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.

  Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.

• Recall 16V396000Jun 2, 20167,749 vehicles
  SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

  Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

  Risk: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

  Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

• Recall 14V743000Nov 19, 20143,233 vehicles
  SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

  Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

  Risk: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

  Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

• Recall 14V053000Feb 12, 2014698,457 vehicles
  ELECTRICAL SYSTEM:SOFTWARE · HYBRID PROPULSION SYSTEM: INVERTER

  Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.

  Risk: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.

  Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.

• Recall 13V235000Jun 5, 201387,060 vehicles
  SERVICE BRAKES

  Toyota is recalling certain model year 2010 Prius vehicles manufactured March 31, 2009, through October 9, 2009; and model year 2010 Lexus HS250h vehicles manufactured June 19, 2009, through October 9, 2009. Nitrogen gas from a component of the brake booster pump assembly could leak into the brake fluid.

  Risk: As nitrogen is released into the brake fluid, the brake pedal may have reduced hydraulic pressure. Under certain circumstances, this condition could affect stopping distance and increase the risk of a crash.

  Remedy: Toyota will notify owners, and dealers will replace the affected brake booster pump assemblies. The recall began on August 7, 2013. Owners may contact Toyota at 1-800-331-4331.

• Recall 13V014000Jan 16, 20133,235 vehicles
  AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE · SEATS

  Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

  Risk: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

  Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

• Recall 10V039000Feb 9, 2010148,549 vehicles
  SERVICE BRAKES, AIR:ANTILOCK:CONTROL UNIT/MODULE

  Toyota is recalling certain model year 2010 toyota prius and lexus hs250h passenger vehicles. Customers have experienced inconsistent brake feel after abs actuation during slow and steady application of the brakes on rough or slick road surfaces. Stopping distances may be increased compared with a customer's expectation for a given pedal force.

  Risk: Vehicle stopping distances may increase relative to a customer's expectation increasing the risk of a crash.

  Remedy: Dealers will rewrite the programming of the abs control unit free of charge. The safety recall began on march 3, 2010, and is expected to be completed in late march 2010. Owners may contact toyota at 1-800-331-4331 and lexus at 1-800-255-3987.

• Recall 10V035000Feb 3, 2010271,417 vehicles
  EQUIPMENT:OTHER:LABELS

  Gulf states toyota is recalling certain model year 2005-2010 vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold between september 1, 2005 and june 2, 2008 without the requisite load carrying capacity modification labels.

  Risk: This does not meet the standard requirements.

  Remedy: Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. Dealers will also correct the owner's manual. The safety recall began on may 27, 2010. Owners may contact gulf states toyota at 713-580-3300.

• Recall 10V036000Feb 3, 2010153,418 vehicles
  EQUIPMENT:OTHER:LABELS

  Southeast toyota is recalling certain model year 2005-2011 passenger vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold without the requisite load carrying capacity modification labels.

  Risk: A driver may overload a vehicle which may increase the risk of a crash.

  Remedy: Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. The safety recall began on may 27, 2010. Owners may contact southeast toyota at 1-800-301-6859.

NHTSA defect investigations

• DP23005Opened Nov 22, 2023Open

  Brake Actuator Valve Wear

  The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additi…

• DP22005Opened Jan 27, 2023Closed Aug 7, 2023led to recall 22V063000

  Pedestrian alert sounds

  NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after Marc…

• DP19004Opened Sep 30, 2019Closed Jan 21, 2021

  Brake Actuator Valve Wear

  On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s requ…

• PE10006Opened Feb 3, 2010Closed Jul 12, 2010

  Braking Performance, Hybrid Vehicle

  The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic brake system more typical of the brake system used on non-hybrid vehicles.As is the case for other similarly designed hybrid vehicles the interaction and management of the two braking systems during ABS braking is complex and requires a sophisticated control system.In a February 9, 2010 Defect Inform…

Recent 2010 Toyota Prius complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Oct 6, 2026WILighting

   The low-beam headlight bulbs on my 2010 Toyota Prius keep burning out, about every [6 months or less]. Since I have owned the vehicle I have replaced them too many times to count, on both sides, but twice as often on the drivers side. The most recent failure was on XXX, my driver low beam failed while I was driving at night on a county highway in heavy rain. Visibility was already poor, and I was stopped by law enforcement because of the burned-out headlight. I was given a…

   NHTSA complaint #11769259 · source
2. Filed Sep 13, 2026CABrakes

   Subject: Vehicle Safety Defect Complaint / Request for Investigation Review Vehicle: 2010 Toyota Prius VIN: [XXX] Component: Electronic Brake Booster / Pressure Accumulator Assembly Dear Administrator, I am writing to formally report a critical safety defect in my 2010 Toyota Prius regarding the electronic brake booster and accumulator pump assembly. This component exhibits classic failure symptoms—specifically a distinct puffing, ticking, and pressure-loss noise directly…

   NHTSA complaint #11763884 · source
3. Filed Aug 27, 2026CABrakes

   Component failed: Brake actuator and accumulator on a 2010 Toyota Prius. It is available for inspection upon request. Safety: ABS, traction, and brake lights turned on suddenly in the middle of rush-hour traffic, followed by a spongey, hard-to-press pedal. Braking distance and efficiency was greatly impacted, and driving to a safe turn-out was extremely dangerous as I feared the brakes would give out entirely at any moment. The problem has been reproduced and confirmed by a…

   NHTSA complaint #11760155 · source
4. Filed Aug 25, 2026TXBody & StructureBrakes

   To Whom It May Concern, I am writing to formally complain about the way Toyota has handled the problems with my 2010 Toyota Prius and my repeated requests for assistance. I have been a loyal Toyota customer and have purchased two new Toyota vehicles because I trusted Toyota's quality and expected good customer service. Unfortunately, after years of contacting Toyota, I have repeatedly been given the runaround without receiving a meaningful resolution. I am now facing a…

   NHTSA complaint #11759364 · source
5. Filed Jun 4, 2026CABrakes

   ABS light came on 6 months ago as well as ((!)) light. As soon as those lights came on, the brakes had an increased stopping distance and it became harder to get the car to come to a complete stop. I have seen a few Prius owners in my area also having the same problem with their Prius. For my car, the ABS light would come on, then turn off for 300 or so miles, then turn back on and stay on for about 300 miles. That has lasted for 6 months. I had almost gotten in an accident…

   NHTSA complaint #11742107 · source
6. Filed May 5, 202675,000 miNHElectrical System

   The contact owns a 2010 Toyota Prius. The contact stated that while driving at an undisclosed speed, a strong and unusual odor was detected inside the vehicle with no warning lights illuminated. The contact further stated that the following day, upon entering the vehicle, both the contact and the contact’s spouse experienced headaches, nausea, and cognitive discomfort. Concerned about possible exposure to harmful fumes, the contact inspected the vehicle and determined that…

   NHTSA complaint #11735753 · source
7. Filed Apr 22, 2026COBrakes

   My 2010 Prius has experienced the following error codes: C12341 and C1391, prompting the dealer to recommend replacing the brake booster assembly and master cylinder for $3938.89. This is a known issue with this vehicle and a Customer Support Program (CSP) was issued back in 2018, stating that if this vehicle displayed these codes, the repairs would be at no charge to the customer. Toyota extended this coverage to 10 years from date of first use or 150,000 miles (whichever…

   NHTSA complaint #11732957 · source
8. Filed Mar 29, 2026GABrakes

   There are issues with the brake. Many times the brake pedal goes down to the floor and it losses ability to stop. Apparently there is a common ABS actuator and Brake issues. Toyota will not address the issue

   NHTSA complaint #11727774 · source

Compare the 2010 Toyota Prius with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 11, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology